NHTSA vehicle safety data

2001 Pontiac Montana Recalls, Ratings & Complaints

The 2001 Pontiac Montana has 11 NHTSA recall campaigns and 156 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Pontiac dealer.

NHTSA recall and complaint data for the 2001 Pontiac Montana, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Pontiac Montana owner complaints

Owners have filed 156 complaints with NHTSA about the 2001 Pontiac Montana, describing incidents dated January 19, 2000 to July 2, 2015.

Most-cited components

Engine 38 complaints
Electrical System 20 complaints
Power Train 20 complaints
Fuel/Propulsion System 18 complaints
Service Brakes 15 complaints
Structure 13 complaints

Of the 156 complaints on file, 10 report a crash and 3 a fire; across all 156 complaints, owners report 26 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10809377 · Filed December 10, 2015
MY GEARSHIFT BROKE,FUEL GAGE DON'T WORK,MY CAR BOUNCE UP AND DOWN WHEN DRIVING SLIDING DOORS WON'T CLICK OPEN.WHEN START CAR UP AND PUT IN GEAR DRIVE OR REVEARSE WON'T MOVE JUST RIVE UP.
ODI #10734029 · Filed July 14, 2015
TL* THE CONTACT OWNS A 2001 PONTIAC MONTANA. THE CONTACT STATED THAT THE POWER SLIDING DOOR WOULD NOT LATCH WHEN CLOSING, CAUSING THE DOOR TO OPEN WHEN DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE LATCH FAILED. AFTER CONTACTING THE DEALER, THE CONTACT WAS INFORMED…
ODI #10715924 · Filed May 12, 2015
IN LEFT TURN LANE IN THE INTERSECTION..ONCOMING VEHICLE HIT HEAD ON. AIRBAG FAILED TO INFLATE ON DRIVERS SIDE. DRIVER AIRLIFTED TO TRAUMA HOSP.

Read all 156 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Pontiac Montana in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE04-064: POWER-SLIDING DOOR
Closed December 22, 2004
- Recall 04V-597

Open and recently closed NHTSA defect investigations

STEERING KNUCKLE BREAKING/LOSS OF STEERING CONTROL

NHTSA #09E005000 · Steering · NHTSA notice

Reported February 17, 2009 · DORMAN PRODUCTS, INC.

Potentially affected: 979 vehicles

Owners notified February 23, 2009

Defect description

DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Safety consequence

A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Manufacturer remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FUEL TANK INLET CHECK VALVE WELD

NHTSA #07V349000 · Fuel System, Gasoline — Storage · NHTSA notice

Reported August 8, 2007 · GENERAL MOTORS CORP.

Potentially affected: 20,594 vehicles

Manufacturer campaign 06230 · Owners notified December 4, 2007 · Vehicles built May 1, 2000 – October 31, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Safety consequence

A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.

Notes

GM RECALL NO. 06230.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/POWER SLIDING DOOR

NHTSA #04V597000 · Latches/Locks/Linkages — Doors — Latch · NHTSA notice

Reported December 22, 2004 · GENERAL MOTORS CORP.

Potentially affected: 717,302 vehicles

Manufacturer campaign 04110 · Owners notified May 31, 2005 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Safety consequence

IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Manufacturer remedy

DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

Notes

GM RECALL NO. 04110.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/FMVSS 225/OWNER'S MANUAL INFORMATION

NHTSA #03V250000 · Equipment — Other — Owners/Service/Other Manual · NHTSA notice

Reported July 15, 2003 · GENERAL MOTORS CORP.

Potentially affected: 1,707,825 vehicles

Manufacturer campaign 03039 · Owners notified August 20, 2003 · Vehicles built March 1, 2000 – June 30, 2001 (per NHTSA)

Defect description

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Safety consequence

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Notes

GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/PASSENGER AIR BAG MISSING CHECK VALVE PIN

NHTSA #02V329000 · Air Bags — Frontal · NHTSA notice

Reported December 9, 2002 · GENERAL MOTORS CORP.

Potentially affected: 272 vehicles

Manufacturer campaign 02061 · Owners notified December 16, 2002 · Vehicles built September 1, 2000 – January 31, 2001 (per NHTSA)

Defect description

ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.

Safety consequence

THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.

Notes

GM RECALL NO. 02061. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/FMVSS 225/SEAT LATCH ANCHOR WIRE

NHTSA #01V383000 · Seats — Front Assembly — Recliner · NHTSA notice

Reported December 13, 2001 · GENERAL MOTORS CORP.

Potentially affected: 75,816 vehicles

Manufacturer campaign 01077 · Owners notified April 10, 2002 · Vehicles built April 1, 2000 – October 31, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.

Safety consequence

IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/POWER SLIDING DOOR

NHTSA #01V264000 · Latches/Locks/Linkages — Doors — Latch · NHTSA notice

Reported August 21, 2001 · GENERAL MOTORS CORP.

Potentially affected: 248,737 vehicles

Manufacturer campaign 01059 · Owners notified October 22, 2001 · Vehicles built January 1, 2001 – April 30, 2001 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.

Safety consequence

IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/POWER SLIDING DOOR

NHTSA #01V067000 · Latches/Locks/Linkages — Doors — Latch · NHTSA notice

Reported March 8, 2001 · GENERAL MOTORS CORP.

Potentially affected: 477,011 vehicles

Manufacturer campaign 01013 · Owners notified April 18, 2001 · Vehicles built April 1, 2000 – December 31, 2000 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.

Safety consequence

AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Manufacturer remedy

DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/AIR BAG INFLATOR MODULE

NHTSA #01V026000 · Air Bags — Frontal · NHTSA notice

Reported February 1, 2001 · GENERAL MOTORS CORP.

Potentially affected: 38 vehicles

Manufacturer campaign 01004 · Owners notified January 29, 2001 · Vehicles built September 1, 2000 – October 31, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.

Safety consequence

IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.

Manufacturer remedy

DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/FMVSS 209/TRW SEAT BELT BUCKLES

NHTSA #00V228003 · Seat Belts · NHTSA notice

Reported August 7, 2000 · GENERAL MOTORS CORP.

Potentially affected: 156,305 vehicles

Manufacturer campaign 00067 · Owners notified August 24, 2000 · Vehicles built April 1, 2000 – May 31, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Manufacturer remedy

DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

Notes

OWNER NOTIFICATION BEGAN AUGUST 24, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; CHEVROLET AT 1-800-222-1020; GMC AT 1-800-462-8782; OLDSMOBILE AT 1-800-442-6537; PONTIAC AT 1-800-762-2737; OR SATURN AT 1-800-553-6000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Pontiac Montana w/SAB.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 3

Side Crash

Not Rated

Driver: 5, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

1 investigation

156 owner complaints have been filed with NHTSA for the 2001 Pontiac Montana.

Steering; Suspension; Visibility/Wiper

ODI #10809377

Incident: August 10, 2014 · Filed: December 10, 2015

MY GEARSHIFT BROKE,FUEL GAGE DON'T WORK,MY CAR BOUNCE UP AND DOWN WHEN DRIVING SLIDING DOORS WON'T CLICK OPEN.WHEN START CAR UP AND PUT IN GEAR DRIVE OR REVEARSE WON'T MOVE JUST RIVE UP.

Latches/Locks/Linkages

ODI #10734029

Incident: July 2, 2015 · Filed: July 14, 2015

TL* THE CONTACT OWNS A 2001 PONTIAC MONTANA. THE CONTACT STATED THAT THE POWER SLIDING DOOR WOULD NOT LATCH WHEN CLOSING, CAUSING THE DOOR TO OPEN WHEN DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE LATCH FAILED. AFTER CONTACTING THE DEALER, THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 01V067000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH). THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

Air Bags

ODI #10715924

Crash 2 injuries

Incident: January 31, 2015 · Filed: May 12, 2015

IN LEFT TURN LANE IN THE INTERSECTION..ONCOMING VEHICLE HIT HEAD ON. AIRBAG FAILED TO INFLATE ON DRIVERS SIDE. DRIVER AIRLIFTED TO TRAUMA HOSP.

Engine

ODI #10705974

Incident: April 15, 2015 · Filed: April 15, 2015

THE VAN WHEN IN PARK WILL REVIVE THE ENGINE AND JUMP, WHEN STOPPING WITH NEW BRAKES AND ALL THAT FUN STUFF WHEN THE VAN IS DOING THIS REVIVING STATE IT TAKES LONGER TO STOP AND LIKE THE VAN IS FIGHTING IT. IT SOMETIMES OVER SHIFTS WHEN IN THIS STATE WHEN TAKING OFF FROM A LIGHT (DOES THE REVIVING THING WHEN MOVING. I AM AFRAID ONE DAY IT IS GOING TO JUMP AND HIT SOMETHING OR SOME ONE OR NOT STOP. *TR

Fuel/Propulsion System

ODI #10629560

Incident: July 1, 2013 · Filed: August 30, 2014

THE TANK LEAKS FUEL AT THE INLET ON THE TANK. CUSTOMER IS ABLE TO PUT NO MORE THAN ENOUGH GAS IN THE TANK WHERE IS BELOW THE LEVEL ON THE INLET ON THE TANK. *TR

Fuel System, Gasoline

ODI #10619231

Incident: July 1, 2014 · Filed: August 6, 2014

TL* THE CONTACT OWNS A 2001 PONTIAC MONTANA. THE CONTACT SMELLED GASOLINE FUEL OUTSIDE THE VEHICLE AND NOTICED A LEAK NEAR THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 223,691.

Power Train; Electrical System

ODI #10583714

Crash

Incident: March 1, 2014 · Filed: April 19, 2014

I BACKED UP TO THE LAUNDRY TO WASH CLOTHES AND PROCEEDED TO PUT THE CAR IN PARK AND GET OUT TO GET CLOTHES OUT OF THE BACK. I PUSHED THE BRAKE AND THOUGHT I HAD PUT THE CAR IN PARK BECAUSE THE KEY CAME OUT. WHEN I STARTED TO STEP OUT OF THE VAN TO GET MY CLOTHES OUT OF THE BACK AND MY FOOT CAME OFF THE BRAKE, THE CAR WAS STILL RUNNING AND BACKED INTO A BLOCK WALL. THE WALL WAS DESTROYED, BUT NO ONE WAS HURT. THE BACK DOOR OF THE VAN IS CRUSHED. AFTER A CLOSE EXAMINATION OF THE IGNITION LOCK I FOUND THAT THE KEY WILL COME OUT IN ANY POSITION, INCLUDING RUNNING. I HAD THOUGHT THE KEY WAS NOT SUPPOSED TO COME OUT EXCEPT IN THE OFF POSITION. IS THIS CORRECT? I ATTEMPTED TO FIND OUT IF IT WAS IN THE GM RECALL FROM MY LOCAL GM DEALER AND THEY CLAIMED IGNORANCE OF ANYTHING AND EVERYTHING. INCLUDING EVEN WHAT CONSTITUTES A DEFECTIVE SWITCH AND WHAT IT IS SUPPOSED TO DO AND NOT DO. IT'S LIKE PULLING TEETH TRYING TO GET THEM TO SAY ANYTHING. THEY SAY THE FACTORY SENDS THEM A LIST AFFECTED CARS AND THEY WILL NOT TOUCH ANYTHING ELSE NO MATTER WHAT THE CIRCUMSTANCES. THE SMELL OF GASOLINE IS STRONG AT TIMES BUT A CURSORY EXAMINATION BY A MECHANIC DOESN'T SHOW ANYTHING. AFTER VIEWING THE RECALLS CONCERNING GAS LEAKS I AM WORRIED. CAN YOU TELL ME BY THE VIN HOW MANY OF THE RECALLS SHOWN ON YOUR PAGE THIS VEHICLE HAS HAD AND WHAT IT HAS MISSED BEFORE IT BURNS ME TO DEATH? *TR

Steering; Engine; Fuel/Propulsion System

ODI #10566652

Incident: March 1, 2014 · Filed: March 2, 2014

BOUGHT THIS 2001 PONTIAC MONTANA WITH 132000 MILES A WEEK BEFORE. GOING TO PICK UP MY SON FROM WORK, EARLY EVENING, 14 DEGREES OUTSIDE. I LOOK DOWN AND MY TEMPERATURE GAUGE SHOOT UP AND THE RED TEMP GAUGE COMES ON. I PULL OVER. BUBBLING FLUIDS IS ALL I HEAR. FIRST WE STARTED OFF WITH NO HEAT A FEW DAYS BEFORE THAT. WE HAD THE HEATER CORE FLUSHED OUT AND THAT SEEMED TO WORK. CHANGED THE WATER PUMP AND THERMOSTAT. O2 SENSORS NEED TO BE REPLACED (1+3). FUEL PUMP IS RUSTED. AND THE HYDROPONIC LIFTERS ARE LOUD. LIKE THE STYLE BUT HAVING PROBLEMS. NOTICED A FEW STEERING ISSUES. *TR

Fuel System, Gasoline

ODI #10536802

Incident: August 22, 2013 · Filed: August 22, 2013

IN 2010 I LEARNED MY VEHICLE HAD AN OUTSTANDING RECALL NOTICE (07V349000) FOR A DEFECTIVE GAS TANK. I HAD THE TANK REPLACED BY THE DEALER. YESTERDAY EVENING I NOTICED A STRONG ODOR OF GASOLINE WHEN I STEPPED NEAR MY VEHICLE. I WENT TO MY LOCAL ASE CERTIFIED MECHANIC AND HAD HIM INSPECT THE GAS TANK. HE FOUND IT WAS LEAKING SIGNIFICANTLY AT THE FILLER NECK. I THEN TOOK THE CAR TO THE DEALER THAT HAD DONE THE REPLACEMENT. I REQUESTED THEY REPLACE THE DEFECTIVE TANK. THE TOLD ME THE WARRANTY WAS GOOD FOR ONLY ONE YEAR OR 12,000 MILES. I TOLD THEM THAT DID NOT MAKE SENSE. THEY REPLACED A SUPPOSEDLY DEFECTIVE UNIT WITH A DEFECTIVE UNIT. THERE IS NO VISIBLE DAMAGE TO THE GAS TANK. I GOT IN TOUCH WITH GM CUSTOMER SERVICE DEPT. AND THEY ADVISED ME TO HAVE THE CAR INSPECTED BY THE DEALER AND WE WOULD PROCEED FROM THERE. THEY WILL CHARGE ME $58 ( I DON'T KNOW IF IT IS TAXABLE OR NOT) TO GET THE BALL ROLLING. THE MILEAGE AT THE TIME OF THE ORIGINAL REPLACEMENT WAS 122,727. THE CURRENT MILEAGE IS 147,583. THAT EQUATES TO A LITTLE OVER 8,000 MILES PER YEAR, IN FLORIDA. *TR

Vehicle Speed Control; Fuel/Propulsion System

ODI #10478632

Incident: January 1, 2011 · Filed: October 4, 2012

FOR SOME TIME NOW I HAVE BEEN HAVING INCIDENTS WHERE MY GAS PEDAL IS HUNG UP OR STUCK. I AM TO THE POINT NOW I AM SCARED TO DRIVE IT. I HAVE SMALL CHILDREN AND EVERYTIME WE GET IN THE VAN ITS A DANGER. *TR

Other Pontiac Montana model years

Check your 2001 Pontiac Montana VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Pontiac Montana at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Pontiac VIN