NHTSA vehicle safety data

2006 Ford Mustang Recalls, Ratings & Complaints

The 2006 Ford Mustang has 9 NHTSA recall campaigns and 424 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2006 Ford Mustang, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Ford Mustang owner complaints

Owners have filed 424 complaints with NHTSA about the 2006 Ford Mustang, describing incidents dated November 20, 2005 to August 18, 2026.

Most-cited components

Air Bags 228 complaints
Fuel/Propulsion System 44 complaints
Vehicle Speed Control 35 complaints
Power Train 32 complaints
Electrical System 31 complaints
Structure 30 complaints

Of the 424 complaints on file, 19 report a crash and 3 a fire; across all 424 complaints, owners report 15 injuries and 2 deaths (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11763545 · Filed September 11, 2026
The contact owned a 2026 Ford Mustang. The contact stated that while driving 65 MPH with the top down, the touch screen washed out due to the glare from the sun on the screen. The contact pulled over to operate the screen. The screen was not close enough while driving, which caused the driver to…
ODI #11757839 · Filed August 18, 2026
A/C lines keep getting pinholes through them. Took to a professional shop 2 different times for 2 different lines and another one just blew for the 3rd time in only 2k miles in just over a year of owning the car.
ODI #11707368 · Filed December 28, 2025
This has happened since purchasing my personal 2006 Mustang GT new in 2006. I also see early S-197 Mustangs (2005—2007) in my shop that cannot be reliably refilled because fuel shoots out of the filler neck, splashes the operator, the side of the Mustang, and puddles on the ground. The defective…

Read all 424 complaints

Owner-reported

2006 Ford Mustang mileage at failure

190 of the 424 complaints on file for the 2006 Ford Mustang give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Air Bags	Median 70,000 miles	Middle half 55,000–100,000 miles	Based on 32 complaints
Fuel/Propulsion System	Median 20,000 miles	Middle half 1,000–65,000 miles	Based on 37 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Ford Mustang in 3 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Audit Query AQ10-001: Fleet Vehicle Recall Completion Audit
Closed December 28, 2015
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page

Open and recently closed NHTSA defect investigations

Frontal Air Bag Inflator May Explode

NHTSA #21V081000 · Air Bags — Frontal · NHTSA notice

Reported February 16, 2021 · Ford Motor Company

Potentially affected: 1,067 vehicles

Repair completion: 42.83% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Ford campaign 21S05 · Owners notified March 17, 2021 · Vehicles built September 23, 2006 – June 20, 2014 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Frontal Air Bag Inflator May Explode

NHTSA #21E013000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported February 16, 2021 · Ford Motor Company

Potentially affected: 249 vehicles

Repair completion: 0% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Ford campaign 21S05 · Owners notified March 17, 2021 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Ford Motor Company (Ford) is recalling certain air bag inflator and/or module replacement service parts that may have been used as part of a collision repair. The parts include certain driver-side air bag inflators and/or modules, designed to fit 2005-2014 Ford Mustang and Mustang GT500. It also includes certain passenger-side air bag inflators and/or modules designed to fit 2005-2014 Ford Mustang, 2010-2012 Lincoln MKZ, 2010-2012 Ford Fusion, 2010-2011 Mercury Milan, 2007-2011 Ford Ranger, and 2007-2010 Lincoln MKX vehicles. Please see Ford's recall report for the specific part numbers. These parts may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

Manufacturer remedy

Ford will notify dealers that purchased the affected parts, and dealers will provide replacement parts to purchasers, free of charge. The recall began March 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #17V024000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported January 10, 2017 · Ford Motor Company

Potentially affected: 654,695 vehicles

Repair completion: 22.15% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Ford campaign 19S01 · Owners notified February 14, 2018 · Vehicles built April 6, 2004 – December 19, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Ford dealer immediately.

Defect description

Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V384000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 31, 2016 · Ford Motor Company

Potentially affected: 1,892,343 vehicles

Repair completion: 24.55% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Ford campaign 19S01 · Owners notified February 2, 2018 · Vehicles built July 26, 2004 – February 3, 2011 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Ford dealer immediately.

Defect description

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver Side Frontal Air Bag May Rupture

NHTSA #15V319000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 28, 2015 · Ford Motor Company

Potentially affected: 1,018,622 vehicles

Repair completion: 45.15% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Ford campaign 15S21 · Owners notified June 10, 2016 · Vehicles built April 6, 2004 – June 21, 2014 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Ford dealer immediately.

Defect description

Ford Motor Company (Ford) is recalling certain model year 2005-2014 Mustang vehicles manufactured April 6, 2004, to June 21, 2014, and 2005-2006 GT vehicles manufactured February 20, 2004, to September 22, 2006. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the front driver side air bag inflator, free of charge. The recall began on June 10, 2016. Even if interim repairs were performed under safety recall 14V-802, owners must bring their vehicles in for the final remedy. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S21. Note: This recall supersedes safety recall 14V-802.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 208/NECK INJURY REQUIREMENTS

NHTSA #08V082000 · Air Bags — Frontal · NHTSA notice

Reported February 25, 2008 · FORD MOTOR COMPANY

Potentially affected: 434,593 vehicles

Ford campaign 08C02 · Owners notified March 3, 2008 · Vehicles built April 22, 2005 – January 31, 2008 (per NHTSA)

Defect description

FORD IS RECALLING 434,593 MY 2008 MUSTANG VEHICLES FOR FAILING TO COMPLY WITH ONE OF THE NECK INJURY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION," FOR AN UNBELTED 5TH PERCENTILE FEMALE SITTING IN THE PASSENGER SEAT WHILE IT IS IN THE FULL FORWARD POSITION.

Safety consequence

DURING AN AIR BAG DEPLOYMENT, IF A SMALL FEMALE IN THE FRONT PASSENGER SEAT IS NOT WEARING THE SAFETY BELT, AND HAS THE SEAT IN THE FULL FORWARD POSITION, THERE MAY BE AN INCREASED POTENTIAL FOR A NECK INJURY.

Manufacturer remedy

DEALERS WILL REPROGRAM THE RESTRAINT CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH EMAIL TO WWW.OWNERCONNECTION.COM.

Notes

FORD RECALL NO. 08C02.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT STRUT BRACKET SEPARATION

NHTSA #06E089000 · Suspension — Front · NHTSA notice

Reported October 27, 2006 · EIBACH SPRINGS, INC.

Potentially affected: 400 vehicles

Defect description

CERTAIN AFTERMARKET EIBACH BRANDED FRONT STRUTS ONLY, PART NO. 35101.8001, AND EIBACH BRANDED FRONT STRUTS AS SUSPENSION KITS, PART NOS. 35101.840, 35101.680, 35101.780, 35100.680, 35100.780, 4.10135.680, AND 4.10035.780, SOLD FOR USE ON 2005 THROUGH 2007 FORD MUSTANG VEHICLES. THE FRONT ANTI ROLL BAR ATTACHMENT BRACKET ON THE FRONT STRUT CAN SEPARATE FROM THE STRUT HOUSING DUE TO INCONSISTENT WELDING. THIS COULD RESULT IN A CLUNKING NOISE AND OR POOR HANDLING IN EXTREME OR EMERGENCY MANEUVERS.

Safety consequence

IF THE BROKEN BRACKET CONTACTS THE TIRE, SIDEWALL DAMAGE CAN OCCUR, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

EIBACH WILL NOTIFY OWNERS AND OFFER TO PROVIDE NEW STRUTS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 1, 2006. OWNERS MAY CONTACT EIBACH AT 951-256-8300.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET EIBACH BRANDED FRONT STRUTS AND SUSPENSION KITS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD MUSTANG GT VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Ford Mustang 2-DR

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 4, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

3 investigations

424 owner complaints have been filed with NHTSA for the 2006 Ford Mustang.

Equipment

ODI #11763545

Incident: May 1, 2026 · Filed: September 11, 2026

The contact owned a 2026 Ford Mustang. The contact stated that while driving 65 MPH with the top down, the touch screen washed out due to the glare from the sun on the screen. The contact pulled over to operate the screen. The screen was not close enough while driving, which caused the driver to remove the hand from the steering wheel. Additionally, the contact used his hands to cover the screen. The contact was nervous while driving the vehicle. The contact felt unsafe driving the vehicle. The contact was driving and drifting towards the right towards incoming traffic but was able to pull over to the left to avoid a crash. The Ford manufacturer was contacted on two occasions. The contact sold the vehicle. The contact stated that the designers might have overlooked the matter. The failure mileage was approximately 600.

Unknown or Other

ODI #11757839

Incident: August 18, 2026 · Filed: August 18, 2026

A/C lines keep getting pinholes through them. Took to a professional shop 2 different times for 2 different lines and another one just blew for the 3rd time in only 2k miles in just over a year of owning the car.

Fuel/Propulsion System

ODI #11707368

Incident: November 3, 2025 · Filed: December 28, 2025

This has happened since purchasing my personal 2006 Mustang GT new in 2006. I also see early S-197 Mustangs (2005—2007) in my shop that cannot be reliably refilled because fuel shoots out of the filler neck, splashes the operator, the side of the Mustang, and puddles on the ground. The defective On-board Refueling and Vapor Recovery (ORVR) system causes high internal fuel tank pressures that will also cause the filling station pump to cut off and prevent putting fuel in the tank. This creates a fire hazard as the spillage contacts the left hot tail pipe and muffler as well as a puddle of fuel that can be ignited by a spark, cigarette, etc. This problem is in direct violation of the Environmental Protection Agency emission standards that clearly state the operator is “expected to fill the fuel tank without spit back or spillage during the refueling event.” EPA emission regulations also require that service vents, also known as safety and vacuum relief valves, be installed in tanks to prevent excessive pressure or vacuum that can build up “due to tank filling or emptying.” The parts of the Ford ORVR system that contribute to the fuel tank pressure spikes and fuel spills include: 1.Poor fuel filler design. The filler pipe is narrow (5/8” to 3/4”) with a severe an S-bend before it reaches the tank. There is a spring-loaded plug at the top of tank built into the fill neck that closes the fill pipe until fuel pushes the plug down to open the fuel tank. 2.Poor fuel tank design. The saddle style tank has two sections that “saddle bag” over the drive shaft making the opening between the two tanks very narrow and at the top of the tank. 3.Insufficient tank venting system. The capacity of this vent system is not sufficient to vent the fuel tank during refueling. Please see attached file that documents the problem and possible solutions. I also recommend sharing your many complaints on this problem with the EPA as the problem is also in their area.

Air Bags

ODI #11675785

1 injury

Incident: July 24, 2025 · Filed: July 24, 2025

Driver side air bag randomly deployed after hitting bump at 40 miles an hour

Air Bags

ODI #11662831

Incident: May 18, 2025 · Filed: May 23, 2025

The contact owns a 2006 Ford Mustang. The contact stated that she purchased a vehicle that was not working. The contact had the engine replaced by an independent mechanic. While starting the vehicle, the air bag warning light illuminated. The contact received notification of NHTSA Campaign Number: 15V319000 (Air Bags) and 19V001000 (Air Bags). The vehicle was repaired at the local dealer, but the failure recurred. The dealer informed the contact that a diagnostic test was needed. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 230,272.

Air Bags

ODI #11636507

Incident: December 18, 2024 · Filed: January 17, 2025

See attached document for complaint.

Air Bags

ODI #11621809

Incident: October 24, 2024 · Filed: October 24, 2024

The contact owns a 2006 Ford Mustang. The contact received notification of NHTSA Campaign Number: 19V001000 (Air Bags); however, the part to do the recall repair was unavailable. The contact stated that several local dealers declined to perform the recall repair on the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Engine

ODI #11594407

Incident: May 1, 2023 · Filed: June 14, 2024

The contact owns a 2006 Ford Mustang. The contact stated while in reverse, he observed a grinding sound emanating from the engine compartment. The vehicle was towed to an independent mechanic where it was diagnosed that the timing chain guides needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 116,000.

Air Bags

ODI #11588232

Incident: May 11, 2024 · Filed: May 11, 2024

Did not sustain some sort of accident in order for me to notice thank God, I simply noticed thanks to multiple virtual methods which told me-considering how stupidly fast this car is and how important air bags are whe combined with that I thought id do this. Ford doesn't really care unless it can somehow bleed more money from something so...kinda just letting y'all know. Not much else I can do..other than drive really carefully (5-speed and I suck with Manual :()

Air Bags

ODI #11581266

Incident: April 5, 2024 · Filed: April 5, 2024

Dealership refuses to do recall

Other Ford Mustang model years

Check your 2006 Ford Mustang VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford Mustang at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN