NHTSA vehicle safety data

2015 Ford E-450 Recalls & Complaints

The 2015 Ford E-450 has 1 NHTSA recall campaign and 6 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Ford dealer.

NHTSA recall and complaint data for the 2015 Ford E-450. Recall data is refreshed daily from NHTSA.

2015 Ford E-450 owner complaints

Owners have filed 6 complaints with NHTSA about the 2015 Ford E-450, describing incidents dated September 10, 2015 to October 29, 2021.

Most-cited components

Power Train 3 complaints
Wheels 2 complaints
Engine 1 complaint
Fuel/Propulsion System 1 complaint
Suspension 1 complaint

Newest complaints

ODI #11438925 · Filed November 1, 2021
The contact rented a 2015 Ford E-450. The contact stated that while driving, the vehicle was shaking in the rear. The contact had to maintain an approximate speed of 40 MPH to control the vehicle. The fuel warning light was illuminated. The local dealer was not contacted. The vehicle was not…
ODI #11373481 · Filed November 6, 2020
THE TIRE THREAD SHREDDED OFF OF BOTH SIDES OF THE WHEEL WHILE DRIVING, DAMAGING MUD FLAPS, ETC. 2015 JAYCO GREYHAWK RV (FORD 450 CHASIS). MILEAGE WAS ONLY 25000 MILES. OTHER TIRES APPEAR TO ALREAY DISPLAY SOFT SPOTS AND CRACKING - ESPECIALLY NEAR THE THREAD, VEHICLE IS GARAGE WHEN NOT IN USE.
ODI #11102982 · Filed June 21, 2018
THIS IS A SCHOOL BUS. WHEN STOPPED AT A STOP SIGN THE SCHOOL BUS WOULD NOT ENGAGE IN ANY GEAR, FORWARD OR REVERSE. THE SCHOOL BUS HAD TO BE TOWED TO THE FORD DEALERSHIP WHERE THEY FOUND THAT THE COAST CLUTCH DRUM, RETURN SPRING, PISTON AND ONE WAY CLUTCH NEEDED TO BE REPLACED. THIS IS THE 4TH SCHOOL…

Read all 6 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2015 Ford E-450 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE18-010: Internal transmission failure
Closed July 16, 2019
- Recall 19V-432

Open and recently closed NHTSA defect investigations

Seat Back may not Stay Upright

NHTSA #19V313000 · Seats · NHTSA notice

Reported April 18, 2019 · Mobility Transportation Services

Potentially affected: 2,080 vehicles

Owners notified May 19, 2020 · Vehicles built October 1, 2014 – November 1, 2018 (per NHTSA)

Defect description

Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.

Safety consequence

In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

Manufacturer remedy

MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

try.vin has no NCAP crash-test rating on file for the 2015 Ford E-450. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

6 owner complaints have been filed with NHTSA for the 2015 Ford E-450.

Suspension; Wheels

ODI #11438925

Incident: October 29, 2021 · Filed: November 1, 2021

The contact rented a 2015 Ford E-450. The contact stated that while driving, the vehicle was shaking in the rear. The contact had to maintain an approximate speed of 40 MPH to control the vehicle. The fuel warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact stated that the rear wheels were cracked. The contact was concerned about driving the vehicle. The failure mileage was approximately 80,329.

Wheels

ODI #11373481

Incident: October 28, 2020 · Filed: November 6, 2020

THE TIRE THREAD SHREDDED OFF OF BOTH SIDES OF THE WHEEL WHILE DRIVING, DAMAGING MUD FLAPS, ETC. 2015 JAYCO GREYHAWK RV (FORD 450 CHASIS). MILEAGE WAS ONLY 25000 MILES. OTHER TIRES APPEAR TO ALREAY DISPLAY SOFT SPOTS AND CRACKING - ESPECIALLY NEAR THE THREAD, VEHICLE IS GARAGE WHEN NOT IN USE.

Power Train

ODI #11102982

Incident: January 12, 2018 · Filed: June 21, 2018

THIS IS A SCHOOL BUS. WHEN STOPPED AT A STOP SIGN THE SCHOOL BUS WOULD NOT ENGAGE IN ANY GEAR, FORWARD OR REVERSE. THE SCHOOL BUS HAD TO BE TOWED TO THE FORD DEALERSHIP WHERE THEY FOUND THAT THE COAST CLUTCH DRUM, RETURN SPRING, PISTON AND ONE WAY CLUTCH NEEDED TO BE REPLACED. THIS IS THE 4TH SCHOOL BUS WE HAVE HAD THIS ISSUE WITH.

Power Train

ODI #11072830

Incident: April 1, 2016 · Filed: February 14, 2018

TL* THE CONTACT OWNS A 2015 FORD E-350. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION WAS CRACKED AND THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 65,000.

Power Train

ODI #11072827

Incident: December 12, 2016 · Filed: February 14, 2018

TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION HAD CRACKED AND THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 100,000.

Engine; Fuel/Propulsion System

ODI #10764471

Incident: September 10, 2015 · Filed: September 17, 2015

TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FUEL MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT STATED THAT SHORTLY AFTER THE REPAIR, THE VEHICLE JERKED AND FAILED TO START AS THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS UNABLE TO BE DIAGNOSED OR REPAIRED THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,020.

Other Ford E-450 model years

Check your 2015 Ford E-450 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Ford E-450 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Ford VIN