NHTSA vehicle safety data

2008 Keystone Fuzion Recalls & Complaints

The 2008 Keystone Fuzion has 4 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Keystone dealer.

NHTSA recall and complaint data for the 2008 Keystone Fuzion. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2008 Keystone Fuzion owner complaints

Owners have filed 4 complaints with NHTSA about the 2008 Keystone Fuzion, describing incidents dated July 16, 2009 to September 13, 2015.

Most-cited components

Tires 3 complaints
Electrical System 1 complaint

Of the 4 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10782102 · Filed October 14, 2015
TL* THE CONTACT OWNS A 2008 KEYSTONE FUZION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V561000 (ELECTRICAL SYSTEM) HOWEVER, THE CONTACT SMELLED AN ODOR COMING FROM UNDER THE FRONT OF THE CAMPER IN THE STORAGE AREA. THE CONTACT EXTINGUISHED THE FIRE. NO INJURIES WERE SUSTAINED…
ODI #10545030 · Filed September 23, 2013
TOWING 5TH WHEEL CAMPER DOWN INTERSTATE. ALL 4 TIRES ON TRAILER DEVELOPED BULGES AND 2 BLEW OUT. DAMAGE WASN'T TOO BAD BUT CAUSED A MAJOR DISRUPTION IN TRAVEL. HAD TO BUY 4 NEW TIRES FOR CAMPER.
ODI #10294271 · Filed December 2, 2009
3.5 HOURS INTO TRIP FROM ROSEVILLE, CA TO SAND MOUNTAIN, NV, WE STOPPED AT PILOT TRUCK STOP TO RENDEZVOUS WITH OTHERS IN GROUP. NO POTHOLES/CURBS HAD BEEN ENCOUNTERED. AFTER APPROXIMATELY A 45 MINUTE STOP, WE STARTED AGAIN, AND AS WE ACCELERATED TO 60MPH ON I-80, 1MILE EAST OF FERNLEY, THE FRONT…

Read all 4 complaints

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #17V755000 · Equipment · NHTSA notice

Reported November 22, 2017 · Keystone RV Company

Potentially affected: 1,205,997 vehicles

Repair completion: 2.15% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Keystone campaign 17-307 · Owners notified January 15, 2018

Defect description

Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Transfer Switch may Overheat

NHTSA #15V561000 · Electrical System · NHTSA notice

Reported September 4, 2015 · Keystone RV Company

Potentially affected: 3,585 vehicles

Repair completion: 33.77% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Keystone campaign 15-234 · Owners notified October 8, 2015 · Vehicles built October 10, 2007 – July 31, 2008 (per NHTSA)

Defect description

Keystone RV Company (Keystone) is recalling certain model year 2008-2009 Big Sky, Challenger, Everest, Fuzion, Montana, and Raptor travel trailers and fifth wheels equipped with an IOTA ITS-50R transfer switch. These transfer switches, used in vehicles wired to be powered by a generator, may fail when exposed to elevated electrical loads and used in higher ambient temperatures.

Safety consequence

As the transfer switch fails, it may overheat, increasing the risk of a fire.

Manufacturer remedy

Keystone will notify owners, and dealers will replace the IOTA ITS-50R transfer switch with a different brand transfer switch, free of charge. The recall began on October 8, 2015. Owners may contact Keystone customer service by calling 1-866-425-4369. Keystone's number for this recall is 15-234.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

LP LINE/SLIDE OUT ROOM

NHTSA #08V037000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Lines and Fittings · NHTSA notice

Reported January 28, 2008 · KEYSTONE RV COMPANY

Potentially affected: 247 vehicles

Keystone campaign 08-100 · Owners notified February 1, 2008

Defect description

ON CERTAIN FIFTH WHEEL TRAVEL TRAILERS, THE PROPANE HOSE FOR THE SLIDE ROOM IS TOO LONG ALLOWING THE HOSE TO DROOP TOO CLOSE TO THE TIRE. THE PROPANE LINE MAY BECOME DAMAGED AS A RESULT OF CONTACT WITH THE TIRE.

Safety consequence

A PROPANE LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Manufacturer remedy

DEALERS WILL REPLACE THE PROPANE HOSE WITH ONE OF SHORTER LENGTH AND WILL ALSO SHORTEN THE HOSE SUPPORT TO MOVE THE HOSE AWAY FROM THE TIRE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT KEYSTONE RV AT 1-866-425-4369.

Notes

KEYSTONE RV RECALL NO. 08-100.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

INCORRECT WIRING TO THE WATER HEATER

NHTSA #07V330000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Water Heater · NHTSA notice

Reported July 20, 2007 · KEYSTONE RV COMPANY

Potentially affected: 596 vehicles

Keystone campaign 07-088 · Owners notified August 10, 2007 · Vehicles built April 27, 2007 – June 15, 2007 (per NHTSA)

Defect description

CERTAIN FIFTH WHEEL RECREATIONAL TRAILERS MAY HAVE INCORRECT WIRING TO THE WATER HEATER. IF THE WIRING IS INCORRECT, THE GAS VALVE ON THE WATER HEATER COULD OPEN AND ALLOW LIQUID PROPANE (LP) GAS INTO THE BURNER TUBE WHEN THE ELECTRIC SWITCH IS TURNED ON.

Safety consequence

THIS COULD CAUSE AN INCREASED RISK OF FIRE, EXPLOSIONS, AND PERSONAL INJURY.

Manufacturer remedy

DEALERS WILL INSPECT THE WIRING AND MAKE CORRECTIONS IF NECESSARY. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS MAY CONTACT KEYSTONE RV AT 1-866- 425-4369.

Notes

KEYSTONE RECALL NO. 07-088.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2008 Keystone Fuzion. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

4 owner complaints have been filed with NHTSA for the 2008 Keystone Fuzion.

Electrical System

ODI #10782102

Fire

Incident: September 13, 2015 · Filed: October 14, 2015

TL* THE CONTACT OWNS A 2008 KEYSTONE FUZION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V561000 (ELECTRICAL SYSTEM) HOWEVER, THE CONTACT SMELLED AN ODOR COMING FROM UNDER THE FRONT OF THE CAMPER IN THE STORAGE AREA. THE CONTACT EXTINGUISHED THE FIRE. NO INJURIES WERE SUSTAINED. THE CONTACT REPLACED THE TRANSFER SWITCH INDEPENDENTLY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DECLINED THE RECALL REMEDY. THE FAILURE MILEAGE WAS UNKNOWN.

Tires

ODI #10545030

Incident: August 5, 2012 · Filed: September 23, 2013

TOWING 5TH WHEEL CAMPER DOWN INTERSTATE. ALL 4 TIRES ON TRAILER DEVELOPED BULGES AND 2 BLEW OUT. DAMAGE WASN'T TOO BAD BUT CAUSED A MAJOR DISRUPTION IN TRAVEL. HAD TO BUY 4 NEW TIRES FOR CAMPER.

Tires

ODI #10294271

Incident: November 26, 2009 · Filed: December 2, 2009

3.5 HOURS INTO TRIP FROM ROSEVILLE, CA TO SAND MOUNTAIN, NV, WE STOPPED AT PILOT TRUCK STOP TO RENDEZVOUS WITH OTHERS IN GROUP. NO POTHOLES/CURBS HAD BEEN ENCOUNTERED. AFTER APPROXIMATELY A 45 MINUTE STOP, WE STARTED AGAIN, AND AS WE ACCELERATED TO 60MPH ON I-80, 1MILE EAST OF FERNLEY, THE FRONT AXLE-RIGHT TIRE BLEW OUT. WE PULLED OFF AT NEXT EXIT. THE TIRE'S CENTER BELT HAD SEPARATED, DAMAGING THE CENTER AXLE TIRE, AND PROPANE LINES TO TRAILER. TIRES WERE CHECKED AND INFLATED TO 80PSI BEFORE STARTING TRIP. *TR

Tires

ODI #10277388

Incident: July 16, 2009 · Filed: July 19, 2009

ON JULY 16, 2009 WE WERE HEADING IN OUT IN OUR FIFTH WHEEL, WE WERE ON I-15 HEADING SOUTH IN UTAH AND ONE OF OUR TIRES HAD A BLOW OUT, WE CALLED OUR ROADSIDE ASSISTANCE AND THE CAME AND INSTALLED OUR SPARE TIRE. THEN UPON RETURNING BACK HOME ON JULY 19, 2009 WE HAD ANOTHER TIRE BLOW OUT ON THE SAME SIDE OF OUR FIFTH WHEEL, THIS TIME THE OTHER TIRE WENT AND WE HAD NO SPARE BECAUSE IT WAS ON OUR RV ALREADY. THE TIRE ARE JUST OVER A YEAR OLD AND THEY DON'T HAVE MORE THAN 2500 MILES ON THEM. WE HAD TO PURCHASE A NEW TIRE FROM THE ROADSIDE SERVICE THAT CAME AND HE LOOKED AT OUR REMAINING TWO TIRES ON THE LEFT SIDE AND SAID WE BETTER REPLACE THEM BEFORE OUR NEXT TRIP AND THEY WERE NOT GOOD TIRES. THE BLOW OUT HAPPENED ON I-15 IN UTAH AND ON STATE ROAD 28 IN UTAH BY LEVAN. THE BLOWOUT HAPPENED ON THE RIGHT PASSENGER SIDE OF OUR RV ON TWO DIFFERENT DAYS. THE SECOND BLOWOUT CAUSED DAMAGE TO OUR FIFTH WHEEL, IT TORE OF THE METAL SIDE WALL, BUSTED A LIGHT, DAMAGED THE GAS LINE AND THE UNDER OR BOTTOM WALL OF OUR FIFTH WHEEL. WE ARE WORRIED THAT THE TIRES ARE DEFECTIVE AND WOULD LIKE TO HAVE IT LOOKED INTO. WE FIND IT ODD THAT WE HAD TWO BLOWOUT IN THE SAME TRIP. THANK YOU, SHANE AND WENDY MURRAY *TR

Other Keystone Fuzion model years

Check your 2008 Keystone Fuzion VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Keystone Fuzion at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Keystone VIN