NHTSA vehicle safety data

2005 Honda Pilot Recalls, Ratings & Complaints

The 2005 Honda Pilot has 15 NHTSA recall campaigns and 679 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Honda dealer.

NHTSA recall and complaint data for the 2005 Honda Pilot, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Honda Pilot owner complaints

Owners have filed 679 complaints with NHTSA about the 2005 Honda Pilot, describing incidents dated December 31, 2004 to June 14, 2026.

Most-cited components

Power Train 176 complaints
Service Brakes 134 complaints
Air Bags 120 complaints
Electronic Stability Control (ESC) 97 complaints
Engine 90 complaints
Electrical System 57 complaints

Of the 679 complaints on file, 42 report a crash and 8 a fire; across all 679 complaints, owners report 46 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11744233 · Filed June 15, 2026
A stuck ignition lock cylinder on a 2005 Honda Pilot. Hello I purchased this car from the second owner and they had the ignition lock replaced less than 2 years ago. This device has now failed again. Its a poor design by honda and was never fixed or recalled. This has lead countless people to be…
ODI #11708565 · Filed January 3, 2026
Power steering high pressure line leaking on exhaust and almost caused fire Dangerous. Lines need to be recall or replace
ODI #11695419 · Filed October 24, 2025
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle…

Read all 679 complaints

Owner-reported

2005 Honda Pilot mileage at failure

558 of the 679 complaints on file for the 2005 Honda Pilot give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Power Train	Median 95,000 miles	Middle half 75,000–125,000 miles	Based on 165 complaints
Service Brakes	Median 100,000 miles	Middle half 75,000–125,000 miles	Based on 117 complaints
Air Bags	Median 120,000 miles	Middle half 90,000–150,000 miles	Based on 76 complaints
Electronic Stability Control (ESC)	Median 110,000 miles	Middle half 70,000–150,000 miles	Based on 88 complaints
Engine	Median 100,000 miles	Middle half 85,000–130,000 miles	Based on 83 complaints
Electrical System	Median 120,000 miles	Middle half 70,000–150,000 miles	Based on 47 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Honda Pilot in 7 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page
Engineering Analysis EA13-002: Vehicle Stability Assist Malfunction
Closed March 29, 2013
- Recall 13V-092
Preliminary Evaluation PE12-028: Vehicle Stability Assist Malfunction
Closed March 15, 2013

2 more NHTSA investigations

Defect Petition DP12-002: Vehicle Stability Assist Malfunction
Closed October 11, 2012
Engineering Analysis EA11-012: Low Beam Headlights Stop Illuminating
Closed September 17, 2012
- Recall 12V-136

Open and recently closed NHTSA defect investigations

Accelerator Pedal May Bind/FMVSS 124

NHTSA #19E068000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported October 10, 2019 · Dorman Products, Inc.

Potentially affected: 3,744 vehicles

Repair completion: 65.51% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified December 9, 2019

Defect description

Dorman Products, Inc. (Dorman) is recalling certain Accelerator Pedal Assemblies part numbers 699-114 and 825-5029-1, sold as replacement parts for 2003-2006 Acura MDX, 2004-2008 Acura TL and TSX, 2003-2007 Honda Accord, 2005-2006 Honda CR-V, 2007-2011 Honda Element, 2005-2008 Honda Pilot and 2006-2014 Honda Ridgeline vehicles. The rotating portion of the accelerator pedal assembly may bind. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 124, "Accelerator Control Systems."

Safety consequence

If the accelerator pedal binds, the engine may not quickly return to idle after the pedal is no longer pressed, increasing the risk of a crash.

Manufacturer remedy

Dorman will notify owners, and qualified service facilities will replace the affected accelerator pedal assemblies, free of charge. The recall began December 9, 2019. Owners may contact Dorman customer service at 1-800-523-2492, using option 5. Dorman's number for this recall is AS1019XXXX.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #19V501000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 27, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 1,657,752 vehicles

Repair completion: 47.72% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign E5D, X5C · Owners notified August 12, 2019 · Vehicles built July 29, 2004 – August 29, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are E5D and X5C.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver Frontal Air Bag Inflator May Explode

NHTSA #19V499000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported June 27, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 3,947 vehicles

Repair completion: 29.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign Q5A, Y58 · Owners notified August 12, 2019 · Vehicles built September 9, 2004 – August 23, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are Q5A and Y58.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver Frontal Air Bag Inflator May Explode

NHTSA #19V182000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported March 6, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 1,101,534 vehicles

Repair completion: 54.23% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign U40,M45,O41,G44 · Owners notified April 10, 2019 · Vehicles built September 7, 2004 – August 26, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.

Safety consequence

An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Improperly Installed Passenger Air Bag

NHTSA #18V268000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported April 26, 2018 · Honda (American Honda Motor Co.)

Potentially affected: 1,335 vehicles

Repair completion: 86.4% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign C1X, N2L, U2M · Owners notified June 22, 2018 · Vehicles built February 2, 2005 – July 14, 2005 (per NHTSA)

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.

Safety consequence

An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.

Manufacturer remedy

Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #17V029000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported January 10, 2017 · Honda (American Honda Motor Co.)

Potentially affected: 308,884 vehicles

Repair completion: 71.85% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign KD9, KE0 · Owners notified February 27, 2017 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2011 Honda Element vehicles, 2005-2012 Acura RL vehicles, 2006-2012 Honda Ridgeline vehicles, 2007-2008 Honda Fit vehicles and 2005-2008 Honda Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2009 Acura RL and Honda Element vehicles, 2007-2008 Honda Fit vehicles, 2005-2008 Honda Pilot vehicles and 2006-2009 Honda Ridgeline vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone A" or "Zone B" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2008 Acura RL, Honda Element and Honda Pilot vehicles, 2007-2008 Honda Fit vehicles and 2006-2008 Honda Ridgeline vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall bagan March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KD9 and KE0.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V344000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 23, 2016 · Honda (American Honda Motor Co.)

Potentially affected: 1,790,894 vehicles

Repair completion: 57.83% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign KA0, KA1, KA2, KA3 · Owners notified June 29, 2016 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda Element, and Honda Pilot vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KA0, KA1, KA2, and KA3.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver's Frontal Air Bag May Rupture

NHTSA #15V320000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 28, 2015 · Honda (American Honda Motor Co.)

Potentially affected: 6,281,043 vehicles

Repair completion: 79.01% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign JQ9 & JR0-JR8 · Owners notified July 1, 2015 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138. Owners may contact Acura customer service at 1-800-382-2238, select option 4. Note: Vehicles that have had their driver frontal air bag replaced previously as part of a recall remedy prior to September 12, 2014 need to have their air bag replaced under this recall as well. Vehicles that, on or after September 12, 2014, received a remedy for a prior driver frontal air bag inflator recall already received an inflator of a different design, and therefore are not included in this recall and do not require additional servicing. Note: This recall fully supersedes recalls 08V-593, 09V-259, 10V-041, 11V-260, 14V-351 and 15V-153. Honda's numbers for this recall are JQ9, JR0, JR1, JR2, JR3, JR4, JR5, JR6, JR7, and JR8.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Air Bag Inflator May Rupture

NHTSA #14V700000 · Air Bags · NHTSA notice

Reported November 4, 2014 · Honda (American Honda Motor Co.)

Owners notified January 26, 2015 · Vehicles built November 26, 2001 – May 20, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

American Honda Motor Co. (Honda) is recalling certain model year 2001-2005 Honda Civic, 2003-2004 Civic CNG and Element, 2002-2005 CR-V, 2002-2004 Odyssey, 2003-2005 Accord, Pilot, Civic Hybrid, and Acura MDX, 2005 Acura RL and 2006 Honda Ridgeline vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger side air bag inflator, free of charge. The recall began January 26, 2015. Owners may contact Honda customer service at 1-800-999-1009.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.Note: This recall supersedes safety recall 14V-353, with the exception of vehicles originally sold, or ever registered, in California.Those vehicles will continue to be addressed, and a free remedy provided, under that safety recall campaign.This recall also includes vehicles in the specific geographic areas listed above that were included within safety recalls 13V-132 and 14V-349.

Passenger Side Air Bag Inflator may Rupture

NHTSA #14V353000 · Air Bags · NHTSA notice

Reported June 20, 2014 · Honda (American Honda Motor Co.)

Potentially affected: 133,207 vehicles

Repair completion: 70% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign JH6,JH7,JH8,JH9,JJ0 · Owners notified September 12, 2014 · Vehicles built July 29, 2004 – May 20, 2005 (per NHTSA)

Recall group: Takata airbag inflators

Defect description

American Honda Motor Company, Inc.'s (Honda) is conducting a limited regional recall for certain model year 2003-2005 Accord, Civic, CR-V, Pilot and Acura MDX, model year 2003-2004 Odyssey and Element, and model year 2005 Acura RL, and 2006 Honda Ridgeline vehicles originally sold, or ever registered in California, and equipped with Takata-brand air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Safety consequence

Manufacturer remedy

Honda will notify owners, and dealers will replace the inflators in all affected vehicles, free of charge. The recall is expected to begin during August 2014. Owners may contact Honda customer service at 1-800-999-1009.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Inadvertent Application of Brakes

NHTSA #13V092000 · Service Brakes, Hydraulic — Antilock/Traction Control/Electronic Limited Slip — Control Unit/Module · NHTSA notice

Reported March 14, 2013 · Honda (American Honda Motor Co.)

Potentially affected: 183,576 vehicles

Honda campaign S87, S88, S89 · Owners notified April 22, 2013 · Vehicles built July 29, 2004 – August 29, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Honda is recalling certain model year 2005 Pilot vehicles manufactured July 29, 2004, through August 29, 2005; model year 2005-2006 Acura MDX vehicles manufactured September 16, 2004, through September 22, 2005; and model year 2005 Acura RL vehicles manufactured March 1, 2004, through June 29, 2005. An electrical capacitor may have been damaged during the manufacturing of the Vehicle Stability Assist (VSA) control module causing intermittent, automatic, minor brake application. However, if the driver applies the brakes while the VSA is malfunctioning, the vehicle may come to an abrupt stop. Additionally, due to a loose ground connection, certain model year 2005 Pilots have a VSA system that may apply partial brake force, without the illumination of the brake lights, whether or not the driver is using the brakes.

Safety consequence

Sudden inadvertent braking, especially without illumination of the brake lights, may increase the risk of a vehicle crash.

Manufacturer remedy

Owners will be notified and instructed to take their vehicles to a dealer of their respective brand. The dealer will install a partial wiring harness containing a capacitor for the VSA modulator, free of charge. The affected model year 2005 Pilots will have their ground connection tightened. The recall began on April 22, 2013. Honda owners may contact Honda Automobile Customer Service at 1-800-999-1009, and select option 4 or go to www.recalls.honda.com; Acura owners may contact 1-800-382-2238, and select option 4, or go to www.recalls.acura.com.

Notes

Honda's recall campaign numbers are S87, S88, and S89.Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

LOW BEAM HEADLIGHT

NHTSA #12V136000 · Exterior Lighting — Headlights — Switch · NHTSA notice

Reported March 30, 2012 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 1,375,217 vehicles

Honda campaign S34, S51 · Owners notified April 27, 2012 · Vehicles built July 29, 2004 – August 29, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

HONDA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V; MODEL YEAR 2003 THROUGH 2005 PILOT; AND MODEL YEAR 2002 AND 2003 CIVIC VEHICLES. IN MARCH 2012, HONDA FILED A DEFECT REPORT TO RECALL CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V AND CERTAIN MODEL YEAR 2003 PILOT VEHICLES. IN AUGUST 2012, HONDA INFORMED THE AGENCY THAT IT WAS INCLUDING AN ADDITIONAL 820,789 VEHICLES INCLUDING CERTAIN MODEL YEAR 2004 AND 2005 PILOTS AND MODEL YEAR 2002 AND 2003 CIVICS. THE TOTAL NUMBER OF VEHICLES BEING RECALLED IS NOW 1,375,217. DUE TO TENSION FROM THE COMBINATION SWITCH WIRING HARNESS, WEAR ON THE SURFACE OF THE ELECTRICAL TERMINAL CAN OCCUR, YIELDING COPPER OXIDE, WHICH INCREASES ELECTRICAL RESISTANCE. INCREASED ELECTRICAL RESISTANCE MAY CAUSE THE TERMINAL ENDS TO MELT WITHIN THE WIRING HARNESS CONNECTOR.

Safety consequence

IF THE TERMINAL ENDS MELT WITHIN THE WIRING HARNESS CONNECTOR, THE LOW BEAM HEADLIGHTS MAY BECOME INOPERATIVE, REDUCING DRIVER VISIBILITY AND INCREASING THE RISK OF A CRASH.

Manufacturer remedy

HONDA WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE LOW BEAM TERMINAL HARNESS OR REPLACE THE LIGHTING SWITCH AS NECESSARY, FREE OF CHARGE. THE ORIGINAL RECALL BEGAN IN APRIL 2012. OWNERS OF VEHICLES INVOLVED IN THE SEPTEMBER 2012 EXPANSION WILL BE NOTIFIED IN SEPTEMBER 2012. OWNERS MAY CONTACT HONDA CUSTOMER SERVICE AT 1-800-999-1009.

Notes

HONDA'S RECALL CAMPAIGN NUMBER FOR THE ORIGINAL RECALL IS S34.HONDA'S RECALL NUMBER FOR THE ADDITIONAL VEHICLES IS S51.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET HITCH STYLE BIKE RACK

NHTSA #08E013000 · Equipment — Mechanical — Carrier/Rack · NHTSA notice

Reported February 5, 2008 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 2,032 vehicles

Defect description

HONDA IS RECALLING 2,032 HITCH STYLE BIKE RACKS SOLD AS AFTERMARKET FOR USE ON MY 2003-2007 AND SOME MY 2008 HONDA PILOT, RIDGELINE, AND ACURA MDX VEHICLES. A PINCH BOLT EXISTS BETWEEN THE BIKE ARM BRACKET AND THE UPRIGHT ASSEMBLY OF THE "HITCH" STYLE BICYCLE RACK.

Safety consequence

WHEN MOVING THE BIKE ARM BRACKET TO ITS DOWN POSITION, THIS PINCH BOLT HAS THE POTENTIAL OF CAUSING SEVERE LACERATION OR AMPUTATION TO THE USER'S FINGERTIPS OR HAND.

Manufacturer remedy

OWNERS SHOULD CONTACT THULE AT 800-THULE91 (800-848-5391) TO OBTAIN A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS OR OWNERS MAY CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238 FOR FURTHER INFORMATION.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

STEERING COLUMN

NHTSA #05V039000 · Steering — Column · NHTSA notice

Reported February 3, 2005 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 203 vehicles

Honda campaign P70 · Owners notified January 25, 2005 · Vehicles built January 14, 2005 – January 22, 2005 (per NHTSA)

Defect description

ON CERTAIN MINIVANS AND SPORT UTILITY VEHICLES, THE STEERING COLUMN MAY BE INCORRECTLY ASSEMBLED, WHICH COULD RESULT IN A LOSS OF STEERING CONTROL.

Safety consequence

LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.

Manufacturer remedy

OWNERS WERE NOTIFIED BY TELEPHONE ON JANUARY 25, 2005, AND ARRANGEMENTS WERE MADE TO HAVE THEIR VEHICLES TOWED TO THEIR DEALERS AND HAVE THE REPAIRS PERFORMED. THE RECALL BEGAN ON JANUARY 25, 2005.

Notes

HONDA RECALL NO. P70.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

HONDA/FUEL TANK

NHTSA #04V541000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported November 18, 2004 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 61 vehicles

Owners notified November 10, 2004 · Vehicles built October 27, 2004 – November 1, 2004 (per NHTSA)

Defect description

ON CERTAIN SPORT UTILITY VEHICLES, SOME FUEL TANKS WERE IMPROPERLY MANUFACTURED.

Safety consequence

IN A CRASH, THE FUEL TANK COULD BE DAMAGED AND LEAK FUEL. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS REPLACED THE FUEL TANK. ALL OWNERS WERE NOTIFIED BY TELEPHONE ON NOVEMBER 10, 2004.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2005 Honda Pilot 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

16% rollover risk

Safety Technology

Electronic Stability Control

7 investigations

679 owner complaints have been filed with NHTSA for the 2005 Honda Pilot.

Steering

ODI #11744233

Incident: June 14, 2026 · Filed: June 15, 2026

A stuck ignition lock cylinder on a 2005 Honda Pilot. Hello I purchased this car from the second owner and they had the ignition lock replaced less than 2 years ago. This device has now failed again. Its a poor design by honda and was never fixed or recalled. This has lead countless people to be stranded. With repairs upwords of $500.

Steering

ODI #11708565

Incident: January 1, 2026 · Filed: January 3, 2026

Power steering high pressure line leaking on exhaust and almost caused fire Dangerous. Lines need to be recall or replace

Air Bags; Vehicle Speed Control; Service Brakes

ODI #11695419

Crash 1 injury

Incident: October 23, 2025 · Filed: October 24, 2025

The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.

Steering; Service Brakes, Hydraulic; Electronic Stability Control (ESC)

ODI #11691189

Incident: October 2, 2025 · Filed: October 3, 2025

The contact owns a 2005 Honda Pilot. The contact stated that while driving 25-35 MPH, the vehicle slowed down unexpectedly, and the brake pedal was hard and slow to respond when depressed. The contact stated that the steering wheel was pulling to the left, and it was difficult to correct the steering wheel. The vehicle was difficult to control. The VSA light was illuminated. There was a triangle with an exclamation mark symbol displayed on the instrument cluster. The vehicle was taken to the local dealer, where it was diagnosed and determined that the VSA module had failed and needed to be replaced. The vehicle was not repaired because the parts were on backorder. The manufacturer was not notified of the failure. The approximate failure mileage was 173,273.

Suspension

ODI #11628163

Incident: March 30, 2023 · Filed: December 1, 2024

The rear trailing arm, normally attached to the rear suspension is clearly corroded and came detached when driving under 25 mph up a road. The SAME issue Honda had to do a recall on their 2005 CRV model. Researched Honda Pilots, in our (Midwest) area, EVERY SINGLE 2005 Pilot had the corrosion. Also cause the muffler pipe to detach from the catalytic converter (included in the photos attached).

Seats

ODI #11618909

Incident: October 8, 2024 · Filed: October 9, 2024

I was leaning back looking backwards while reversing and the front left seat bracket on the driver’s seat cracked and separated resulting in my seat turning into a rocking chair and my feet coming off of the pedals. It could have ended in an accident.

Electrical System; Air Bags

ODI #11577511

Incident: January 1, 2024 · Filed: March 15, 2024

Airbag is deactivated due to failure of both crash sensors on the vehicle. Replacement parts are on national backorder.

Suspension; Unknown or Other

ODI #11574041

Incident: June 1, 2023 · Filed: February 26, 2024

The rear suspension got detached from a collapsed/rusted Frame. Item # 11 Sub-Frame, Rear Suspension Part # 50300-S9V-A01 The suspension is rubbing against the rear tires since the Bolt Flange (14x125 item# 14 part # 90160-S0X-A00) can’t be supported by the rusted/ collapsed Frame affecting the rest of suspension parts item # 12 washer E subframe part# 50354-S3V-A00 and item#13 part# 50456-S3V-A00 Washer F subframe Mounting.

Exterior Lighting

ODI #11557678

Incident: November 23, 2023 · Filed: November 30, 2023

The contact owns a 2005 Honda Pilot. The contact stated that while waiting in line at a gas station, she smelled a burning odor, and there was smoke coming from the steering wheel. The contact was turned off and restarted the vehicle. The contact stated that upon activating the low-beam headlights, the failure reoccurred. The contact stated that upon restarting the vehicle without activating the low-beam headlights, the steering wheel stopped smoking. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 12V136000 (Exterior Lighting). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was approximately 220,000.

Suspension

ODI #11527807

Crash

Incident: June 5, 2023 · Filed: June 19, 2023

The rear subframe attaches to the unibody has rotted and almost fell off the car

Other Honda Pilot model years

Check your 2005 Honda Pilot VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Honda Pilot at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Honda VIN