NHTSA vehicle safety data
1997 Thomas Conventional Recalls & Complaints
The 1997 Thomas Conventional has 8 NHTSA recall campaigns on file as of October 21, 2026. try.vin has no NHTSA owner complaints on file for the 1997 Thomas Conventional. Recall repairs are usually free at an authorized Thomas dealer.
NHTSA recall and complaint data for the 1997 Thomas Conventional. Recall data is refreshed daily from NHTSA.
THOMAS BUILT/FMVSS 222/STORAGE COMPARTMENT
NHTSA #00V360000 · Unknown or Other · NHTSA notice
Reported November 3, 2000 · THOMAS BUILT BUSES, INC.
Potentially affected: 11,500 vehicles
Owners notified February 8, 2002 · Vehicles built January 1, 1977 – October 15, 2000 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES EQUIPPED WITH A STORAGE COMPARTMENT OVERHEAD TO THE LEFT OF THE DRIVER FAIL TO MEET FMVSS NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."
Safety consequence
CONTACT WITH THIS STORAGE COMPARTMENT DOES NOT MEET THE IMPACT ZONE REQUIREMENTS OF THE STANDARD.
Manufacturer remedy
DEALERS WILL ADD PADDING TO THE SIDES OF THE STORAGE COMPARTMENT. OWNER NOTIFICATION BEGAN FEBRUARY 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
THOMAS BUILT/DRIVER SEAT BRACKET
NHTSA #00V362000 · Seats · NHTSA notice
Reported November 3, 2000 · THOMAS BUILT BUSES, INC.
Potentially affected: 6,500 vehicles
Owners notified February 9, 2001 · Vehicles built April 1, 1996 – September 30, 2000 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES AND TRANSIT BUSES EQUIPPED WITH NATIONAL SEATING'S SERIES 93B-SB DRIVER SEAT. A BRACKET ATTACHING THE GAS SPRING SHOCK TO THE HEIGHT ADJUSTER OF THE SEAT CAN DEFORM AND BREAK. THIS BRACKET IS LOCATED AT THE TOP OF THE HEIGHT ADJUSTER.
Safety consequence
IF THE BRACKET IS NOT REPLACED AFTER DEFORMING, AND IS ALLOWED TO BREAK, ITS BREAKING WILL RESULT IN A SUDDEN DROP OF THE DRIVER'S SEAT, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE AND A CRASH.
Manufacturer remedy
DEALERS WILL REPLACE THE SEAT BASE AND ADD REINFORCEMENT TO THE SEAT ASSEMBLY
Notes
OWNER NOTIFICATION BEGAN FEBRUARY 9, 2001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT ATALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SEAT BELT TETHER BELTS
NHTSA #99V175000 · Seats · NHTSA notice
Reported July 2, 1999 · THOMAS BUILT BUSES, INC.
Potentially affected: 744 vehicles
Owners notified March 31, 2000 · Vehicles built July 1, 1995 – January 4, 1999 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES EQUIPPED WITH AIR SUSPENSION DRIVER SEAT. TETHER BELTS USED TO ANCHOR THE SEAT BELT ASSEMBLY TO THE FLOOR WERE NOT INSTALLED ON BUSES EQUIPPED WITH AN AIR RIDE DRIVER SEAT. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Safety consequence
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Manufacturer remedy
DEALERS WILL INSTALL THE TETHER BELT ASSEMBLY.
Notes
OWNER NOTIFICATION BEGAN MARCH 31, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-881-7219.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
THOMAS BUILT/FMVSS 222
NHTSA #99V173000 · Seats · NHTSA notice
Reported July 2, 1999 · THOMAS BUILT BUSES, INC.
Potentially affected: 2,175 vehicles
Owners notified May 5, 2000 · Vehicles built July 1, 1995 – October 1, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: SCHOOL BUSES. RESTRAINING BARRIERS AND REINFORCEMENT PLATES MAY BE INSTALLED INCORRECTLY. NUTS USED TO SECURE THE PLATE THE FLOOR MAY BE MISSING OR THE REINFORCEMENT PLATE MAY BE MOUNTED IN A NON-STANDARD LOCATION. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."
Safety consequence
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Manufacturer remedy
DEALERS WILL INSPECT THE BARRIERS AND PLATES, INSTALL ANY NUTS THAT ARE MISSING, AND MOUNT THE REINFORCEMENT PLATE CORRECTLY.
Notes
OWNER NOTIFICATION BEGAN MAY 5, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-881-7219.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
THOMAS BUILT/FMVSS 111/MIRRORS
NHTSA #98V309000 · Visibility — Rearview Mirrors/Devices — Exterior · NHTSA notice
Reported December 7, 1998 · THOMAS BUILT BUSES, INC.
Potentially affected: 500 vehicles
Owners notified April 27, 1999 · Vehicles built June 1, 1993 – November 30, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: SCHOOL BUSES BUILT ON A NAVISTAR CHASSIS. THE CROSS VIEW MIRRORS DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 111, "REARVIEW MIRRORS." THE ENTIRE TOP SURFACE OF CYLINDER H IS NOT VISIBLE AS REQUIRED.
Safety consequence
A DRIVER MAY NOT BE ABLE TO SEE CERTAIN PORTIONS OF THE BUS INCREASING THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS NEAR THE BUS.
Manufacturer remedy
OWNERS WILL BE PROVIDED WITH A REPAIR KIT AND DETAILED INSTRUCTIONS. IF AN OWNER SO DESIRES, THOMAS BUILT DEALERS CAN PERFORM THE REPAIR FOR THEM.
Notes
OWNER NOTIFICATION BEGAN APRIL 27,1999. OWNERS WHO DO NOT RECEIVE THE FREE REPAIR KIT AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-910-889-4871.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
THOMAS BUILT/DRIVER'S SEAT
NHTSA #98V229000 · Seats · NHTSA notice
Reported September 17, 1998 · THOMAS BUILT BUSES, INC.
Potentially affected: 4,300 vehicles
Owners notified December 7, 1998 · Vehicles built April 1, 1996 – April 10, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH NATIONAL SEATING SERIES 93B-SB DRIVER SEAT. A BRACKET ATTACHING TO THE HEIGHT ADJUSTING SHOCK ABSORBER ON THE DRIVER'S SEAT CAN DEFORM AND BREAK.
Safety consequence
THIS CONDITION CAN RESULT IN A SUDDEN DROP OF THE DRIVER'S SEAT, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE AND A CRASH.
Manufacturer remedy
DEALERS WILL ADD A REINFORCEMENT TO THE BRACKET, OR IF THE BRACKET IS DEFORMED AND/OR BROKEN, THE ENTIRE SEAT BASE WILL BE REPLACED.
Notes
OWNER NOTIFICATION BEGAN DECEMBER 7, 1998.OWNERS WHO TAKE THEIR BUSES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-841-5991.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
THOMAS BUILT/FMVSS 111/MIRRORS
NHTSA #98V011000 · Visibility — Rearview Mirrors/Devices · NHTSA notice
Reported January 21, 1998 · THOMAS BUILT BUSES, INC.
Potentially affected: 241 vehicles
Owners notified April 8, 1998 · Vehicles built March 1, 1997 – March 31, 1998 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: SCHOOL BUSES. THESE VEHICLES DO NOT COMPLY WITH THE VISIBILITY REQUIREMENTS OF FMVSS NO. 111, "REARVIEW MIRRORS."
Safety consequence
THE DRIVER OF THE BUS MAY NOT HAVE A CLEAR AND UNOBSTRUCTED VIEW TO THE REAR.
Manufacturer remedy
NEW MIRRORS WHICH INCORPORATE MIRROR ARMS THAT WILL MOVE THE CROSS VIEW MIRRORS FORWARD WILL BE INSTALLED ON THESE VEHICLES.
Notes
OWNER NOTIFICATION BEGAN APRIL 8, 1998. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-910-889-4871.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
THOMAS BUILT/FMVSS 222/SEATS
NHTSA #97V192000 · Seats · NHTSA notice
Reported November 1, 1997 · THOMAS BUILT BUSES, INC.
Potentially affected: 2,391 vehicles
Owners notified March 8, 1999 · Vehicles built December 22, 1995 – September 3, 1997 (per NHTSA)
Defect description
VEHICLE DESCRIPTION: SCHOOL BUSES. THE FLIP SEATS INSTALLED ON THESE BUSES DO NOT MEET THE REARWARD PUSH REQUIREMENTS OF FMVSS NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."
Safety consequence
IN THE EVENT OF A VEHICLE CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY PROTECTED INCREASING THE RISK OF PERSONAL INJURY.
Manufacturer remedy
OWNERS WILL BE PROVIDED WITH REPAIR PARTS AND A DETAILED REPAIR PROCEDURE. IF AN OWNER SO DESIRES, THOMAS BUILT WILL PERFORM THE REPAIR FOR THEM.
Notes
OWNER NOTIFICATION BEGAN MARCH 8, 1999.A PRELIMINARY OWNER NOTIFICATION LETTER WAS MAILED JUNE 12, 1998.OWNERS WHO DO NOT RECEIVE THE FREE REPAIR PARTS AND DETAILED REPAIR PROCEDURE WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-910-889-4871. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Other Thomas Conventional model years
Check your 1997 Thomas Conventional VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thomas Conventional at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Thomas VIN