NHTSA vehicle safety data

2005 Ford F-250 Recalls & Complaints

The 2005 Ford F-250 has 5 NHTSA recall campaigns and 144 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

Includes campaigns NHTSA files under the spelling "F250".

NHTSA recall and complaint data for the 2005 Ford F-250. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Ford F-250 owner complaints

Owners have filed 144 complaints with NHTSA about the 2005 Ford F-250, describing incidents dated January 1, 2004 to March 25, 2025.

Most-cited components

Engine 43 complaints
Steering 39 complaints
Suspension 37 complaints
Fuel/Propulsion System 19 complaints
Power Train 14 complaints
Electrical System 13 complaints

Of the 144 complaints on file, 3 report a crash and 3 a fire; across all 144 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11692282 · Filed October 9, 2025
Odometer Fraud. The contact owns a 2005 Ford F-250. The contact purchased the vehicle from a private seller on social media. The contact stated that the sellers advertisement indicated the odometer mileage was 96,000. The contact later purchased a new vehicle and decided to sell the existing…
ODI #11653078 · Filed April 6, 2025
Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting…
ODI #11636147 · Filed January 15, 2025
While driving at 65 Mph, towing a fifth wheel camper, encountered a mildly rough section of highway when entire front end began to wobble and shake violently. Slowed the vehicle, maintaining control. When going back up to speed, the same shaking occured again. Also noted a less violent shaking at 45…

Read all 144 complaints

Owner-reported

2005 Ford F-250 mileage at failure

119 of the 144 complaints on file for the 2005 Ford F-250 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Engine	Median 90,000 miles	Middle half 45,000–110,000 miles	Based on 35 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Ford F-250 in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA08-007: VIOLENT FRONT END OSCILLATION
Closed March 31, 2009
Preliminary Evaluation PE07-057: VIOLENT FRONT END OSCILLATION
Closed March 14, 2008

Open and recently closed NHTSA defect investigations

STEERING COLUMN MULTIFUNCTION SWITCH/FMVSS 108

NHTSA #11V352000 · Exterior Lighting — Tail Lights · NHTSA notice

Reported July 13, 2011 · FORD MOTOR COMPANY

Potentially affected: 26,715 vehicles

Ford campaign 11C18 · Owners notified August 15, 2011

Defect description

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Safety consequence

NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Notes

FORD'S SAFETY RECALL NO. 11C18.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 403/ANTI-STOW INTERLOCK/RICON

NHTSA #09V026000 · Equipment Adaptive/Mobility · NHTSA notice

Reported January 26, 2009 · COMM TRANS SULLY CORPORATION

Potentially affected: 108 vehicles

Owners notified February 15, 2009 · Vehicles built April 1, 2005 – September 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COMM TRANS IS RECALLING 108 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Safety consequence

A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Manufacturer remedy

COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

THRESHOLD WARNING SYSTEM/FMVSS 404/RICON

NHTSA #09V025000 · Equipment Adaptive/Mobility · NHTSA notice

Reported January 23, 2009 · COMM TRANS SULLY CORPORATION

Potentially affected: 111 vehicles

Owners notified February 15, 2009 · Vehicles built April 1, 2005 – October 30, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

COMM TRANS IS RECALLING 111 MY 2005-2008 FORD E250 AND E350 VANS BUILT ON FORD CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Safety consequence

THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Manufacturer remedy

COMM TRANS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COMM TRANS AT 901-726-9394.

Notes

WHEEL RIMS - BRAKE LINE WEAR

NHTSA #06E087000 · Service Brakes, Air · NHTSA notice

Reported October 17, 2006 · HARSCO TRACK TECHNOLOGIES

Potentially affected: 450 vehicles

Owners notified September 15, 2006

Defect description

CERTAIN HARSCO WHEEL MODIFICATION GROUPS CONTAINING ACCURIDE STEEL RIMS, P/NOS. 203237 AND 203738; ACCURIDE ALUMINUM RIMS, P/N 203712; AND GKN STEEL RIMS, P/N 203688, SOLD AS MODIFICATION EQUIPMENT FOR CERTAIN 2005-2007 FORD F-250/F-350 4X4 PICKUP TRUCKS TO MODIFY TRACK WIDTH OF FRONT AND REAR AXLES. THE RIMS PROVIDED IN THESE WHEEL MODIFICATION GROUPS WEAR THROUGH THE OEM BRAKE LINES.

Safety consequence

BRAKE FAILURE CAN OCCUR, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

HARSCO WILL NOTIFY OWNERS AND PROVIDE A REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS FREE OF CHARGE. THE RECALL BEGAN IN SEPTEMBER 2006. OWNERS MAY CONTACT HARSCO AT 507-235-7112.

Notes

HARSCO RECALL NO. #06-006.THIS RECALL ONLY PERTAINS TO MODIFICATION KITS MANUFACTURED BY HARSCO AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON FORD F-250 AND F-350 4X4 PICKUP TRUCKS MANUFACTURED BY THE FORD MOTOR COMPANY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2005 Ford F-250. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

144 owner complaints have been filed with NHTSA for the 2005 Ford F-250.

Electrical System

ODI #11692282

Incident: January 29, 2025 · Filed: October 9, 2025

Odometer Fraud. The contact owns a 2005 Ford F-250. The contact purchased the vehicle from a private seller on social media. The contact stated that the sellers advertisement indicated the odometer mileage was 96,000. The contact later purchased a new vehicle and decided to sell the existing vehicle. The existing vehicle was posted on social media for sale. A potential buyer noticed the vehicle and obtained a Carfax report. The potential buyer then sent a copy of the Carfax report to the contact. The Carfax report indicated that the odometer was reported at 303,000 in 2023. The contact then contacted the seller and informed the seller of the discrepancy. The contact was informed that the odometer had been swapped prior to the sale. The contact stated that seller then deleted the advertisement from social media and rejected all further communications with the contact.

Power Train; Electrical System; Engine

ODI #11653078

Incident: March 25, 2025 · Filed: April 6, 2025

Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because I'm having this issue

Steering; Suspension

ODI #11636147

Incident: September 27, 2024 · Filed: January 15, 2025

While driving at 65 Mph, towing a fifth wheel camper, encountered a mildly rough section of highway when entire front end began to wobble and shake violently. Slowed the vehicle, maintaining control. When going back up to speed, the same shaking occured again. Also noted a less violent shaking at 45 mph. Took vehicle to have new tires rebalanced but did not change condition much. Inspected front end components. Currently replacing steering damper and shocks in hopes of correcting issue. All other components new or nearly new (3 years) with no issues. Vehicle and components can be inspected, and all replaced parts will be kept for inspection if required. Safety of my vehicle and others on busy highway could have been compromised had I not slowed and maintained control. The problem is being dealt with by me, as I do most maintenance on vehicle. The vehicle has not been seen or inspected by others except by tire mechanic who noted no obvious issues but did re-balance all tires. There was NO advance warning of a failure or compromise.

Engine

ODI #11619962

Incident: August 15, 2024 · Filed: October 15, 2024

The contact owns a 2005 Ford F-250. The contact stated while driving at an undisclosed speed, the contact heard a loud rumbling noise that sounded like rocks in the engine. In addition, the contact stated that when the vehicle was parked and the engine was turned off, the vehicle was started, however, the vehicle did not start. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that her husband was an independent mechanic and had recently replaced several unknown parts, however the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was 246,808.

Steering; Power Train; Electrical System

ODI #11606568

Incident: August 3, 2024 · Filed: August 5, 2024

Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road

Steering; Electrical System; Structure

ODI #11582251

Incident: April 10, 2024 · Filed: April 10, 2024

The back bed rails rot/rust very quickly and trying to buy new beds run 4500$ along with o2 sensors ir intake sensors go out of blue no reasoning let alone the power steering lines rusting very very quickly

Tires

ODI #11543599

Incident: September 9, 2023 · Filed: September 9, 2023

The tire is a Cooper (Discoverer/Rigged Trek) 35x12.50R20LT. The tire is unreadable as it ripped off the bead. While driving, a sudden pop suddenly occurred and smoke began to appear. I pulled over and realized the entire tire popped/blew up. No accident, it was at 35mph approximately. The vehicle has not been inspected yet as I am typing this while waiting for a tow truck.

Steering; Suspension; Wheels

ODI #11487504

Incident: September 16, 2022 · Filed: October 2, 2022

In 2014, I got the “Ford death wobble” in the right front. VERY scary and dangerous. Trying to quickly slow down to stop it in traffic is almost as dangerous as the wobble itself. You have very little to no control with the steering when it happens. I had to repair the problem out of pocket because Ford won’t do anything about it. Now, two weeks ago, I had the same death wobble happen at 70 mph on the left front. So frightening. My passengers thought we had a blowout and we’re about to crash. I successfully slowed it down but this problem is a road hazard to me and everyone else on the road. So now, once again, it’s on me to shell out to fix a problem that should have been a recall a long time ago but Ford won’t step up and do the right thing. Please give us some relief here.

Steering; Suspension

ODI #11486705

Incident: September 24, 2022 · Filed: September 27, 2022

towing a trailer, traveling at 70 mph, I hit a pothole and vehicle violently shook. The episode lasted for approx 30 seconds. It was very Difficult to maintain control and I almost ran off the road. It happened several times before I took it for repairs. The stabilizer bar was replaced, however the violent shaking has still continued.

Steering; Suspension

ODI #11481545

Incident: August 25, 2022 · Filed: August 27, 2022

Front end suspension shimmy> My granddaughter and I were driving at 60mpa and hit a bump and could not control shaking of truck until pulling over to stop. This happened without warning. Had to drive back roads to get home.

Other Ford F-250 model years

Check your 2005 Ford F-250 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford F-250 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN