2026 Honda Pilot Recalls & Complaints

Incident: October 17, 2026 · Filed: October 21, 2026

The vehicle has a critical, severe multi-system factory safety defect involving structural steering/alignment and advanced driver assistance systems (ADAS) software. 1. STRUCTURAL DEFECT: From the time of delivery, the vehicle had out-of-specification factory alignment causing extreme handling instability, violent chassis/brake vibrations under acceleration/braking, and severe, premature tire rubber scrubbing/burning. Hayward Honda documented factory alignment failure on July 9, 2026, at 1,615 miles. AutoNation Honda Fremont documented severe vehicle pulling and drifting on September 4, 2026, at 2,533 miles. 2. LIFE-THREATENING ADAS SOFTWARE CRASH: The Honda Sensing Suite, specifically Lane Keeping Assist System (LKAS) and Adaptive Cruise Control (ACC), intermittently malfunctions, short-circuits, and drops connection. On a high-speed bridge en route to San Francisco Airport, while traveling with my teenage son, the automated steering suddenly and violently jerked completely out of the lane to the left, attempting to collide with an adjacent vehicle. A fatal crash was avoided solely by instantaneous manual driver physical intervention to overpower the electronic steering rack. Dealership service management has admitted on paper that these safety features operate at a restricted 60% to 70% capacity, making the vehicle an immediate public safety hazard on public roads. Honda Corporate has failed to issue a recall or buyback over a three-month escalation matrix.

Incident: September 30, 2026 · Filed: October 19, 2026

Unknown issue and no recall available - Steering wheel started making a clicking noise at around 1200 miles on the vehicle. I have heard that many people have had this issue and got the clock spring replaced only for the issue to return.

Incident: September 1, 2026 · Filed: October 19, 2026

Steering wheel makes a clicking sound. Should not due that

Incident: September 17, 2026 · Filed: October 17, 2026

This is the description from my wife, who was driving the vehicle at the time. I was driving and the check engine light came on and the car started to violently shake. I lost the ability to accelerate. Fortunately, I was able to steer the car to safety and use the emergency brake to stop the vehicle. I called the nearest dealership and they told me to turn it off and if they engine warning light came back on, to contact honda to tow it. The light did not come back on so they suggested that I drive it to them, which was only 7 miles away. Within 1/5 of a mile, they same thing happened- check engine light came on, I lost the ability to accelerate and all warning lights came on including brake system failed. I was again able to pull over safely and stop the vehicle. Honda corp. had it towed to the dealership. It was there for 5 days. It was an engine problem. I have uploaded detailed reports for you. After honda shipped the car back to me, the gas pedal was acting strange. There was a grinding/vibrating sensation upon acceleration. Sometimes it does hesitate to accelerate. I brought it to the dealership closest to me. They kept it for 5 days. They told me that the engine misfired but that could be from anything. They were in contact with honda corp. No codes happened even when they drove it 115 miles. I was told to pick it up and return the rental they provided. My concern is for my safety. The cause of the engine issue initially has not been identified to me and I do not feel safe driving this car. Fortunately, both times I could not accelerate there were no other vehicles behind me and I was able to get to safety very quickly and stop the vehicle. However, this was engine failure and should not have happened on a brand new car. We do have a case # with honda corporation and have not heard back from them. They are only reimbursing us for car rental and hotel.

Incident: August 20, 2026 · Filed: October 5, 2026

Steering wheel is stiff and constantly clicking when I turn the wheel. My dealership said there have been several complaints but no recall and they could not do anything to fix the issue at this time. I am concerned that it could be a safety issue if it is not addressed. This has been an issue since I purchased the vehicle brand new in August 2026.

Incident: August 1, 2026 · Filed: September 23, 2026

Steering wheel makes a clicking noise. the internal steering rack or the cable reel (clock spring) behind the wheel.

Incident: July 6, 2026 · Filed: September 22, 2026

Steering wheel started making a clicking noise after a couple hundred miles. Dealer replaced clock spring and wrapped in felt tape. I could hear the felt tape a few days later when turning the wheel, and the clicking returned within a few hundred miles, returned to dealer again and they replaced clock spring again and wrapped in felt tape. The issue was only fixed for 1 day before I started hearing the felt tape when turning the wheel.

Incident: September 15, 2026 · Filed: September 15, 2026

When turning steering there is a clicking noise almost like a spring clicking on a gear. It is sound like it is coming from under the middle part where the airbag sits. Not sure if it is the airbag mechanism that it is the attached to the steering or a faulty clock spring.

Incident: May 28, 2026 · Filed: September 14, 2026

We believe there is a serious safety issue with our 2026 Honda Pilot with its delayed acceleration. There is a distinct delay between pushing the gas pedal and the engine engaging/moving the car forward (approximately 2 seconds). This has nothing to do with the Auto Idle Stop function. I've attached a vLinker MC+ device to our car's OBD port and used the Car Scanner mobile app ([XXX]) to measure the delay. I'm attaching visual proof of the delay between the gas pedal and the engine RPMs. The reason we believe this is a safety issue is that when trying to merge into traffic (think of crossing 2 lanes to turn left) the delay means you have no confidence you'll make it safely across without getting broadsided because the car won't accelerate when it is needed. This sounds eerily similar to NHTSA 25V-031. The engine hesitation will cause an accident at some point. This issue was reported to Honda customer care (case #XXX) but they declined to address the situation and pushed it back on the local Honda dealer. "All technical evaluations and potential escalations must originate with, and be requested by, an authorized Honda dealership based on their inspection findings." We already brought this up with our local Honda dealer in a service call on XXX. It was documented in our service record with them. They asked us to submit the issue to Honda Customer Care. Since all parties are pointing the finger at each other, we are raising this safety issue with NHTSA. This is a new vehicle purchased at the end of May, 2026. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: August 23, 2026 · Filed: September 2, 2026

Steering wheel makes a clicking/spring noise when turning, especially at low speeds