NHTSA vehicle safety data

2006 Pontiac Montana Recalls & Complaints

The 2006 Pontiac Montana has 2 NHTSA recall campaigns and 37 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Pontiac dealer.

NHTSA recall and complaint data for the 2006 Pontiac Montana. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Pontiac Montana owner complaints

Owners have filed 37 complaints with NHTSA about the 2006 Pontiac Montana, describing incidents dated July 1, 2005 to October 1, 2020.

Most-cited components

Electrical System 8 complaints
Engine 7 complaints
Electronic Stability Control (ESC) 5 complaints
Service Brakes 5 complaints
Structure 5 complaints
Suspension 5 complaints

Of the 37 complaints on file, 2 report a crash; across all 37 complaints, owners report 3 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11363656 · Filed October 10, 2020
WHEN HAVING MY OIL CHANGED AT A GARAGE WHILE THE VEHICLE WAS ON THE LIFT BOTH FRAME RAILS HAD SEVERE RUST DAMAGE. SINCE THIS IS WHAT GIVES THE UNIBODY FRAME IT'S STRENGTH, WHY DIDN'T GM ZINC COAT THEM OR APPLY RUST PROOFING? I LIVE IN SOUTHEAST MICHIGAN WHERE THEY USE SALT ON THE ROADS IN WINTER…
ODI #11306546 · Filed February 2, 2020
WHEN IT'S COLD AND YOU START THE VEHICLE I GET A MESSAGE REDUCED ENGINE POWER. YOU HAVE TO IMMEDIATELY SHUT IT OFF. SOM ETIMES WHEN YOU ARE DRIVING DOWN THE ROAD AND IT IS WARMED UP IT WILL DO THIS AND YOU HAVE TO FIND A SAFE PLACE TO PULL OVER BECAUSE IF YOU TRY TO GIVE IT GAS IT WON'T GO ANYWAYS…
ODI #11287206 · Filed December 5, 2019
TL* THE CONTACT OWNS A 2006 PONTIAC MONTANA. WHILE DRIVING 35 MPH, THERE WAS AN ABNORMAL RUBBING SOUND COMING FROM THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE REAR SUSPENSION DETACHED FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS AND THE CONTACT…

Read all 37 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Pontiac Montana in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA07-019: POWER SLIDING DOOR
Closed February 23, 2009
Preliminary Evaluation PE07-044: POWER SLIDING DOOR OPENING
Closed December 11, 2007

Open and recently closed NHTSA defect investigations

REAR SUSPENSION TRAILING ARM

NHTSA #10V110000 · Suspension — Rear · NHTSA notice

Reported March 19, 2010 · BRAUN CORPORATION

Potentially affected: 5,375 vehicles

Owners notified June 4, 2010 · Vehicles built July 1, 2004 – May 7, 2008 (per NHTSA)

Defect description

THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.

Safety consequence

A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

TIRE INFORMATION LABEL/FMVSS 110

NHTSA #05V552000 · Equipment — Other — Labels · NHTSA notice

Reported December 7, 2005 · GENERAL MOTORS CORP.

Potentially affected: 32,068 vehicles

Manufacturer campaign 05109 · Owners notified March 31, 2006 · Vehicles built September 1, 2005 – September 7, 2005 (per NHTSA)

Defect description

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.

Safety consequence

A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.

Notes

GM RECALL NO. 05109.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 Pontiac Montana. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

37 owner complaints have been filed with NHTSA for the 2006 Pontiac Montana.

Unknown or Other

ODI #11363656

Incident: October 1, 2020 · Filed: October 10, 2020

WHEN HAVING MY OIL CHANGED AT A GARAGE WHILE THE VEHICLE WAS ON THE LIFT BOTH FRAME RAILS HAD SEVERE RUST DAMAGE. SINCE THIS IS WHAT GIVES THE UNIBODY FRAME IT'S STRENGTH, WHY DIDN'T GM ZINC COAT THEM OR APPLY RUST PROOFING? I LIVE IN SOUTHEAST MICHIGAN WHERE THEY USE SALT ON THE ROADS IN WINTER. SEEING GM IS ALSO IN MICHIGAN YOU WOULD THINK THEY WOULD BE AWARE OF THIS AND ACT ACCORDINGLY? THE ONLY REASON I CAN THINK OF IS TO SAVE MONEY, INCREASE PROFITS, AT THE EXPENSE OF THE VEHICLE BEING SAFE FOR THE CONSUMER. I DON'T SEE DESIGNING THE FRAME RAILS TO LAST FOR 20-25 YEARS FOR SAFETY REASONS AS BEING UNREASONABLE.

Engine; Fuel/Propulsion System

ODI #11306546

Incident: November 13, 2019 · Filed: February 2, 2020

WHEN IT'S COLD AND YOU START THE VEHICLE I GET A MESSAGE REDUCED ENGINE POWER. YOU HAVE TO IMMEDIATELY SHUT IT OFF. SOM ETIMES WHEN YOU ARE DRIVING DOWN THE ROAD AND IT IS WARMED UP IT WILL DO THIS AND YOU HAVE TO FIND A SAFE PLACE TO PULL OVER BECAUSE IF YOU TRY TO GIVE IT GAS IT WON'T GO ANYWAYS. I THINK IT IS A SAFETY HAZARD BECAUSE IT CAN HAPPEN WHEN YOU ARE GOING 70 MPH ON THE INTERSTATE AND CARS ARE RIGHT ON YOUR ASS. LUCKILY I WASN'T ON THE INTERSTATE BUT I WAS ON A HIGHWAY GOING 60MPH WHEN IT HAPPENED.

Suspension

ODI #11287206

Incident: November 26, 2019 · Filed: December 5, 2019

TL* THE CONTACT OWNS A 2006 PONTIAC MONTANA. WHILE DRIVING 35 MPH, THERE WAS AN ABNORMAL RUBBING SOUND COMING FROM THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE REAR SUSPENSION DETACHED FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS AND THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO EXCESSIVE CORROSION OF THE SUBFRAME. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. THE VIN WAS NOT AVAILABLE.

Engine

ODI #11175704

Incident: November 5, 2018 · Filed: February 8, 2019

WHEN STARTING THE VEHICLE, OR AFTER AWHILE WHEN YOU ARE DRIVING THE VEHICLE IT WILL COME UP AND READ REDUCED ENGINE POWER THEN YOU HAVE TO STOP BECAUSE IT WILL NOT LET YOU ACCELERATE THE GAS PEDAL. SOMETIMES WHEN YOU TURN IT OFF AND RESTART IT, IT WILL BE FINE AND SOMETIMES YOU HAVE TO WAIT ABOUT 10 MINUTES THEN RESTART. IT DOESN'T MATTER IF YOU ARE ON A SIDE STREET OR ON THE HIGHWAY, IT JUST RANDOMLY DOES THIS.

Electrical System; Seat Belts; Electronic Stability Control (ESC)

ODI #11119519

Incident: August 1, 2018 · Filed: August 13, 2018

THE DASH KEEPS TELLING ME THAT THE TRACTION CONTROL AND STABILITY SYSTEM NEED TO BE CHECKED. I HAVE WIRING ISSUES FOR THE PASSENGER SIDE FRONT LIGHTS, THEY COME ON AND OFF. FUEL GAUGE DOES NOT READ PROPERLY ALL THE TIME AND NOW MOST RECENTLY THE PASSENGER SEAT BELT ALARM DOES NOT REGISTER THAT THE SEAT BELT IS CONNECTED. THE VEHICLE EXPERIENCES THESE ISSUES MOVING AND STATIONARY.

Tires

ODI #10818124

Incident: December 15, 2015 · Filed: January 5, 2016

TIRES ARE SHOWING SIGNS OF EXTREME SIDEWALL SPLITS THAT COULD HAVE LED TO TIRE BLOWOUT AT HIGHWAY SPEEDS. TIRES WILL BE TAKEN BACK TO STORE WHERE BOUGHT ALTHOUGH NOT OPTIMISTIC THEY WILL REPLACE THEM. DUNLOP SIGNATURE SERIES II ALL SEASON

Structure

ODI #10748386

Incident: January 10, 2011 · Filed: August 13, 2015

TL* THE CONTACT OWNS A 2006 PONTIAC MONTANA. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED. THE CONTACT STATED THAT THE DASHBOARDD DEVELOPED CRACKS IN SEVERAL AREAS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000. THE VIN WAS NOT AVAILABLE.

Electrical System; Exterior Lighting

ODI #10735618

Incident: July 7, 2015 · Filed: July 21, 2015

KEEP SAYING SERVICE PARKING LITE CHANGE LIGHT BULB CHECK FUSES CANNOT FIX PROBLEM.

Power Train; Engine; Fuel/Propulsion System

ODI #10733212

Incident: February 1, 2015 · Filed: July 10, 2015

TL* THE CONTACT OWNS A 2006 PONTIAC MONTANA. THE CONTACT STATED THAT THE TRANSMISSION FAILED. AS A RESULT, THE VEHICLE DECELERATED AND JERKED VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. IN ADDITION, THE CONTACT STATED THAT THE FUEL CAP FAILURE LIGHT AND ENGINE WARNING LIGHT ILLUMINATED. THE INDEPENDENT MECHANIC REPLACED THE FUEL CAP SEVERAL TIMES; HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 106,000.

Suspension; Electrical System

ODI #10732604

Incident: March 10, 2015 · Filed: July 8, 2015

I HAVE BOUGHT A 2006 PONTIAC MONTANA SV6 FROM A DEALER WITHIN 10 DAYS OF HAVING THE VAN THE BALL JOINT FELL COMPLETELY OUT WHILE WE WERE DRIVING HOME WITH KIDS IN CAR DEALER FIXED IT FREE OF CHARGE BUT I HAD TO PAY THE TOWING BILL....I CHANGE ALL 4 TIRES AND NOW MY VAN IS MAKING A SQUEAKING AND CLUNKING SOUND ...I BELIEVE IT IS THE REAR DEF.ALSO NONE OF MY POWER DOORS WORK AND THE BACK WINDSHIELD WIPER KEEPS BURNING OUT NOW THE DEALER WILL NOT HELP ME FIX THE PROBLEM WITH OUT PAYING MORE MONEY PLEASE HELP ME WITH SOME ADVICE IN WHAT TO DO I'VE ONLY HAD VAN FOR 3 MNTHS AND I BOUGHT THE VAN FOR 3500.00 DOLLARS VAN...THANKS SINCERELY A PONTIAC OWNER. *TR

Other Pontiac Montana model years

Check your 2006 Pontiac Montana VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Pontiac Montana at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Pontiac VIN