NHTSA vehicle safety data

2003 Ford F-450 SD Recalls & Complaints

The 2003 Ford F-450 SD has 6 NHTSA recall campaigns and 16 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2003 Ford F-450 SD. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Ford F-450 SD owner complaints

Owners have filed 16 complaints with NHTSA about the 2003 Ford F-450 SD, describing incidents dated April 26, 2003 to April 25, 2013.

Most-cited components

Fuel/Propulsion System 6 complaints
Engine 4 complaints
Suspension 2 complaints
Tires 2 complaints
Service Brakes 1 complaint
Steering 1 complaint

Newest complaints

ODI #10510740 · Filed May 6, 2013
THE TRUCK BEGAN TO SHAKE AND LOSE POWER, EVENTUALLY NOT EVEN BEING ABLE TO STAY RUNNING. THE MECHANIC UPON REVIEW FOUND THE TANK LINER HAD DELAMINATED FROM INSIDE FUEL TANK AND HAD PLUGGED UP FUEL SENDER. BOTH NEEDED TO BE REPLACE AT A COST OF $2800, FORD DEALER STATED THERE WAS NOTHING THEY COULD…
ODI #10344315 · Filed July 20, 2010
THE EGR, FICM, AND INJECTORS ON THIS VEHICLE HAVE CAUSED TRAFFIC HAZARDS. WE CAN NOT PULL OUT WITHOUT THE ENGINE SPITTING AND SPUTTERING. WE HAVE REPLACE ALL OF THE ABOVE, SOME MORE THAN ONCE. LAST TIME IN TO THE FORD DEALER THEY SUGGESTED THAT WE USE A THINNER OIL TO LUBRICATE THE INJECTORS BETTER…
ODI #10334371 · Filed June 3, 2010
TRUCK HAS NO POWER WHEN FIRST STARTING AND THE FRONT END SHIMMIES SOMETHING TERRIBLE. HARD TO CONTROL. *TR

Read all 16 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2003 Ford F-450 SD in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA06-012: ENGINE STALLING
Closed December 7, 2007
- Recall 07V-553
Engineering Analysis EA05-003: ENGINE STALLING
Closed November 2, 2005
- Recall 05V-270
Engineering Analysis EA04-006: ACCELERATOR PEDAL SENSOR (ETC)
Closed February 10, 2005

Open and recently closed NHTSA defect investigations

STEERING COLUMN MULTIFUNCTION SWITCH/FMVSS 108

NHTSA #11V352000 · Exterior Lighting — Tail Lights · NHTSA notice

Reported July 13, 2011 · FORD MOTOR COMPANY

Potentially affected: 26,715 vehicles

Ford campaign 11C18 · Owners notified August 15, 2011

Defect description

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Safety consequence

NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Notes

FORD'S SAFETY RECALL NO. 11C18.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SPEED CONTROL DEACTIVATION SWITCH/OVERHEATS

NHTSA #09V399000 · Vehicle Speed Control · NHTSA notice

Reported October 13, 2009 · FORD MOTOR COMPANY

Potentially affected: 4,500,000 vehicles

Ford campaign 09S09 · Owners notified October 27, 2009 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Safety consequence

A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Manufacturer remedy

FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Notes

FORD'S RECALL CAMPAIGN NUMBER IS 09S09.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

CAMSHAFT POSITION SENSOR

NHTSA #07V553000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported December 5, 2007 · FORD MOTOR COMPANY

Potentially affected: 1,176,000 vehicles

Ford campaign 07S57 · Owners notified December 29, 2007 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.

Safety consequence

IN THE EVENT OF AN ENGINE STALL, A CRASH COULD RESULT WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL INSPECT THE SENSOR AND REPLACE IT WITH AN IMPROVED CAMSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 29, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Notes

FORD RECALL NO. 07S57.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS/TOW ASSEMBLIE

NHTSA #07E066000 · Equipment — Electrical · NHTSA notice

Reported August 28, 2007 · CEQUENT ELECTRICAL PRODUCTS

Potentially affected: 175 vehicles

Owners notified September 5, 2007

Defect description

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Safety consequence

IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

Manufacturer remedy

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET CEQUENT TOW PACKAGES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DAIMLERCHRYSLER, GMC, OR FORD VEHICLES.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

SPEED CONTROL DEACTIVATION SWITCH/SUPPLEMENT

NHTSA #07V078000 · Vehicle Speed Control · NHTSA notice

Reported March 6, 2007 · FORD MOTOR COMPANY

Potentially affected: 155,584 vehicles

Ford campaign 05S28 · Owners notified March 12, 2007 · Vehicles built August 1, 2002 – January 6, 2003 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Safety consequence

OVERHEATING COULD RESULT IN SMOKE, BURN, OR AN UNDERHOOD FIRE.

Manufacturer remedy

DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017, 05V388, AND 06V286)

Notes

FORD RECALL NO. 05S28. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FORD/BATTERY TERMINAL TO ENGINE BLOCK CONNECTION

NHTSA #04V327000 · Electrical System — 12V/24V/48V Battery · NHTSA notice

Reported July 7, 2004 · FORD MOTOR COMPANY

Potentially affected: 83,687 vehicles

Ford campaign 04S15 · Owners notified July 22, 2004 · Vehicles built December 1, 2002 – March 31, 2003 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES, THE ENGINE GROUND STUD THAT ATTACHES THE NEGATIVE BATTERY TERMINAL EYELET TO THE ENGINE BLOCK MAY BE LOOSE.

Safety consequence

IF THE GROUND WIRE IS LOOSE, ELECTRICAL CURRENT MAY FLOW TO THE RADIO SUPPRESSION STRAP CAUSING IT TO HEAT AND POTENTIALLY MELT OR IGNITE ADJACENT COMPONENTS WHICH COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE ENGINE GROUND STUD AND THE RADIO SUPPRESSION STRAP AND ADJACENT COMPONENTS WILL BE INSPECTED FOR DAMAGE AND REPLACED, IF NECESSARY. THE RECALL BEGAN ON JULY 23, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Notes

FORD RECALL NO. 04S15.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2003 Ford F-450 SD. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

16 owner complaints have been filed with NHTSA for the 2003 Ford F-450 SD.

Fuel System, Diesel

ODI #10510740

Incident: April 25, 2013 · Filed: May 6, 2013

THE TRUCK BEGAN TO SHAKE AND LOSE POWER, EVENTUALLY NOT EVEN BEING ABLE TO STAY RUNNING. THE MECHANIC UPON REVIEW FOUND THE TANK LINER HAD DELAMINATED FROM INSIDE FUEL TANK AND HAD PLUGGED UP FUEL SENDER. BOTH NEEDED TO BE REPLACE AT A COST OF $2800, FORD DEALER STATED THERE WAS NOTHING THEY COULD DO. *TR

Fuel System, Diesel

ODI #10344315

Incident: June 12, 2010 · Filed: July 20, 2010

THE EGR, FICM, AND INJECTORS ON THIS VEHICLE HAVE CAUSED TRAFFIC HAZARDS. WE CAN NOT PULL OUT WITHOUT THE ENGINE SPITTING AND SPUTTERING. WE HAVE REPLACE ALL OF THE ABOVE, SOME MORE THAN ONCE. LAST TIME IN TO THE FORD DEALER THEY SUGGESTED THAT WE USE A THINNER OIL TO LUBRICATE THE INJECTORS BETTER. THIS ALSO DOESN'T WORK. WE HAVE READ MANY PEOPLE ON THE INTERNET THAT HAVE THE SAME PROBLEM WITH THEIR DIESEL ENGINES SO WE KNOW IT'S NOT JUST OURS. WE PAID $8,000.00 TO REPAIR AND NOTHING IS BETTER. FORD REFUSES TO ADMIT THERE IS A PROBLEM. PLEASE HELP THOSE OF US THAT ARE STUCK WITH THESE TRUCKS. THE DATES OF INCIDENTS HAVE BEEN ONGOING. *TR

Suspension; Fuel System, Diesel

ODI #10334371

Incident: April 26, 2003 · Filed: June 3, 2010

TRUCK HAS NO POWER WHEN FIRST STARTING AND THE FRONT END SHIMMIES SOMETHING TERRIBLE. HARD TO CONTROL. *TR

Fuel System, Diesel

ODI #10322799

Incident: October 7, 2009 · Filed: March 30, 2010

THE COATING ON THE INTERIOR OF FORD DIESEL FUEL TANKS CORRODES AND COLLECTS AS SEDIMENT IN THE FUEL SYSTEM. THE SEDIMENT, COLLECTS AT THE BOTTON OF THE FUEL TANK AND IS SUCKED INTO THE FUEL SYSTEM. THE FUEL LINES BECOME FOULED, THE FUEL PUMPS BECOME CLOGGED AND REQUIRE REPLACEMENT. AS THE COATING CONTINUES TO DETERIORATE, THE ONLY RECOURSE IT TO CHANGE THE FUEL TANK, THE SENSORS, AND ENTIRE FUEL DELIVERY SYSTEM. WE HAVE HAD 3 FORD VEHICLES F SERIES EXPERIENCE THIS PROBLEM. THE AVERAGE REPAIR IS APPROXIMATELY $2180 PER VEHICLE. WE ARE REPORTING THIS AS IT SEEMS TO BE A DEFECT IN ALL THE FORD DIESEL FUEL SYSTEMS. AS THE FUEL SYSTEMS BECOME CLOGGED, THE VEHICLES LOSE POWER WITHOUT WARNING AND CREATE A SAFETY ISSUE AND DRIVING HAZARD NOT ONLY TO THE VEHICLE OPERATOR BUT OTHER MOTORISTS.

Engine and Engine Cooling

ODI #10256119

Incident: September 1, 2006 · Filed: January 23, 2009

WHEN DRIVING DOWN A HILL WITH LOTS OF TURNS. THE TRUCK STALLED (SHUT OFF) ALL OF THE SUDDEN RIGHT BEFORE A TURN. LUCKILY WAS ABLE TO KEEP THE TRUCK ON THE ROAD AND RESTART THE TRUCK IN NEUTRAL. TOOK TRUCK STRAIGHT TO HANSEL FORD ASKED THEM TO TELL ME WHAT WAS WRONG WITH THE TRUCK. THEY CHECKED THE COMPUTER IN THE TRUCK, AND SAID THEY COULD NOT FIND ANYTHING AND DIDN'T KNOW WHAT TO TELL ME. *TR

Fuel System, Diesel

ODI #10256109

Incident: December 20, 2008 · Filed: January 23, 2009

THE LINING OF THE FUEL TANK HAS BEEN FLAKING OFF INTO MY FUEL LINES, WHICH IS RESTRICTING MY FUEL FILTERS. BECAUSE OF THE LACK OF FUEL, 2 FUEL INJECTORS WENT BAD AND HAD TO BE REPLACED. AND THE TURBO WAS OVER COMPENSATING FOR THE LACK OF POWER, DUE TO FUEL SHORTAGE, SO THE TURBO HAD TO BE REPLACED AS WELL. NOW THAT WE HAVE FOUND THE SOURCE OF THE PROBLEM, THE FUEL TANK AND FUEL PUMP HAS TO BE REPLACED AS TOO. INTO THIS FOR $5000 ALREADY WITHOUT REPLACING THE TANK AND PUMP. NEED SOME HELP. *TR

Fuel System, Diesel

ODI #10249629

Incident: November 21, 2008 · Filed: November 24, 2008

THE LINING OF THE DIESEL FUEL TANK FLAKED OFF WHICH CLOGGED THE FUEL FILTERS, WHICH RESULTED IN POOR ENGINE PERFORMANCE. *TR

Tires

ODI #10239027

Incident: July 13, 2008 · Filed: August 20, 2008

TL*THE CONTACT OWNS A 2003 FORD F450 SUPER DUTY. THE VEHICLE HAS DOUBLE COIN RADIAL TIRES, SIZE 225/70/19.5 (NA). THIS COMPLAINT IS RELATED TO ODI NUMBER 10239016 REGARDING THE OTHER FIVE DEFECTIVE TIRES. THE TIRES WERE SERVICED BY AN INDEPENDENT TIRE MECHANIC AND TREAD SEPARATION WAS DISCOVERED IN SIX TIRES. THERE WAS ONE TIRE WITH A DIFFERENT DOT NUMBER. THE TIRES WERE REPLACED ON THE VEHICLE. THE FAILURE MILEAGE WAS 95,773 AND CURRENT MILEAGE WAS 96,343. UPDATED 10/16/08. *LJ UPDATED 10/20/08. *JB

Tires

ODI #10239016

Incident: August 13, 2008 · Filed: August 20, 2008

TL*THE CONTACT OWNS A 2003 FORD F450 SUPER DUTY. THE VEHICLE HAS DOUBLE COIN RADIAL TIRES, SIZE 225/70/19.5 (NA). THE TIRES WERE SERVICED BY AN INDEPENDENT TIRE MECHANIC AND TREAD SEPARATION WAS DISCOVERED IN SIX TIRES. THERE WERE FIVE TIRES WITH THE SAME DOT NUMBER. THE TIRES WERE REPLACED ON THE VEHICLE. THE FAILURE MILEAGE WAS 95,773 AND CURRENT MILEAGE WAS 96,343. UPDATED 10/16/08. *LJ THE TIRES WERE PRORATED. UPDATED 10/17/08. *JB

Engine and Engine Cooling

ODI #10152286

Incident: January 19, 2004 · Filed: March 9, 2006

EVENTS LEADING TO FAILURE: TRUCK WAS PURCHASED ON 12-19-03 1.) ON 1-19-04 TRUCK HAD NO POWER, DEALER FOUND 2,3 INJECTOR SHORTED, DEALER REPLACED INJECTORS AND CHECKED BORE IN CYL HEAD PER HOTLINE. 2.)1-21-04 ENGINE WAS MISSING IN FIRE. DEALER REPLACED BOTH INJECTORS PER HOTLINE. O-RINGS BLOWN APART AND INJECTOR WONT SEAT, HOTLINE SUGGEST LOOKING AT BORE AND FOUND BURR IN BORE NOT ALLOWING INJECTOR TO SEAT . 3.) 2-23-04 ENGINE LOCKED UP ON HWY, FUEL COMING OUT OF EXHAUST. DEALER FOUND EXCESSIVE FUEL IN CYLINDERS AND TURBO, DEALER REMOVED ENGINE AND DISASSEMBLED. NO. 3 INJECTOR DAMAGED AND COPPER WASHER IN PIECES O-RING BLOWN APART. DEALER CHECKED DECK HEIGHT, REMOVED RODS AND PISTONS TO CHECK FOR BEING BENT, DEALER REPLACED NO. 3 PISTON AND ROD AND TURBO BEARINGS, WASHED OUT AND TESTED. 4.)10-26-04 STEERING FEELS FUNNY WHEN DRIVING DOWN HWY. DEALER INSPECTING STEERING AND STEERING STABILIZER LEAKING FLUID. DEALER REMOVED AND REPLACED STABILIZER SHOCK. 5.)2-03-05 STEERING WHEEL BINDS UP WHILE TURNING. DEALER CHECKED AND VERIFIED CONDITION FLOW , PITMAN ARM SEIZED FLUSH SYSTEM METAL IN FLUID. 6.) 7-19-05 ENGINE HARD TO START. WHISTLE NOISE COMING FROM ENGINE WHEN RPMS REV HIGH. DEALER PERFORM COMPLETE ENGINE DIAG. REMOVED TURBO AND REPLACED EBP SENSOR PER SSM AND VERIFIED REPAIR. 7.)11-02-05 ENGINE HARD TO START, MUST PLUG BLOCK HEATER IN TO START. DEALER CHECKED AND CYL. 5 MISSED. DEALER REMOVED AND REPLACED NO.5 INJECTOR,TURBO CHARGER. DEALER FOUND OIL CONTAMINATED DUE TO INJECTOR, DEALER REMOVED AND REPLACE 1,3 INJECTOR. 8.) HARD TO START AND DOES NOT HAVE OIL PRESSURE. NEW DEALER REPLACED HIGH PRESSURE OIL PUMP AND TURBO PEDESTAL, REPLACED NO. 3 INJECTOR. *NM

Other Ford F-450 SD model years

Check your 2003 Ford F-450 SD VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-450 SD at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN