2016 Ford E-450 Recalls & Complaints

Incident: December 26, 2025 · Filed: December 29, 2025

The contact rented a 2016 U-Haul E450. The contact stated that while in the parking lot and placing the vehicle in drive, the contact tapped on the accelerator pedal, then when the brakes were applied and the vehicle suddenly accelerated. The contact removed her foot from the brake, and it continued to accelerate and crashed into a parked U-Haul truck. There were no reported injuries, fire, airbag deployment, or police report filed. It was unknown if there were any warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The contact spoke with the rental company, who reversed the vehicle without incident. The contact stated that the rental employee was not operating the vehicle the same way when the failure occurred. The failure mileage was approximately 141,000. The insurance company was contacted, who would potentially obtain the black box.

Incident: June 21, 2021 · Filed: July 2, 2021

Driver’s side extended towing mirror (Ford e450 Class C RV) began closing back toward door while on interstate at normal speed. I rolled down window to push it back out, and the arm extension and mirror fell down out of the “elbow joint” basically hanging by the electrical cord. Was able to exit interstate. Could not reinstall it. Had to tuck into cab door and wrap a pants belt around the arm and through the hand grip inside the door in order to get home. Dealer has ordered replacement mirror ETA 4 weeks or longer

Incident: May 6, 2021 · Filed: May 6, 2021

TL* THE CONTACT OWNS A 2016 FORD E-450 TRAILERED TO A 2016 COACHMEN LEPRECHAUN TRAVEL TRAILER. THE CONTACT STATED THAT THE FORD CHASSIS WAS UNABLE TO HANDLE THE WEIGHT OF THE RV. THE CONTACT STATED THAT THE SUSPENSION WAS NOT STURDY ENOUGH FOR THE WEIGHT OF THE RV. THE CONTACT SUBMITTED AN ONLINE COMPLAINT TO NOTIFY THE MANUFACTURER OF THE FAILURE. THE FAILURE MILEAGE WAS 10,600.

Incident: September 6, 2019 · Filed: September 29, 2019

I PURCHASED THIS THOR MOTOR HOME FROM A DEALER ON 09/06/2019, USED OUR FIRST TRIP 260 MILES BOTH WAYS I HAVE FOUND A VERY DIFFICULT TIME ON KEEPING UNIT ON ROAD PROPERLY CONSTANTLY DRIFTING AND VERY FATIGUED IN DRIVING. AT CAMP SIGHT AN IDENTICAL 31W THOR 2018 OWNER STATED HE HAD SAME PROBLEM AN NEIGHBORS STATED THAT STABILIZER NEEDS TO BE REPLACED WITH A SAFETPLUS 31-140 UNIT AND NOW NO PROBLEM. HELP!!! I WOULD CONSIDER THIS TO BE A SAFETY ITEM THAT NEEDS CORRECTION. HIGHWAY 65MPH.

Incident: October 18, 2018 · Filed: November 1, 2018

TL* THE CONTACT OWNS A 2016 FORD E-450. THE CONTACT STATED THAT WHILE IN REVERSE, THE VEHICLE ACCELERATED WITHOUT ANY WARNING CRASHING INTO A MOBILE HOME. THE CONTACT STATED NO INJURIES WERE SUSTAINED. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED AS A RESULT OF THE FAILURE THE VEHICLE HAS FAILED TO SHIFT FROM THE REVERSE POSITION. THE DEALER KAYSER AUTOMOTIVE GROUP (2303 WEST BELTLINE HIGHWAY, MADISON, WI 53713 (608)-271-6000) WAS CONTACTED FOR A DIAGNOSTIC TEST TO BE PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WOULD NEED TO BE DIAGNOSED AT A DEALER. THE FAILURE MILEAGE WAS 15,500.

Incident: September 1, 2017 · Filed: February 22, 2018

NHTSA RECALL 17V550: METRO WORLDWIDE BUS VEHICLE EXCEEDS GROSS VEHICLE WEIGHT RATING (GVWR) WHEN FULLY LOADED. THE MANUFACTURER'S PROPOSED REMEDY IS TO REMOVE SEATS UNTIL THE GVWR IS IN COMPLIANCE. THE MANUFACTURER OFFERED $1,500 PER SEAT REMOVED AS COMPENSATION. BUT REMOVING SEATS DRAMATICALLY REDUCES THE EFFECTIVENESS OF THE BUS FOR ITS INTENDED PURPOSE. IF WE KNEW THAT THE MANUFACTURER COULDN'T FOLLOW THROUGH ON THEIR PROMISE TO PROVIDE VEHICLES MEETING REQUIRED SPECIFICATION, METRO WORLDWIDE WOULD NOT HAVE BEEN CONSIDERED. WE BELIEVE THAT THE MANUFACTURER WAS NEGLIGENT AND IN VIOLATION OF THE LAW FOR IMPROPERLY BUILDING THE BUSES. THE DEALER, HOGLUND BUS, WAS ALSO NEGLIGENT FOR SELLING THE BUSES TO US THAT DID NOT COMPLY WITH NHTSA SAFETY STANDARDS. BOTH THE MANUFACTURER AND THE DEALER SHOULD BEAR THE RESPONSIBILITY OF REPLACING THE BUSES AT NO CHARGE. WE BELIEVE FULL BUS REPLACEMENT IS FAIR BECAUSE IF WE WANTED 16, 18 OR 20 PASSENGER BUSES, WE COULD HAVE GOTTEN THEM CHEAPER FROM OTHER MANUFACTURERS THAN THE 22 PASSENGER BUSES METRO WORLDWIDE PROMISED.

Incident: September 1, 2017 · Filed: February 22, 2018

NHTSA RECALL 17V550: METRO WORLDWIDE BUS VEHICLE EXCEEDS GROSS VEHICLE WEIGHT RATING (GVWR) WHEN FULLY LOADED. THE MANUFACTURER'S PROPOSED REMEDY IS TO REMOVE SEATS UNTIL THE GVWR IS IN COMPLIANCE. THE MANUFACTURER OFFERED $1,500 PER SEAT REMOVED AS COMPENSATION. BUT REMOVING SEATS DRAMATICALLY REDUCES THE EFFECTIVENESS OF THE BUS FOR ITS INTENDED PURPOSE. IF WE KNEW THAT THE MANUFACTURER COULDN'T FOLLOW THROUGH ON THEIR PROMISE TO PROVIDE VEHICLES MEETING REQUIRED SPECIFICATION, METRO WORLDWIDE WOULD NOT HAVE BEEN CONSIDERED. WE BELIEVE THAT THE MANUFACTURER WAS NEGLIGENT AND IN VIOLATION OF THE LAW FOR IMPROPERLY BUILDING THE BUSES. THE DEALER, HOGLUND BUS, WAS ALSO NEGLIGENT FOR SELLING THE BUSES TO US THAT DID NOT COMPLY WITH NHTSA SAFETY STANDARDS. BOTH THE MANUFACTURER AND THE DEALER SHOULD BEAR THE RESPONSIBILITY OF REPLACING THE BUSES AT NO CHARGE. WE BELIEVE FULL BUS REPLACEMENT IS FAIR BECAUSE IF WE WANTED 16, 18 OR 20 PASSENGER BUSES, WE COULD HAVE GOTTEN THEM CHEAPER FROM OTHER MANUFACTURERS THAN THE 22 PASSENGER BUSES METRO WORLDWIDE PROMISED.

Incident: September 22, 2017 · Filed: February 21, 2018

VEHICLE EXCEEDS GROSS VEHICLE WEIGHT RATING WHEN FULLY LOADED. METRO WORLDWIDE BUS NHTSA RECALL 17V THE MANUFACTURES REMEDY GIVEN TO US IS TO REMOVE 6 SEATS FROM A 20 PASSENGER BUS. OR PAY AN ESTIMATE COST TO US OF 17 THOUSAND DOLLARS TO REPLACE THE BUS. THE BUS CANNOT BE USED FOR THE PURPOSE IT WAS PURCHASED FOR. WE FEEL THE MANUFACTURE WAS NEGLIGENT FOR IMPROPERLY BUILDING THE BUS AND THE DEALER HOGLUND BUS WAS NEGLIGENT FOR SELLING THE BUS THAT DONE NOT MEET NHTSA SAFTY STANDARDS. WE FEEL THAT THEY SHOULD BARE THE RESPONDIBILTY OF REPLACING THE BUS AT NO CHARGE

Incident: September 22, 2017 · Filed: February 21, 2018

VEHICLE EXCEEDS GROSS VEHICLE WEIGHT RATING WHEN FULLY LOADED. METROWORLDWIDE BUS NHTSA RECALL 17V 550 THE MANUFACTURES REMEDY GIVEN TO US IS TO REMOVE 6 SEATS FROM A 20 PASSENGER BUS. OR PAY AN ESTIMATE COST TO US OF 17 THOUSAND DOLLARS TO REPLACE THE BUS. THE BUS CANNOT BE USE FOR THE PURPOSE IT WAS PURCHASED FOR. WE FEEL THE MANUFACTURE WAS NEGLIGENT FOR IMPROPERLY BUILDING THE BUS AND THE DEALER HOGLUND BUS WAS NEGLIGENT FOR SELLING THE BUS TO US AND THAT THEY SHOULD BARE THE RESPONSIBILTIY OF REPLACING THE BUS AT NO CHARGE.

Incident: November 4, 2017 · Filed: November 6, 2017

PROBLEM IS WITH WINNEBAGO ASPECT MOTORHOME ATTACHED TO THE E 450. THE AUTOMATIC TRANSFER SWITCH ALMOST CAUGHT FIRE(SMOKED) LAST WEEK. THIS PROBLEM WAS COVERED BY NHTSA 16V-598. I TOOK IT TO THE WINNEBAGO FACTORY IN SEPTEMBER OF 2016 TO GET IT RETORQUED. THIS COULD HAVE CAUSED A FIRE WHILE WE WERE SLEEPING. IT WAS HOOKED UP TO CAMPGROUND ELECTRIC POWER WHEN IT OCCURRED AND WAS PROTECTED BY A SURGE SUPPRESSOR.