NHTSA vehicle safety data

2001 Nissan Pathfinder Recalls, Ratings & Complaints

The 2001 Nissan Pathfinder has 7 NHTSA recall campaigns and 230 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Nissan dealer.

NHTSA recall and complaint data for the 2001 Nissan Pathfinder, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Nissan Pathfinder owner complaints

Owners have filed 230 complaints with NHTSA about the 2001 Nissan Pathfinder, describing incidents dated July 1, 2000 to July 18, 2022.

Most-cited components

Suspension 68 complaints
Equipment 42 complaints
Steering 35 complaints
Structure 30 complaints
Fuel/Propulsion System 28 complaints
Engine 17 complaints

Of the 230 complaints on file, 18 report a crash and 2 a fire; across all 230 complaints, owners report 12 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11619421 · Filed October 11, 2024
The contact owns a 2001 Nissan Pathfinder. The contact stated that the door open warning light was illuminated. In addition, the vehicle dome light remained on. The contact stated when opening the rear door hatch there was an abnormal noise present. The contact related the failure to NHTSA Campaign…
ODI #11478841 · Filed August 11, 2022
The contact owns a 2001 Nissan Pathfinder. The contact stated while driving approximately 35 MPH, the contact was attempting to use her brakes to slow for traffic and was unable to stop. The contact had to depress the brake pedal to the floorboard to get the vehicle to stop. The contact stated that…
ODI #11432536 · Filed September 10, 2021
Rear mount of front passenger control arm cracked where mounts to frame. Very little metal left where bolts hold bracket to body.

Read all 230 complaints

Owner-reported

2001 Nissan Pathfinder mileage at failure

137 of the 230 complaints on file for the 2001 Nissan Pathfinder give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Suspension	Median 135,000 miles	Middle half 100,000–165,000 miles	Based on 49 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Nissan Pathfinder in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE11-004: Frame/Body Structure Corrosion
Closed June 30, 2011
- Recall 11V-244

Open and recently closed NHTSA defect investigations

FRAME/BODY STRUCTURE CORROSION

NHTSA #11V244000 · Steering — Column · NHTSA notice

Reported April 20, 2011 · NISSAN NORTH AMERICA, INC.

Potentially affected: 195,991 vehicles

Owners notified August 25, 2011 · Vehicles built October 1, 1995 – July 31, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

NISSAN IS RECALLING CERTAIN MODEL YEAR 1996-2004 PATHFINDER AND MODEL YEAR 1997-2003 INFINITI QX4 VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON D.C., WEST VIRGINIA AND WISCONSIN. IN AREAS OF THE COUNTRY IN WHICH HEAVY CONCENTRATIONS OF ROAD SALT ARE USED, A MIXTURE OF SNOW/WATER AND SALT MAY ENTER AN ASSEMBLY LOCATION HOLE IN THE UPPER STRUT HOUSING, CAUSING WATER TO COLLECT AT THE MATING SURFACE OF THE STRUT HOUSING PANEL AND THE INNER HOOD LEDGE ASSEMBLY. OVER TIME, THIS SNOW/WATER AND SALT INTRUSION MAY RESULT IN CORROSION OF THE STRUT TOWER HOUSING IN SOME SUBJECT VEHICLES.

Safety consequence

THE STRUT HOUSING MAY CRACK AND PULL AWAY FROM THE INNER HOOD LEDGE ASSEMBLY. THIS MAY LEAD TO GRINDING NOISES, INCREASED STEERING EFFORT, AND POSSIBLY THE STEERING COLUMN TO BREAK, RESULTING IN THE LOSS OF STEERING CONTROL, WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

NISSAN WILL INSPECT THE STRUT HOUSING AND REPAIR THE VEHICLES AS NECESSARY, FREE OF CHARGE. AN INTERIM NOTIFICATION LETTER WAS SENT OUT IN MAY 2011. THE SECOND NOTICE WAS MAILED ON JULY 25, 2011. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

LOWER MOUNTING BRACKET

NHTSA #07V435000 · Fuel System, Gasoline — Storage — Tank Assembly — Filler Pipe and Cap · NHTSA notice

Reported September 18, 2007 · NISSAN NORTH AMERICA, INC.

Potentially affected: 372,250 vehicles

Owners notified November 26, 2007 · Vehicles built May 24, 1997 – July 26, 2001 (per NHTSA)

Defect description

ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, TENNESSEE, VERMONT, VIRGINIA, WEST VIRGINIA , WISCONSIN AND THE DISTRICT OF COLUMBIA, DURING THE COATING PROCESS OF THE FUEL FILLER TUBE ASSEMBLY, AN INSUFFICIENT AMOUNT OF COATING MAY HAVE BEEN APPLIED AT THE LOWER MOUNTING BRACKET. THIS COULD RESULT IN AN OPENING IN THE COATING WHICH CAN ALLOW WATER TO ENTER AND MAKE CONTACT WITH THE BARE METAL OF THE TUBE.

Safety consequence

THIS MAY RESULT IN SURFACE RUST BUT NOT PERFORATION OF THE TUBE. HOWEVER, IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, IF A MIXTURE OF SNOW/WATER AND SALT MAKES CONTACT WITH THE BARE METAL, CORROSION MAY OCCUR TO A DEGREE WHICH RESULTS IN PERFORATION OF THE TUBE. IN THIS CASE FUEL LEAKAGE MAY OCCUR WHEN FILLING THE TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL FILLER TUBE ASSEMBLY WITH A NEW ONE WITH AN IMPROVED COATING PROCESS. THE RECALL BEGAN ON NOVEMBER 26, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E049000 · Exterior Lighting · NHTSA notice

Reported May 24, 2006 · CK MOTORSPORT, INC.

Potentially affected: 27,176 vehicles

Owners notified July 1, 2006

Defect description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY THE VEHICLE MANUFACTURERS.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 108/AMBER SIDE REFLEX REFLECTORS

NHTSA #06E026000 · Exterior Lighting · NHTSA notice

Reported March 23, 2006 · PRO-A MOTORS, INC.

Potentially affected: 61,944 vehicles

Owners notified April 3, 2006

Defect description

CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Safety consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Manufacturer remedy

PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Notes

THIS RECALL ONLY PERTAINS TO PRO-A MOTORS AFTERMARKET LAMPS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE LISTED PASSENGER VEHICLES.FOR MORE INFORMATION ON THE LAMP MODEL NUMBERS, CLICK ON DOCUMENT SEARCH AND VIEW DOCUMENT TITLED "LAMP MODEL NUMBERS."CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

NISSAN/REAR DOOR HATCH

NHTSA #01V282000 · Structure — Body — Hatchback/Liftgate — Hinge and Attachments · NHTSA notice

Reported August 30, 2001 · NISSAN NORTH AMERICA, INC.

Potentially affected: 31,000 vehicles

Owners notified September 24, 2001 · Vehicles built December 20, 2000 – June 8, 2001 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. SOME OF THE BRACKETS USED TO ATTACH THE TWO GAS STRUTS TO THE REAR DOOR (HATCH) MAY HAVE BEEN IMPROPERLY MADE. AT HIGH AMBIENT TEMPERATURES, THE INCREASE IN GAS PRESSURE IN THE STRUT(S) COULD CAUSE ONE OR BOTH BRACKETS TO BEND, RESULTING IN THE STRUTS DETACHING FROM THE BRACKET(S) WHEN OPENING OR CLOSING THE REAR DOOR.

Safety consequence

IF BOTH STRUTS DETACH FROM THE BRACKETS, THE DOOR WILL RAPIDLY FALL DOWN, POSSIBLY STRIKING SOMEONE AND CAUSING SERIOUS INJURY.

Manufacturer remedy

DEALERS WILL REPLACE THE STRUT BRACKETS. OWNER NOTIFICATION BEGAN SEPTEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NISSAN AT 1-800-647-7261.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Nissan Pathfinder 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Safety Technology

1 investigation

2001 Nissan Pathfinder 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Safety Technology

1 investigation

230 owner complaints have been filed with NHTSA for the 2001 Nissan Pathfinder.

Structure

ODI #11619421

Incident: March 10, 2014 · Filed: October 11, 2024

The contact owns a 2001 Nissan Pathfinder. The contact stated that the door open warning light was illuminated. In addition, the vehicle dome light remained on. The contact stated when opening the rear door hatch there was an abnormal noise present. The contact related the failure to NHTSA Campaign Number: 01V282000 (Structure). The vehicle was taken to the dealer where she was informed that the remedy parts were no longer available. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Steering; Suspension

ODI #11478841

Incident: July 18, 2022 · Filed: August 11, 2022

The contact owns a 2001 Nissan Pathfinder. The contact stated while driving approximately 35 MPH, the contact was attempting to use her brakes to slow for traffic and was unable to stop. The contact had to depress the brake pedal to the floorboard to get the vehicle to stop. The contact stated that prior to the failure her ABS warning had been illuminated for a long period of time prior to the failure. The contact drove the vehicle to an independent mechanic where it was diagnosed that due to a significant amount of rust, the front suspension and struts and brake pads, and rotors had to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 11V244000 (Steering and Suspension). The work had been previously completed by a dealer. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 142,000.

Structure

ODI #11432536

Incident: September 9, 2021 · Filed: September 10, 2021

Rear mount of front passenger control arm cracked where mounts to frame. Very little metal left where bolts hold bracket to body.

Steering; Suspension; Wheels

ODI #11348789

Incident: August 11, 2020 · Filed: August 12, 2020

FAMILY CAR;2001 NISSAN PATHFINDER, WE GOT IN THE TRUCK AND DROVE ABOUT 250 FEET TO THE STOP SIGN. I STOP. AS I STARTED MOVING AND SUDDENLY I HEAR A POP LOUD SOUND FROM ENGINE COMPARTMENT AND MY STEERING GOT HARD AND DIFFICULT TO STEER AND A GRINDING SOUND AS YOU TURN THE STEERING. DROVE BACK TO THE HOUSE SLOW AND PARK. OPEN THE HOOD AND I SEE THE STRUT TOWER UNDER NEATH THE BRAKE MASTER CYLINDER, THEN I LOOK BETWEEN LEFT SIDE (DRIVERS) TIRE THE STRUT TOWER JUST RIPPED FROM THE FACTORY WELD. MY FAMILY IN THE CAR WHEN THIS OCCUR. WHAT IF THIS OCCUR WHILE ON THE HIGHWAY AT HIGHER SPEEDS. MY TRUCK ONLY HAS 106523 MILES AND WAS SCHEDULED FOR A PA INSPECTION.

Electrical System

ODI #11299157

Incident: April 13, 2019 · Filed: January 13, 2020

IN APRIL 2019, I WAS DRIVING AT ABOUT 55 MPH TOWING A SMALL TRAILER IN THE RIGHT MOST LANE OF A 3 LANE HIGHWAY. AS I APPROACHED A HILL, THE PATHFINDER SUDDENLY SMELLED LIKED SOMETHING WAS ON FIRE AND THE ENGINE STOPPED RUNNING. I MANAGED TO PULL OFF THE HIGHWAY AND COAST TO A STOP ON THE SHOULDER. THE BURNING SMELL LASTED ABOUT 5 MINUTES, BUT I COULD NOT TELL WHERE THE SOURCE WAS AT THE TIME. I RAN SEVERAL DIAGNOSTIC TESTS, INCLUDING ECU CODES, BUT DID NOT FIND ANYTHING INDICATIVE OF A PROBLEM OF THIS NATURE. IN JANUARY 2020, I ATTEMPTED TO START THE VEHICLE AFTER REPLACING SEVERAL WORN OUT DRIVETRAIN COMPONENTS (CLUTCH, ENGINE, RADIATOR, ENGINE GASKETS) AND FOUND THAT IT WOULD NOT START. I FOUND A BURNED OUT FUSE TO THE ECCS2, 10 AMP CIRCUIT. I REPLACED THE FUSE AND IMMEDIATELY NOTICED THAT THERE WAS SMOKE COMING FROM UNDERNEATH THE DASHBOARD EVEN THOUGH THE VEHICLE WAS NOT ON OR RUNNING AT THE TIME. AGAIN THE SMOKE LASTED SEVERAL MINUTES. THIS TIME I WAS ABLE TO SEE SMOKE COMING FROM THE COMPUTER CASING OF THE VEHICLE'S ECU. I DISCONNECTED THE BATTERY IMMEDIATELY AND REMOVED THE ECU FROM THE VEHICLE. I DISCOVERED A BURNED CHIP INSIDE. AFTER SEVERAL HOURS OF RESEARCH, I WAS ABLE TO IDENTIFY THE CAUSE AND LEARN THAT THIS HAPPENS TO MANY OTHER MODELS OF NISSAN VEHICLES OF SIMILAR YEAR MODEL. THE CAUSE IS ALWAYS THE SAME - THE IDLE AIR CONTROL VALVE SEALS FAIL, THEN WATER GETS INSIDE THE ELECTRIC IACV MOTOR AND WHEN THE ECU TRIES TO COMPENSATE FOR THE IACV FAILURE, IT OVERLOADS THE ELECTRICAL CIRCUIT AND SHORTS OUT THIS PARTICULAR CHIP. SOME PEOPLE HAVE REPORTED SPENDING SEVERAL THOUSAND DOLLARS TO HAVE NISSAN REPLACE PARTS AND REPAIR THEIR ECU AS THESE VEHICLES ARE NOW OUT OF WARRANTY.

Steering

ODI #11231413

Incident: June 28, 2019 · Filed: July 12, 2019

TL* THE CONTACT OWNS A 2001 NISSAN PATHFINDER. WHILE DRIVING APPROXIMATELY 15 MPH AND MAKING A LEFT TURN, THE LOWER STEERING COLUMN FRACTURED WITHOUT WARNING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE VEHICLE WAS TOWED TO WALSER NISSAN WAYZATA (612-426-6995, LOCATED AT 15906 WAYZATA BLVD, WAYZATA, MN 55391) VIA THE AFTER HOUR SERVICE. THE CONTACT LEFT A MESSAGE FOR THE TECHNICIAN TO DIAGNOSE THE FAILURE AND PROVIDE A REPORT. THE CONTACT WENT ON A VACATION. OVERNIGHT, THE GENERAL MANAGER OF THE DEALER CALLED THE CONTACT AND INFORMED HIM TO MOVE THE VEHICLE FROM THE PREMISES BEFORE 8AM THE FOLLOWING DAY. THE CONTACT EXPLAINED THAT HE WAS OUT OF TOWN. THE VEHICLE WAS TOWED TO AN IMPOUND LOT BY THE DEALER. FOUR YEARS PRIOR TO THE FAILURE, THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 11V244000 (STEERING, SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 187,000. The contact is requesting a call back from a NHTSA Supervisor or Administrator.

Steering

ODI #11228822

Incident: June 30, 2019 · Filed: July 1, 2019

TL* THE CONTACT OWNS A 2001 NISSAN PATHFINDER. THE CONTACT'S VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V244000 (STRUCTURE) AND REPAIRED IN 2015. WHILE THE CONTACT'S DAUGHTER WAS DRIVING AT A VERY LOW SPEED, SHE ATTEMPTED TO MAKE A U-TURN AND THE STEERING COLUMN FRACTURED. AS A RESULT, THE VEHICLE DROVE FORWARD AND RAN INTO A CURB. THE DRIVER WAS ABLE TO REVERSE THE VEHICLE AND ALIGN THE VEHICLE AGAINST THE CURB, ALTHOUGH THE STEERING FAILED. THE VEHICLE WAS LEFT AT THE SCENE. KLINE NISSAN (3090 HWY 61 N, MAPLEWOOD, MN 55109, (877) 284-5230) WAS CONTACTED AND STATED THAT THE RECALL REPAIR WAS ALREADY PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE RECURRING FAILURE AND REFERRED THE CONTACT BACK TO THE DEALER. THE FAILURE MILEAGE WAS UNKNOWN.

Steering

ODI #11228817

Incident: June 30, 2019 · Filed: July 1, 2019

TL* THE CONTACT OWNS A 2001 NISSAN PATHFINDER. THE CONTACT STATED THAT THE STEERING SHAFT WAS FRACTURED ON THE BOTTOM OF THE STEERING COLUMN. WHILE DRIVING, THE VEHICLE LOST ALL POWER STEERING ABILITY. THE VEHICLE DROVE OVER A CURB AND WAS ABLE TO BE STOPPED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT TOOK PICTURES OF THE FAILURE AND SENT THEM TO KLINE NISSAN (LOCATED AT 3090 HWY 31 N, MAPLEWOOD, MN 55109, (877) 284-5230). THE CONTACT WAS INFORMED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 11V244000 (STEERING, SUSPENSION) YEARS AGO. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

Steering; Suspension; Structure

ODI #11197090

Incident: April 15, 2019 · Filed: April 18, 2019

DRIVER'S SIDE STRUT TOWER HAS RUSTED TO THE POINT WERE THE TRUCK WILL PASS VA STATE SAFETY INSPECTION. THERE WAS A RECALL PERFORMED BY SEVERAL YEARS AGO BY NISSAN FOR THE RUST ISSUE ON BOTH INNER WHEEL WELLS AND STRUT TOWER AREA.

Steering; Suspension

ODI #11191510

Incident: March 25, 2019 · Filed: March 25, 2019

THE SUB-FRAME/CRADLE 54400-0W00 ON THE PASSENGER SIDE IS ROTTED OUT TO THE POINT THAT IT WILL NOT PASS A PA STATE INSPECTION. THIS WAS FOUND BY MY MECHANIC WHILE HE WAS REPLACING THE FRONT ROTORS AND BRAKES. MY MECHANIC HAS ORDERED A NEW SUB FRAME + BOLTS TO REPLACE THE ROTTED OUT SUB-FRAME. I WONDER HOW MANY OTHER SUB-FRAMES ARE ROTTED OUT ON PATHFINDERS FROM 1996 TO 2004 WHICH IS WHEN NISSAN USED THIS PARTICULAR PART. MY CONCERN IS IF THIS PART FAILS COMPLETELY WHAT WILL HAPPEN??? I HAVE RESTRICTED DRIVING MY PATHFINDER UNTIL THE NEW PART IS INSTALLED. I THINK SOMEONE SHOULD LOOK INTO THIS PROBLEM, BECAUSE WHEN IT FAILS AND IT WILL SOMEONE WILL GET HURT OR EVEN KILLED? THE CONTROL ARMS MOUNTED TO THIS PART WHICH CONTROLS STEERING. THIS PART PLUS LABOR WILL COST ME ABOUT $1500.00.

Other Nissan Pathfinder model years

Check your 2001 Nissan Pathfinder VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Nissan Pathfinder at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Nissan VIN