NHTSA vehicle safety data

1999 Kenworth T2000 Recalls & Complaints

The 1999 Kenworth T2000 has 8 NHTSA recall campaigns on file as of October 21, 2026. try.vin has no NHTSA owner complaints on file for the 1999 Kenworth T2000. Recall repairs are usually free at an authorized Kenworth dealer.

NHTSA recall and complaint data for the 1999 Kenworth T2000. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

PACCAR/ARVINMERITOR/SKF/FRONT AXLE HUBS

NHTSA #03V125000 · Suspension — Front — Hub · NHTSA notice

Reported April 1, 2003 · PACCAR INCORPORATED

Potentially affected: 154 vehicles

Manufacturer campaign 303-A/03KW2 · Owners notified July 16, 2003 · Vehicles built September 2, 1998 – December 6, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

Safety consequence

SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.

Manufacturer remedy

DEALERS WILL REPLACE ALL FRONT AXLE HUBS. NOTIFICATION BEGAN JULY 16, 2003. THE MANUFACTURER HAS ADVISED US THAT PARTS WILL NOT BE AVAILABLE UNTIL SEPTEMBER 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITH A REASONABLE TIME SHOULD CONTACT PETERBILT AT 940-591-4201 OR KENWORTH 425-828-5440.

Notes

KENWORTH RECALL NO. 03KW2 AND PETERBILT RECALL NO. 303-A.CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/ARVINMERITOR/TRW TIE ROD ENDS (20EDL)

NHTSA #02V037003 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported July 15, 2002 · PACCAR, INCORPORATED

Potentially affected: 4,513 vehicles

Manufacturer campaign 102A/02KW2 · Owners notified July 15, 2002 · Vehicles built December 11, 1999 – September 30, 2000 (per NHTSA)

Defect description

HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN ARVINMERITOR AND DANA AXLES. PETERBILT WILL RECALL 1,434 VEHICLES EQUIPPED WITH ARVINMERITOR AXLES MANUFACTURED FROM DECEMBER 11, 1999, TO MAY 14, 2000, AND FROM JULY 22 TO SEPTEMBER 30, 2000. KENWORTH WILL RECALL 859 VEHICLES EQUIPPED WITH ARVINMERITOR VEHICLES MANUFACTURED FROM DECEMBER 11, 1999, TO MAY 23, 2000, AND FROM JULY 27, 2000, TO SEPTEMBER 30, 2000 AND KENNWORTH WILL RECALL AN ADDITIONAL 4,151 VEHICLES EQUIPPED WITH DANA AXLES AND MANUFACTURED FROM JUNE 23 TO DECEMBER 6, 1999, AND FROM MAY 23 TO SEPTEMBER 30, 2000. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.

Safety consequence

THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Manufacturer remedy

DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN JULY 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4201 OR KENWORTH AT 1-425-828-5440.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/TRW TIE ROD ENDS (20EDL)

NHTSA #01V140006 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported August 28, 2001 · PACCAR, INCORPORATED

Potentially affected: 2,294 vehicles

Owners notified October 24, 2001 · Vehicles built June 23, 1999 – December 15, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.

Safety consequence

THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Manufacturer remedy

DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN OCTOBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000 OR KENWORTH AT 1-425-828-5000.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/TRW STEERING SYSTEMS/TIE ROD

NHTSA #01V044005 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported March 1, 2001 · PACCAR, INCORPORATED

Potentially affected: 6,392 vehicles

Manufacturer campaign 201C/01KW03 · Owners notified April 10, 2001 · Vehicles built July 14, 1999 – September 22, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.

Safety consequence

IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN ON APRIL 10, 2001, TO KENWORTH OWNERS AND ON APRIL 25, 2001, TO PETERBILT OWNERS. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000, PETERBILT AT 1-940-591-4000 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/KENWORTH/LOWER SWAY ARM BOLTS

NHTSA #01V051000 · Suspension — Front — Control Arm — Lower Arm · NHTSA notice

Reported February 20, 2001 · PACCAR, INCORPORATED

Potentially affected: 209 vehicles

Manufacturer campaign 01KW02 · Owners notified March 27, 2001 · Vehicles built February 19, 1996 – February 9, 2001 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 54" REAR AXLE SPACING CONFIGURATION OF THE AIRGLIDE 200 SUSPENSION WITH THE SERVICE APPLICATION IDENTIFIED AS LOGGER, DUMP TRUCK, OR TANKER. THE REAR SUSPENSION IS REGULARLY SUBJECTED TO EXTREME ARTICULATION, RESULTING IN FLEXING OF THE JOINT.

Safety consequence

FAILURE OF THE LOWER SWAY ARM ATTACHING BOLTS COULD RESULT IN LOSS OF VEHICLE CONTROL.

Manufacturer remedy

DEALERS WILL REPLACE THE LOWER SWAY ARM BRACKETS. OWNER NOTIFICATION BEGAN MARCH 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-425-828-5000.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/TRW TIE ROD ENDS

NHTSA #00V246102 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported September 13, 2000 · PACCAR, INCORPORATED

Potentially affected: 3,260 vehicles

Manufacturer campaign 800-G/00KW03 · Owners notified October 6, 2000 · Vehicles built July 7, 1999 – December 3, 1999 (per NHTSA)

Defect description

Safety consequence

THIS CAN LEAD TO PREMATURE WEAR WITH POSSIBLE SEPARATION OF THE BALL STUD FROM THE SOCKET, INCREASING THE RISK OF LOSS OF CONTROL OF THE VEHICLE.

Manufacturer remedy

DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS.

Notes

OWNER NOTIFICATION BEGAN OCTOBER 6, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PETERBILT AT 1-940-591-4000 OR KENWORTH AT 1-425-828-5000.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/HONEYWELL-BENDIX/BRAKE VALVE

NHTSA #00V026000 · Service Brakes, Air — Supply — Quick Release Valve · NHTSA notice

Reported February 1, 2000 · PACCAR, INCORPORATED

Potentially affected: 2,268 vehicles

Manufacturer campaign 00KW01 · Owners notified February 29, 2000 · Vehicles built August 30, 1999 – January 14, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH BRAKE VALVES MANUFACTURED BY HONEYWELL BENDIX. THE ORIENTATION AND LOCATION OF THE BRAKE VALVE IS SUCH THAT WATER CAN GET INTO THE VALVE THROUGH A VENT IN THE VALVE. THE WATER WILL CONTAMINATE THE AIR SYSTEM AND COULD FREEZE THE BRAKE VALVE.

Safety consequence

IF FROZEN, THE OPERATOR WILL NOT BE ABLE TO MODULATE THE BRAKE FORCES WITH THE BRAKE PEDAL.

Manufacturer remedy

DEALERS WILL INSPECT THE AIR BRAKE SYSTEM AND MODIFICATIONS WILL BE MADE TO THE BRAKE VALVE.

Notes

OWNER NOTIFICATION BEGAN FEBRUARY 29, 2000.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT1-206-828-5000. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

PACCAR/ENGINE STALL

NHTSA #99V181001 · Electrical System — Ignition — Module · NHTSA notice

Reported July 9, 1999 · PACCAR, INCORPORATED

Potentially affected: 272 vehicles

Manufacturer campaign 99KW3/799-C · Vehicles built December 1, 1998 – June 30, 1999 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR ENGINES AND EATON AUTOSHIFT TRANSMISSIONS. THE ENGINES CAN STALL BECAUSE OF SOFTWARE PROBLEMS.

Safety consequence

INCREASED STEERING EFFORT CAN OCCUR.

Manufacturer remedy

DEALERS WILL UPDATE THESE ENGINES WITH SOFTWARE CHANGES. CATERPILLAR IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY OF THIS RECALL.

Notes

OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING AUGUST 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KENWORTH AT 1-206-828-5418 OR PETERBILT AT 1-940-591-4000.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 1999 Kenworth T2000. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

try.vin has no NHTSA owner complaints on file for the 1999 Kenworth T2000.

Other Kenworth T2000 model years

Check your 1999 Kenworth T2000 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Kenworth T2000 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Kenworth VIN