2017 Ford F-250 Recalls, Ratings & Complaints

Incident: May 8, 2026 · Filed: May 15, 2026

On 5/8/2026 at 1555 hours, while driving at normal freeway speed under normal driving conditions, vehicle began an exhaust system regeneration cycle. During the course of the region cycle, vehicle began to smoke excessively and realizing this wan not normal, I was able to yield to the right shoulder of the roadway. Almost immediately the vehicle ignited on fire and completely burned to the ground. The fire appeared to have commenced in the engine compartment, driver side near the firewall. The location of which appears to be consistent with reports of fuel filter failures I have read about in the past. The resulting fire ignited nearby brush which burned several hundred feet of brush and resulted in the spillage of diesel fuel and coolant which combined from the resulting melting of the coolant system and fuel tank and lines. This incident put both me and surrounding communities at risk, particularly from the resulting fire and HAZMAT spill. The vehicle was in good running condition prior to this incident. The incident was investigated by the Templeton California Highway Patrol.

Incident: April 8, 2026 · Filed: May 13, 2026

I am reporting a serious safety issue involving my 2017 Ford F-250 diesel truck. While towing a 34-foot fifth wheel trailer and traveling from [XXX] to [XXX] , the vehicle experienced a sudden and dangerous failure near [XXX] . The engine warning light appeared, the vehicle went into low power mode, and then completely shut down on the highway. This created a serious safety hazard, particularly while towing a large trailer at highway speeds. The vehicle was towed to a repair facility where it was determined that the high-pressure fuel pump had catastrophically failed. The pump had developed a significant crack and released metal debris throughout the entire fuel system. This required extensive repairs, including: - Replacement of the high-pressure fuel pump - Replacement of fuel lines - Full fuel system cleaning, including the fuel tank The total repair cost exceeded $14,000 USD (near $20,000 CAD). The mechanic indicated that this type of failure should not occur under normal operating conditions. Additionally, the Ford parts dealer advised that the failed fuel pump could be returned for credit, suggesting the failure may not be consistent with normal wear and tear. This failure occurred suddenly, without warning, and resulted in a complete loss of power while driving, which I believe represents a significant safety concern. I respectfully request that NHTSA investigate this issue as a potential safety-related defect involving high-pressure fuel pumps in diesel vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: January 31, 2026 · Filed: April 29, 2026

This past year I experienced catastrophic failure with my Bosch, CP4 fuel pump in my 2017 Ford F250 with a 6.7 L diesel. Recalls have been published by Ford, but not beyond a 2018 vehicle. After seeing metal fragments in my fuel water separator, I was forced to flush my entire fuel system, replace the CP4 fuel pump with a CDR high pressure pump (replacement), flush the entire fuel rail system and replace my fuel injectors. This repair cost me approximately $13,000. I find it difficult to understand why my 2017 vehicle was not included in the recall when it had the defective item as the later models had. The truck has 129,000 miles on it currently. Certainly, these are not excessive miles given the year of the vehicle. I would like to know what can be done for older models(the Bosch CP4 fuel pump goes all the way back to 2011). Thank you for your consideration and attention to this

Incident: March 5, 2026 · Filed: April 5, 2026

No less than 6 occasions now I have experienced extreme shaking (death wobble) even after Ford replaced the steering damper. I'm done with the vehicle and will take it in again for this issue.

Incident: March 15, 2026 · Filed: March 16, 2026

The contact owns a 2017 Ford F-250. The contact stated that while driving approximately 70-75 MPH, the vehicle drove over a bump in the roadway, and the front end of the vehicle started bouncing. The contact pulled over to the side of the road and then continued driving 45 MPH with no further issues. The dealer and the manufacturer were not contacted. The vehicle was not yet diagnosed or repaired. The failure mileage was approximately 68,000.

Incident: March 1, 2026 · Filed: March 2, 2026

2 different issues- 1st issue was Ford factory fuel filter leaked at a seam. Resulting in fuel loss all over engine! 2nd issue is fuel filter inlet line retaining clip comes unclipped on its own resulting in fuel loss all over the engine. Both incidents happened during long distance travel which also resulted in several gallons of fuel drenching whole undercarriage of vehicle.

Incident: November 1, 2025 · Filed: February 21, 2026

We get a power reduced code and the truck shuts down while driving. We have to pull over and put it in park and restart it. When we are on the freeway we can’t get over we put it in neutral and turn off the truck and restart it. It is very scary and dangerous! This has been happening since June of 2025.

Incident: February 19, 2026 · Filed: February 20, 2026

The contact owned a 2017 Ford F-250. The contact stated while driving 22 MPH and attempting to depress the brake pedal, the brake pedal was firm and difficult to depress. The brake pedal was depressed with both feet and the vehicle started slowing down. There was no warning light illuminated. After coming to a complete stop, the contact saw smoke coming from the grill underneath the windshield wipers and the lower windshield. The contact exited the vehicle and there was fire coming from the engine compartment and entering the cabin of the vehicle. The contact exited the vehicle, ran to the neighbor’s house and grabbed the garden hose and started spraying water on the hood; however, smoke and the fire increased and the fire was too hot for the house to put out the flames. The contact called 9-1-1 for assistance and the Fire Department arrived on the scene and extinguished the Fire. The Police showed up on scene to direct traffic. There was no injuries sustained. A Police Report was filed, but the report number was not provided. The vehicle was towed to the residence. The vehicle was destroyed. The manufacturer was informed of the failure and opened a case and provided the contact with the case number. The failure mileage was approximately 190,000.

Incident: February 13, 2024 · Filed: February 18, 2026

This issue with the truck has been going on since last year can be driving down the highway at a speed of 55 to 70 mph depending on the speed limit and the truck will start jerking and bucking to the point where it will almost sling you through the windshield and the reduced engine power will come on and you have no power at all taking it to the Ford dealership to get the powertrain control module reprogrammed I was informed that would fix the issue it did not there was a recall on the cp4 high pressure fuel pump that was manufactured by Bosch i have one of those fuel pumps in the ford company said 2017 f250 super duty diesel wasn't apart of the recall why did they all of a sudden do a recall to have the power train control module programmed on my 2017 Ford f250 super duty diesel that is the same thing that is called for in the recall of the high pressure cp4 fuel pump on other models this is becoming an issue because i have the exact same fuel pump made by Bosch and the same symptoms are happening as to the recall of the fuel pump in other year models I took my truck to the dealership to have it reprogrammed and it is still doing the same thing the day that I took it over there and they do nothing about it this could cause someone's life to be on the line when driving this particular year make and model and they do not want to recognize that it's coming from the cp4 high pressure fuel pump

Incident: January 30, 2026 · Filed: February 10, 2026

2017 F250 99k miles . got off the interstate and went to turn and the steering wheel immediately came loose. I had to press down while turning. I brought it to a repair shop and it was stated that it looked as if was glued and the locknut was never tightened . This could have been catastrophic. I didn't bring it to the dealer because it would take three days to look at it.