2005 Ford Cvpi Recalls & Complaints

Incident: March 1, 2014 · Filed: April 16, 2014

I WAS DRIVING FOR APPROX. 5 MIN AND MY HEADLIGHTS JUST CUT OFF. I PULLED OVER TURNED THE LIGHT SWITCH ON AND OFF AND STILL NO HEAD LIGHTS. THE PARK LIGHTS WOULD WORK JUST FINE. I HAD TO DRIVE HOME USING MY BRIGHT LIGHTS. LUCKILY, NO ONE WAS WALKING BECAUSE I WOULD NOT HAVE BEEN ABLE TO SEE THEM AT ALL. I TOOK THE CAR IN TO THE FORD DEALERSHIP AND THEY SAID IT WAS THE LIGHT CONTROL MODULE THAT COST OVER $600 JUST FOR THE PART.

Incident: March 18, 2013 · Filed: March 19, 2013

LOW SPEED STEERING FAILURE. COULD NOT CONTROL STEERING AT LOW SPEED. - STEERING WHEEL RESISTED MOVEMENT TO CONTROL VEHICLE. VEHICLE IMMEDIATELY BROUGHT TO FORD DEALER AND FOUND THAT 5W1Z*3B676*AA STEERING SHAFT ASSEMBLY WORN CAUSING STEERING/CONTROL PROBLEM. ORIGINAL OWNER WITH FORD EXTRA CARE WARRANTY - REPAIR NOT COVERED AT $538.63. HISTORY OF STEERING FAILURES ON THESE VEHICLES - FORD SHOULD RECALL/REIMBURSE FOR REPAIRS. I SPOKE TO A FORD ESP REPRESENTATIVE AND WAS TOLD THAT NO MATTER HOW MANY FAILURES OCCUR, REGARDLESS OF ACCIDENT OR INJURY, FORD DOES NOT MONITOR NON-FORD WEBSITES FOR FREQUENCY OF FAILURES. IF THE FREQUENCY OF FAILURE, ACCIDENT, INJURY OR FATALITIES IS HIGH ENOUGH, THEY WILL ISSUE RECALL AND REIMBURSE COST OF REPAIRS MADE AT FORD DEALER. *TR

Incident: July 18, 2011 · Filed: September 26, 2011

I AM HAVING A PROBLEM WITH OUR 2005 CROWN VIC HEADLIGHTS GOING OUT WITHOUT WARNING WHILE DRIVING. WINDSHIELD WIPERS ONLY WORKS ON HIGH. *TR

Incident: June 7, 2011 · Filed: June 8, 2011

DRIVING VEHICLE...HEADLAMPS TURNED OFF ON THEIR OWN...PROBLEM TRACED TO LAMP CONTROL MODULE...PROBLEM WITH THIS PART HAS BEEN INVESTIGATED BY NHTSA PREVIOUSLY...FORD NEEDS TO BE HELD ACCOUNTABLE FOR FAILURES OF THIS PART.

Incident: October 29, 2010 · Filed: October 30, 2010

DRIVING A 2005 CROWN VICTORIA IN THE EARLY AM (IT WAS DARK) ON A CITY STREET WITHOUT STREET LIGHTS. THE HEADLIGHTS WENT OFF. STOPPED THE CAR IMMEDIATELY. TURNED LIGHTS OFF AND BACK ON. ALL LIGHTS EXCEPT THE HEADLIGHTS WORKED. EXPERIMENTED WITH THE LIGHT SWITCH AND TURN SIGNAL LEVER. DISCOVERED THE BRIGHTS WORKED WHEN PULLING THE LEVER (MANUAL OPERATION OF THE BRIGHTS). AFTER ABOUT THREE MINUTES THE HEADLIGHTS TURNED THEMSELVES BACK ON. TOOK THE CAR TO A FORD DEALERSHIP. TOLD THEM WHAT HAD HAPPENED. THEY REPORTED LATER IN THE DAY THAT NOTHING COULD BE FOUND THAT WAS WRONG. I GOOGLED THE PROBLEM AND WAS OVERWHELMED WITH HITS. WHEN I GOT THE CAR AFTER WORK I ASKED THE SERVICE MANAGER IF ANYONE ELSE HAD ENCOUNTERED THE SAME PROBLEM. AT FIRST HE WAS RELUCTANT BUT AFTER INFORMING HIM I HAD GOOGLED THE PROBLEM AND HAD DISCOVERED THAT IT HAD HAPPENED TO OTHERS. AT THAT POINT HE DID TELL ME THAT THEY HAD OTHER CUSTOMERS COMPLAINING OF THE SAME (OR SIMILAR) PROBLEM. TO CORRECT IT I WOULD HAVE TO REPLACE THE LCM (LIGHT CONTROL MODULE). WHICH COSTS $511.00 PLUS LABOR AND TAX. (I DID NOT DO IT AT THAT TIME) THIS IS A VERY SERIOUS PROBLEM. IF I HAD NOT BEEN AS CALM AS I WAS AN ACCIDENT COULD HAVE VERILY EASILY OCCURRED. THERE HAS BEEN NO RECALL ON THIS VEHICLE/PART. WHY NOT? *TR

Incident: May 13, 2009 · Filed: March 30, 2010

HEADLIGHT CONTROL MODULES ON FORD CROWN VICTORIA POLICE CARS. LIGHTS GO OUT WHILE DRIVING DOWN THE ROAD AT NIGHT. WE HAVE HAD APPROXIMATELY 15 OF THESE FAIL IN OUR AREA WHICH ONLY INVOLVES 4 POLICE AGENCIES. WE HAVE HAD 2 UNEXPLAINED FATALITIES IN FORD CROWN VICTORIA POLICE INTERCEPTORS WHICH OCCURRED AT NIGHT WHILE RUNNING LIGHTS AND SIRENS. THE LIGHTS GO OUT AND AN ENGINEER IN CANADA TOLD ME TO PUSH ON THE BOX LOCATED ABOVE THE GAS PEDAL WITH MY FOOT. WHILE DOING THIS THE LIGHTS CAME BACK ON. TAKE FOOT OFF THEY GO OUT. FORD WILL NOT RECONIZE THIS AS A PROBLEM AND WILL NOT WARRANTY THIS EVEN THOUGH THE CAR ONLY HAD 30000 MILES ON IT AND 3YRS 2 MONTHS OLD. COST US $690.00 FOR REPAIRS

Incident: March 9, 2010 · Filed: March 10, 2010

TL* THE CONTACT OWNS A 2005 FORD CVPI. SINCE PURCHASING THE VEHICLE THE CONTACT NOTICED THAT THE WHEELS ON THE VEHICLE HAD BEGUN TO SHOW SIGNS OF RUST. THE CONTACT CALLED THE DEALERSHIP REGARDING NHTSA RECALL #07V079000 COMPONENT: WHEELS AND WAS INFORMED THAT THE RECALL DID NOT APPLY TO HIS VEHICLES VIN NUMBER. THE VEHICLE HAD NOT BEEN DIAGNOSED BY THE DEALERSHIP AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 172000.

Incident: May 1, 2009 · Filed: January 29, 2010

LINGERING PROBLEM WITH 2005 FORD CROWN VICTORIA POLICE INTERCEPTOR WITH SUSPECTED CRACKED WHEELS. VEHICLE HAS ALL SYMPTOMOLOGY VEHICLE WAS MANUFACTURED FOR THE 2005 MY IN 08/2004. NHTSA CAMPAIGN ID NUMBER: 07V079000 . FORD REFUSES TO ADDRESS THE PROBLEM. *TR

Incident: October 5, 2009 · Filed: October 28, 2009

LEFT FRONT BRAKE LINE RUPTURED RESULTING IN NO POWER BRAKING ASSIST. *TR

Incident: April 14, 2009 · Filed: June 15, 2009

WAKEMED POLICE DEPARTMENT OWN SEVERAL CROWN VICTORIA POLICE INTERCEPTOR VEHICLES. TWO OF THE VEHICLES, MY 2005, HAVE DEVELOPED WORN AREAS (AND SUBSEQUENT HOLES) ON THE RIGHT FRONT BRAKE HOSE LEADING TO THE BRAKE CALIPER. THESE DEFECTS WERE DISCOVERED AFTER THE VEHICLES LOST POWER BRAKE ASSIST IN HEAVY TRAFFIC DURING PATROL OPERATIONS. THE OTHER THREE BRAKE LINES ON EACH VEHICLE SHOW NO EVIDENCE OF ANY SUCH WEAR. WHILE IT DOES NOT APPEAR THAT THERE ARE ANY COMPONENTS IN DIRECT CONTACT WITH THE BRAKE LINE, IT SEEMS AS IF THE LIKELY POINT OF CONTACT IS THE FRONT RIGHT LOWER CONTROL ARM. *TR