NHTSA vehicle safety data
2009 Ford E-450 Recalls & Complaints
The 2009 Ford E-450 has 10 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.
NHTSA recall and complaint data for the 2009 Ford E-450. Recall data is refreshed daily from NHTSA.
2009 Ford E-450 owner complaints
Owners have filed 2 complaints with NHTSA about the 2009 Ford E-450, describing incidents dated July 24, 2016 to June 3, 2021.
Most-cited components
- Air Bags 1 complaint
- Engine 1 complaint
Of the 2 complaints on file, 1 reports a crash; across both complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).
Newest complaints
ODI #11421467 · Filed
Air bags failed to deploy in a off-center passenger side frontal collision. As a result, driver's hands remained on the wheel through collision, causing the L upper extremity to suddenly rotate approximately 210 degrees to the right causing a shoulder injury (severity at this point is uncertain)…
ODI #10892917 · Filed
PLASTIC PART ATTACHED TO VALVE COVER INSIDE ENGINE BREAKS OFF CAUSING SUDDEN ENGINE FAILURE.
Back Up Camera Display Image may be Reversed
NHTSA #19V401000 · Equipment · NHTSA notice
Reported May 29, 2019 · VCI Emergency Vehicle Specialists
Potentially affected: 22 vehicles
Owners notified May 9, 2019 · Vehicles built May 1, 2017 – December 13, 2018 (per NHTSA)
Defect description
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Safety consequence
The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Manufacturer remedy
VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Wheelchair Lift Platform Cracking
NHTSA #15V112000 · Equipment Adaptive/Mobility · NHTSA notice
Reported February 25, 2015 · Farber Specialty Vehicles
Potentially affected: 117 vehicles
Manufacturer campaign 14E-041 · Owners notified March 24, 2015 · Vehicles built January 15, 2007 – July 24, 2013 (per NHTSA)
Defect description
Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Safety consequence
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Manufacturer remedy
Farber will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on March 24, 2015. Owners may contact Farber customer service at 1-800-331-3188, or Ricon customer service at 1-800-322-2884. Farber's number for this recall is 14E-041.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Ricon Wheelchair Lift - Platform Cracking
NHTSA #14V595000 · Equipment Adaptive/Mobility · NHTSA notice
Reported September 24, 2014 · Elkhart Coach
Potentially affected: 437 vehicles
Owners notified October 1, 2014 · Vehicles built January 1, 2006 – May 1, 2014 (per NHTSA)
Defect description
Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Safety consequence
If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Manufacturer remedy
Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Ricon customer service at 1-800-322-2884. Owners may also contact Elkhart customer service at 1-574-264-5179. This recall has been superseded by campaign 15V-768.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Wheelchair Lift Roll Stop Latches
NHTSA #12V584000 · Equipment · NHTSA notice
Reported December 12, 2012 · Creative Bus Sales, Inc.
Potentially affected: 227 vehicles
Owners notified December 23, 2012 · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.
Safety consequence
A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.
Manufacturer remedy
Braun is conducting this recall on behalf of Creative Bus Sales. Braun will notify owners, and dealers will repair the vehicles free of charge. The recall began on November 23, 2012. Owners may contact Creative Bus at 1-888-633-8380 or Braun at 1-800-488-0359.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
AFTERMARKET ROUSH PROPANE CONVERSION KIT/FUEL LEAK
NHTSA #11E033000 · Fuel System, Other — Fuel Injection System · NHTSA notice
Reported August 31, 2011 · ROUSH INDUSTRIES, INC.
Potentially affected: 286 vehicles
Owners notified September 29, 2011
Defect description
ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS USED FOR INSTALLATION ON THE FOLLOWING VEHICLES: MODEL YEAR 2007 AND 2008 FORD E-350 (DUEL REAR WHEEL), MY 2009-2011 FORD E- 150, E-250, AND E-350, AND MY 2009-2011 FORD E-450 CUTAWAYS. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD RESULT IN LEAKAGE OF PROPANE AUTOGAS. THE PART NUMBERS OF THE AFFECTED KITS ARE: P07C2-176KIT-AB, P10C2-RCOMMKIT-AB, P10C2-R150KIT-AA, P10C2-R150KIT-AC, P10C2-R350KIT-AC, P11C2-R150KIT-AA, P11C2-R150KIT-AB, P11C2-R350KIT-AA, P11C2-R350KIT-AB, P10-SO-RKIT-BA, PBC2-RKIT158-AB, PBC2-RKIT176-AB, AND PBC2-RKITMB-AC.
Safety consequence
A GAS LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Manufacturer remedy
ROUSH WILL NOTIFY OWNERS OF THE VEHICLES OF WHICH THE KITS WERE INSTALLED ON IN ORDER TO ARRANGE FOR FREE REPLACEMENT OF THE INJECTOR RETENTION CLIPS. THE SAFETY RECALL BEGAN ON SEPTEMBER 29, 2011. OWNERS MAY CONTACT ROUSH AT 1-800-59-ROUCH (1-800-597-6874.
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
WHEELCHAIR LIFTS/INTERLOCK BELT
NHTSA #10V128000 · Equipment Adaptive/Mobility · NHTSA notice
Reported April 2, 2010 · ELKHART COACH
Potentially affected: 41 vehicles
Owners notified July 27, 2010
Defect description
ELKHART COACH HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN TRANSIT BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.
Safety consequence
THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.
Manufacturer remedy
ELKHART COACH IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800-322-2884, EMAILING AT [email protected].
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
WHEELCHAIR LIFTS/UP FUNCTION SWITCH
NHTSA #10V130000 · Equipment Adaptive/Mobility · NHTSA notice
Reported April 2, 2010 · ELKHART COACH
Potentially affected: 200 vehicles
Owners notified July 27, 2010
Defect description
ELKHART COACH HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN TRANSIT BUSES EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.
Safety consequence
WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.
Manufacturer remedy
ELKHART COACH WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. CURRENTLY RICON IS DEVELOPING A SOFTWARE SOLUTION AND IS NOT AVAILABLE. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800- 322-2884, EMAILING AT [email protected].
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
AIRV CEILING ASSEMBLIES/HEATER ELEMENT
NHTSA #09V434000 · Equipment — Appliance — Air Conditioner · NHTSA notice
Reported November 13, 2009 · ENG MOBILE SYSTEM, INC
Potentially affected: 53 vehicles
Owners notified December 31, 2009 · Vehicles built May 1, 2007 – August 31, 2009 (per NHTSA)
Defect description
E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
Safety consequence
THIS DEFECT COULD RESULT IN A FIRE.
Manufacturer remedy
E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.
Notes
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
FRAME RAIL FUEL TANK GUARD BRACKETS
NHTSA #09V231000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice
Reported June 23, 2009 · FORD MOTOR COMPANY
Potentially affected: 65 vehicles
Ford campaign 09C08 · Owners notified June 30, 2009 · Vehicles built April 29, 2008 – January 20, 2009 (per NHTSA)
Defect description
FORD IS RECALLING 65 MY 2008-2009 E-350 AND MY 2009 E450 CUTAWAY VEHICLES EQUIPPED WITH SCHOOL BUS PREP PACKAGES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES MAY NOT HAVE BEEN ASSEMBLED WITH THE FUEL TANK PROTECTION BRACKETS THAT ARE REQUIRED FOR SCHOOL BUS APPLICATIONS.
Safety consequence
IN CERTAIN TYPES OF VERY SEVERE CRASHES, THE FUEL TANK MAY BE DAMAGED AND RESULT IN A LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Manufacturer remedy
DEALERS WILL INSPECT FOR PROPER FUEL TANK PROTECTION BRACKET INSTALLATION AND INSTALL BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH THE INTERNET AT WWW.OWNERCONNECTION.COM.
Notes
FORD 09C08.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
FUEL TANK PROTECTION BRACKET LOCATION
NHTSA #09V112000 · Fuel System, Gasoline — Storage — Tank Assembly — Mounting · NHTSA notice
Reported April 7, 2009 · FORD MOTOR COMPANY
Potentially affected: 429 vehicles
Ford campaign 09S08 · Owners notified April 14, 2009 · Vehicles built April 22, 2008 – March 2, 2009 (per NHTSA)
Defect description
FORD MOTOR COMPANY IS RECALLING 429 MY 2009 FORD ECONOLINE E-350 AND E-450 CUTAWAY SCHOOL BUS PREP PACKAGE VEHICLES MANUFACTURED FROM APRIL 22, 2008 THROUGH MARCH 2, 2009, TO REPOSITION THE UPPER FUEL TANK PROTECTION BRACKET ON THE FRAME RAIL.
Safety consequence
IN CERTAIN TYPES OF VERY SEVERE CRASHES, THE FUEL TANK MAY BE DAMAGED AND RESULT IN A LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Manufacturer remedy
FORD WILL NOTIFY OWNERS AND DEALERS WILL REPOSITION THE UPPER FUEL TANK PROTECTION BRACKET FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 14, 2009. OWNERS MAY CONTACT FORD TOLL-FREE AT 1-866-436-7332 OR CONTACT A LOCAL FORD OR LINCOLN/MERCURY DEALER FOR MORE INFORMATION.
Notes
FORD'S RECALL NO. 09S08.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
Other Ford E-450 model years
Check your 2009 Ford E-450 VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford E-450 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Ford VIN