2015 Kia Optima Recalls, Ratings & Complaints

Incident: October 21, 2026 · Filed: October 23, 2026

There is a known issue with this vehicle and the fix by KIA is not safe nor fair to the consumer. Kia's knock sensor recall centers on the Knock Sensor Detection System (KSDS) software update for Theta II GDI engines. The update listens for rod bearing wear, triggers a check engine light and limp mode via Code P1326, and extends the engine warranty up to a lifetime or 15 years/150,000 miles. My problem is that we had to car in on May of 2026 after in went into limp mode. They updated the software. The car again went into limp mode on 10/21/2026, they updated the software again. My focus here is the fact that it is a known issue and they say it still does not meet the parameters for an engine replacement. It is a severe issue that is dangerous and inconvenient to the driver. You are afraid to take it on a trip or even take it on a highway. My 20 year old daughter drives this to college. Can you imagine a car going into limp mode on a majory US highway? Limp mode essentially does not allow a vehicle to go above 2K RPM. You cant go up a hill over 35 and on a highway, on a flat road you "might" be able to go 55 MPH. My daughter goes to college 4 hours away. This creates a very unsafe, dangerous and inconvenient environment. KIA is hoping that they can buy time until these vehicles fail for some other reason and they dont have to pay the cost for a new engine.... ALL at the consumers peril. To put this in perspective, if you have a vehicle with a "low tire pressure" warning, does lowering the sensors parameters fix the problem.... No, it just turns off the warning and you are driving a car with low tire pressure.

Incident: September 23, 2026 · Filed: September 29, 2026

The contact owns a 2015 Kia Optima. The contact stated that while pulling into the driveway, the ABS warning light remained illuminated after the vehicle was powered off. The contact stated that the parking brake warning light unexpectedly illuminated while the vehicle was being operated. The contact stated that the brake lights illuminated while the vehicle was turned on or off. The contact's son inspected the vehicle and became aware that the rear of the vehicle near the brake pedal was extremely hot and that the area under the hood was extremely hot. The vehicle was taken to the dealer but was not diagnosed. The dealer informed the contact that the failure could be associated with a light switch failure; however, the contact stated that the failure was not related to the light switch and that the vehicle needed to be diagnosed to determine the cause of the failure. The approximate failure mileage was 231,000.

Incident: June 10, 2026 · Filed: September 20, 2026

My energy in my car started messing up with only 150,000 miles it had a long knocking sound and it would not got over 20 miles while driving

Incident: August 14, 2026 · Filed: August 24, 2026

My 2015 KIA optima experienced a catastrophic engine fire while I was driving. There was no warning, I just heard a boom in the engine bay the breaks stopped working and all electrical cut out. As I'm coasting, because I'm unable to stop, flames started to come in through under the dash. I couldn't turn the car off, nor put it in park so the doors stayed locked. The driver window was opened just enough for me to grab the top and break it, allowing me to crawl out. The car coasted itself to the shoulder then blew up (I had a full tank of gas.). All this happened in the manner of 30 to 35 seconds. It's important to note that KIA just replaced the engine 2 months prior to this incident.

Incident: August 20, 2026 · Filed: August 20, 2026

The contact owns a 2015 Kia Optima. The contact stated that for over 8 years, the vehicle was experiencing excessive oil consumption. There was no warning light illuminated. The contact became aware that there was an oil leak on the ground underneath the vehicle. The vehicle was taken to the dealer on several occasions for the oil consumption failure; however, the dealer was unable to find a fault with the vehicle. The dealer had not yet provided a cause for the oil leak. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 123,000.

Incident: August 14, 2026 · Filed: August 19, 2026

The engine in my vehicle failed while putting the car into reverse to back into my garage. I thank God I wasn't on the road when this happened. I took the car into a mechanic who confirmed that the engine was locked and that the car was very low on oil(even though I had my oil changed by him a few months prior). There was an undetected oil leak that led to the engine failure. The warning indicators didn't appear on my dash until after my engine failed.

Incident: July 27, 2026 · Filed: August 13, 2026

This is a formal vehicle safety complaint regarding a manufacturer's active refusal to remedy a known safety defect under an active recall campaign guidelines.My 2015 Kia Optima Turbo experienced an active internal mechanical engine knock, violent sputtering, and a complete engine seizure. The vehicle is currently sitting un-driveable at an authorized Kia dealership.The required Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the incident, legally qualifying it for a 100% free long-block engine replacement under the manufacturer's active Lifetime Warranty extension. However, the dealership service department is actively withholding the safety warranty paperwork and refusing to submit the diagnostic photos and engine seizure data to corporate for warranty approval unless I agree to pay an additional $800 out of pocket for an external throttle body and O2 sensor.I have explicitly declined the retail accessory charges five separate times. I only authorize the replacement of my front sway bar links. Instead of separating the ticket and processing the free engine block safety remedy, the dealer is holding my safety warranty hostage to force a retail sale. Furthermore, a manufacturer consumer care representative recently refused to listen to my request on this matter and dropped the call.The manufacturer is using internal technical advice to block a court-ordered safety remedy and is allowing a dealership to use unauthorized retail accessory charges to deny me a safe, operating vehicle. I request immediate federal intervention to force the manufacturer to release the free engine block safety replacement order to the dealer and halt these predatory dealer practices.

Incident: November 10, 2025 · Filed: July 29, 2026

The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed; however, the rear taillight socket wiring harness failed to function as intended. The contact was informed that the brake lights were inoperable. The contact stated that the failure had occurred every 6–7 months. The contact stated that the repair was completed by the contact. The dealer was not made aware of the failure but provided no assistance. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 88,000.

Incident: July 17, 2026 · Filed: July 23, 2026

The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. During the failure, several unknown warning lights flashed on the instrument panel and there was smoke coming from under the hood of the vehicle. The contact exited the vehicle, and there were flames coming from underneath the hood. The Fire Department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A Police report was filed, and the vehicle was towed to a tow lot. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The contact stated that the original engine was previously replaced by the local dealer due to a previous recall. No further information was available. The failure mileage was 140,000.

Incident: June 30, 2026 · Filed: July 20, 2026

My girlfriend was driving on interstate 95 to pick me up from the metro. The engine suddenly cut off in a manner that appears to have melted the wiring harness of the vehicle, risking fire. She was able to safely get to the side of the road and call a tow. After taking it to a local repair shop, they diagnosed the issue as related to the KSDS recall. We had it towed to the dealership that has also confirmed it is related to the recall. The engine is completely seized following this incident and it's worth noting that Kia is completely denying the engine repair claim as the KSDS update was not installed prior.