NHTSA vehicle safety data

2006 Dodge Ram 1500 Recalls, Ratings & Complaints

The 2006 Dodge Ram 1500 has 12 NHTSA recall campaigns and 792 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Dodge dealer.

NHTSA recall and complaint data for the 2006 Dodge Ram 1500, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Dodge Ram 1500 owner complaints

Owners have filed 792 complaints with NHTSA about the 2006 Dodge Ram 1500, describing incidents dated February 25, 2006 to February 18, 2026.

Most-cited components

Air Bags 193 complaints
Exterior Lighting 139 complaints
Electrical System 125 complaints
Suspension 106 complaints
Power Train 100 complaints
Steering 84 complaints

Of the 792 complaints on file, 43 report a crash and 8 a fire; across all 792 complaints, owners report 42 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11718823 · Filed February 18, 2026
The contact owns a 2006 Dodge Ram 1500. The contact received notification of NHTSA Campaign Number: 16V352000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time…
ODI #11716319 · Filed February 6, 2026
The contact owns a 2006 Dodge Ram 1500. The contact stated that while the vehicle was parked, oil stains were found on the ground underneath the vehicle. The contact checked underneath the vehicle and became aware that the rear axle pinion nut was loose. The axle pinion nut was tightened. The…
ODI #11695312 · Filed October 23, 2025
The pinion nut loosen up causing the pinion to lock down into the ring gear and locked the rear axle housing, ejecting the drive shaft.

Read all 792 complaints

Owner-reported

2006 Dodge Ram 1500 mileage at failure

565 of the 792 complaints on file for the 2006 Dodge Ram 1500 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Air Bags	Median 80,000 miles	Middle half 45,000–130,000 miles	Based on 42 complaints
Exterior Lighting	Median 50,000 miles	Middle half 40,000–75,000 miles	Based on 127 complaints
Electrical System	Median 60,000 miles	Middle half 40,000–90,000 miles	Based on 110 complaints
Suspension	Median 60,000 miles	Middle half 35,000–100,000 miles	Based on 90 complaints
Power Train	Median 85,000 miles	Middle half 25,000–140,000 miles	Based on 84 complaints
Steering	Median 80,000 miles	Middle half 45,000–105,000 miles	Based on 65 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Dodge Ram 1500 in 4 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Audit Query AQ14-003: Chrysler's execution of 13V-528 & 529
Closed May 16, 2016
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page

Open and recently closed NHTSA defect investigations

Do Not Drive - Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V352000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 24, 2016 · Chrysler (FCA US LLC)

Potentially affected: 4,648,270 vehicles

Repair completion: 43.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign S43 · Owners notified March 27, 2017 · Vehicles built January 1, 2003 – September 1, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Dodge dealer immediately.

Defect description

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Safety consequence

These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Do Not Drive - Driver Side Frontal Air Bag May Rupture

NHTSA #15V313000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 26, 2015 · Chrysler (FCA US LLC)

Potentially affected: 4,077,169 vehicles

Repair completion: 47.11% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign R25 · Owners notified June 8, 2015 · Vehicles built January 1, 2003 – December 31, 2008 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Dodge dealer immediately.

Defect description

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Clutch Ignition Interlock Switch

NHTSA #14V795000 · Electrical System — Ignition — Switch · NHTSA notice

Reported December 16, 2014 · Chrysler Group LLC

Potentially affected: 54,164 vehicles

Repair completion: 31.67% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign P80 · Owners notified March 27, 2015 · Vehicles built July 1, 2005 – July 31, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Chrysler Group LLC (Chrysler) is recalling certain model year 2006-2007 Dodge Ram 1500, 2500, 3500, Dakota, and 2006 Mitsubishi Raider vehicles manufactured July 1, 2005, to July 31, 2006 with manual transmissions. The return springs in the clutch ignition interlock switch may break.

Safety consequence

Broken springs can result in a no-start condition, or cause unintended movement when the ignition is cranked, increasing the risk of a vehicle crash.

Manufacturer remedy

Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on March 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P80.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Failure of the Left Tie Rod Assembly

NHTSA #13V528000 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported November 6, 2013 · Chrysler Group LLC

Potentially affected: 706,664 vehicles

Repair completion: 31.96% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N62 · Owners notified January 17, 2014

Defect description

Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.

Safety consequence

A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.

Manufacturer remedy

Chrysler notified owners and launched its recall campaign in January 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N62.

Notes

This recall supersedes Chrysler tie rod recall 11V350. Vehicles that were previously remedied under recall 11V350 are also affected by this campaign. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

WHEEL HUB ASSEMBLY

NHTSA #10E040000 · Wheels — Hub · NHTSA notice

Reported August 23, 2010 · FEDERAL-MOGUL CORPORATION

Potentially affected: 34,604 vehicles

Owners notified September 15, 2010

Defect description

FEDERAL-MOGUL IS RECALLING CERTAIN CARQUEST, NATIONAL, AND PERCISION BRAND WHEEL HUB ASSEMBLIES, P/NOS 515073 AND 515073, SOLD FOR USE AS REPLACEMENT EQUIPMENT ON MODEL YEAR 2002 THROUGH 2008 DODGE RAM 1500 PICKUP TRUCKS. THE INBOARD ROLL FORM USED TO MAINTAIN THE HUB ASSEMBLY CAN FATIGUE RESULTING IN NOISE AND/OR WHEEL SEPARATION ON THE TWO WHEEL DRIVE (2WD) APPLICATIONS. THE RISK OF THESE ISSUES DO NOT OCCUR ON THE FOUR WHEEL DRIVE (4WD) APPLICATIONS, AND INSTALLATION ON THE 4WD APPLICATIONS ARE NOT PART OF THIS RECALL.

Safety consequence

A VEHICLE CRASH CAN OCCUR IF THE WHEEL SEPARATES FROM THE VEHICLE.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY OWNERS OF RECORD AND TECHNICIANS WILL REPLACE THE AFFECTED HUB ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 15, 2010. OWNERS MAY CONTACT FEDERAL-MOGUL AT 1-877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT CARQUEST AND NATIONAL WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DODGE RAM 1500 VEHICLES MANUFACTURED BY CHRYSLER LLC.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AFTERMARKET REPLACEMENT PITMAN ARMS

NHTSA #10E013000 · Steering — Gear Box — Shaft Pitman · NHTSA notice

Reported May 3, 2010 · FABTECH MOTORSPORTS

Potentially affected: 1,500 vehicles

Owners notified May 24, 2010

Defect description

FABTECH IS RECALLING CERTAIN AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS93001 AND FT44039, INSTALLED FOR USE ON CERTAIN 2003 THROUGH 2008 DODGE 2500 4WD, 3500 4WD, AND 1500 4WD MEGA CAB VEHICLES. THE PITMAN ARM CAN FRACTURE AND BREAK AWAY FROM THE STEERING BOX CAUSING TOTAL LOSS OF STEERING CONTROL.

Safety consequence

STEERING LOSS COULD RESULT IN A VEHICLE CRASH POSSIBLY RESULTING IN PROPERTY DAMAGE, INJURY OR DEATH.

Manufacturer remedy

FABTECH WILL NOTIFY OWNERS AND AUTHORIZED INSTALLERS WILL INSPECT FOR DEFECTIVE PITMAN ARM AND REPLACE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 24, 2010. OWNERS MAY CONTACT FABTECH AT 1-877-432-2832.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FABTECH REPLACEMENT PITMAN ARMS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DODGE 2500, 3500, AND 1500 VEHICLES MANUFACTURED BY CHRYSLER GROUP, LLC.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

CURVED TEMPERED AUTOMOTIVE REPLACEMENT GLASS

NHTSA #07E104000 · Visibility — Glass, Side/Rear · NHTSA notice

Reported December 11, 2007 · SAFELITE FULFILLMENT, INC.

Potentially affected: 1,657 vehicles

Owners notified January 15, 2008

Defect description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Manufacturer remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT WHEEL BEARING

NHTSA #07V038000 · Suspension — Front — Wheel Bearing · NHTSA notice

Reported February 12, 2007 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 86,333 vehicles

Manufacturer campaign G02 · Owners notified February 26, 2007 · Vehicles built November 7, 2005 – April 27, 2006 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS, THE FRONT WHEEL BEARING MAY HAVE RECEIVED AN INSUFFICIENT QUANTITY OF GREASE DURING THE MANUFACTURING PROCESS.

Safety consequence

THIS COULD RESULT IN BEARING DEGRADATION, AND IF SUBSEQUENT NOISE AND VIBRATION ARE IGNORED, COULD RESULT IN HUB ASSEMBLY SEPARATION. THIS MAY RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL REPLACE THE FRONT HUB AND BEARING UNITS. THE RECALL BEGAN ON FEBRUARY 26, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. G02.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 208/AIR BAG DEPLOYMENT/CHILD SEAT

NHTSA #06V353000 · Air Bags — Frontal · NHTSA notice

Reported September 14, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 144,750 vehicles

Manufacturer campaign F40 · Owners notified October 20, 2006

Defect description

ON CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION. THE PASSENGER AIR BAG MAY DEPLOY WITH EXCESSIVE FORCE WHEN CERTAIN MODEL REAR FACING CHILD SEATS ARE INSTALLED IN THE RIGHT FRONT PASSENGER SEAT POSITION.

Safety consequence

THIS CAN INCREASE THE RISK OF INJURY TO A CHILD SEAT OCCUPANT DURING CERTAIN CRASH CONDITIONS.

Manufacturer remedy

DEALERS WILL REPLACE THE PASSENGER AIR BAG CUSHION AND REPROGRAM THE OCCUPANT RESTRAINT CONTROLLER. THE RECALL BEGAN ON OCTOBER 20, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F40. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 208/SEAT BELT ASSEMBLY/CHILD SEATS

NHTSA #06V354000 · Seat Belts — Front · NHTSA notice

Reported September 14, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 159,741 vehicles

Manufacturer campaign F41 · Owners notified October 20, 2006 · Vehicles built February 7, 2005 – June 30, 2006 (per NHTSA)

Defect description

CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE FRONT PASSENGER SEAT BELT MAY NOT BE ABLE TO TIGHTEN SECURELY ON CERTAIN MODEL CHILD SEATS.

Safety consequence

THIS CAN INCREASE THE RISK OF INJURY TO A CHILD SEAT OCCUPANT IN THE EVENT OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE FRONT PASSENGER SEAT BELT. THE RECALL BEGAN ON OCTOBER 20, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F41. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

ABS ECU

NHTSA #06V038000 · Service Brakes, Hydraulic — Antilock/Traction Control/Electronic Limited Slip — Control Unit/Module · NHTSA notice

Reported February 9, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 39,274 vehicles

Manufacturer campaign F05 · Owners notified July 17, 2006 · Vehicles built September 12, 2005 – December 11, 2005 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), THE ABS ELECTRONIC CONTROL UNIT (ECU) MAY CAUSE A LOSS OF FRONT TO REAR BRAKE BALANCE, AND THE REAR BRAKES COULD LOCK UP PREMATURELY DURING CERTAIN BRAKING CONDITIONS.

Safety consequence

THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL REPLACE THE ABS ECU. THE RECALL IS EXPECTED TO BEGIN DURING THE WEEK OF JULY 17, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F05.(MITSUBISHI RECALL NO. SR-06-003).CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

TRANSFER CASE CONTROL MODULE

NHTSA #05V461000 · Power Train — Transfer Case (4-WHEEL DRIVE) · NHTSA notice

Reported October 6, 2005 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 136 vehicles

Manufacturer campaign E18 · Owners notified November 7, 2005 · Vehicles built February 9, 2005 – September 7, 2005 (per NHTSA)

Defect description

ON CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS, THE TOTALLY INTEGRATED POWER MODULE (TIPM) MAY CONTAIN INCORRECT TRANSFER CASE CALIBRATION SET POINTS, POTENTIALLY RESULTING IN INADVERTENT TRANSFER CASE DEFAULT TO NEUTRAL.

Safety consequence

IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.

Manufacturer remedy

DEALERS WILL REPROGRAM THE TIPM WITH NEW SOFTWARE THAT PREVENTS THE POTENTIAL FOR THIS CONDITION. THE RECALL BEGAN ON NOVEMBER 7, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. E18.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY:1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Dodge Ram 1500 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

4 investigations

2006 Dodge Ram 1500 Regular Cab

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

20% rollover risk

Safety Technology

4 investigations

792 owner complaints have been filed with NHTSA for the 2006 Dodge Ram 1500.

Air Bags

ODI #11718823

Incident: February 18, 2026 · Filed: February 18, 2026

The contact owns a 2006 Dodge Ram 1500. The contact received notification of NHTSA Campaign Number: 16V352000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Power Train

ODI #11716319

Incident: February 6, 2023 · Filed: February 6, 2026

The contact owns a 2006 Dodge Ram 1500. The contact stated that while the vehicle was parked, oil stains were found on the ground underneath the vehicle. The contact checked underneath the vehicle and became aware that the rear axle pinion nut was loose. The axle pinion nut was tightened. The contact stated that the oil stains on the ground persisted. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 14V796000 (POWER TRAIN); however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

Power Train

ODI #11695312

Incident: October 20, 2025 · Filed: October 23, 2025

The pinion nut loosen up causing the pinion to lock down into the ring gear and locked the rear axle housing, ejecting the drive shaft.

Suspension; Power Train; Electrical System

ODI #11688378

Incident: September 19, 2025 · Filed: September 19, 2025

Several safety-critical systems on my vehicle are failing, and the symptoms match existing recalls shown on Kelley Blue Book for my VIN. However, the manufacturer (Dodge/Stellantis) shows only 4 recalls, all marked completed — despite ongoing issues. 1. ABS / Brake System: The ABS warning light is on continuously, indicating a malfunction in the ABS control module. This disables anti-lock braking, increasing the risk of skidding or loss of control during emergency stops. KBB shows a recall for this issue, but Dodge says it’s either not open for my VIN or already completed. The ABS light has remained on since 2. Front Wheel Bearing: There is a grinding noise and vibration from the front wheel area, suggesting a worn or failing wheel bearing. This poses a risk of steering loss or wheel detachment. No warning lights have appeared for this issue. 3. Transfer Case / 4WD: The 4WD system intermittently fails to engage or disengage, sometimes with clunking noises or jerking. This can cause unpredictable handling or loss of traction. Issue is still ongoing. 4. Electrical System: Intermittent electrical issues include random warning messages, dimming lights, and occasional no-starts. These affect essential safety systems and match known electrical recalls. These issues have not been confirmed by a dealer but are ongoing and present serious SAFETY risks. I believe my vehicle may have been incorrectly excluded from applicable recalls or that prior recall work was not properly completed. These components are available for inspection.

Tires

ODI #11680930

Incident: August 15, 2025 · Filed: August 15, 2025

The contact owns a 2006 RAM 1500 equipped with Arroyo Tires, Tire Line: Tamarock A/T, Tire Size: 33X12.50/R18, DOT Number: 1TBDDP35C0924 and 1TBDDP35C0824. The contact stated that while driving at an undisclosed speed, the steering wheel started to vibrate excessively. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who determined that the tires needed to be balanced. The contact was later informed that the tires could not be properly balanced due to irregularities in the inner liner. The contact was advised that all four tires needed to be replaced. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 20,000.

Engine

ODI #11673569

Incident: June 1, 2025 · Filed: July 15, 2025

The contact owns a 2006 Dodge Ram 1500. The contact stated that while driving at various speeds, the vehicle suddenly shut off. During the failure, the power steering and power braking system became inoperable. After restarting the vehicle, the vehicle operated normally. The vehicle was taken to the local dealer who replaced the spark plugs and ignition coils however, the failure persisted. The manufacturer and local dealer were not yet contacted or notified of the failure. The failure mileage was 90,000.

Unknown or Other; Service Brakes

ODI #11577712

Incident: March 15, 2024 · Filed: March 16, 2024

This has been a issue going on several months . I can be driving down the road on any Giving day , road conditions wet or dry .I was driving 57 mph and vehicle in front of me hit the brakes ,causing me to hit mine as of sudden , but instead of stopping the brake pedal shifts toward the gas pedal causing me to brake and hit the gas at the same time. No I didn't wreck but came close as I corrected it very quick. This could have xausd me to run into on coming traffic and seriously caused fatal injuries or death. Thank God it wasn't raining . Vehicle hasn't been inspected because I don't have the money to have it inspected . The brake pedal I checked and you can take your hand and the pedal will go side to side over the gas pedal . There was no warning light or check engine light for this issue.

Power Train

ODI #11574135

Incident: February 25, 2024 · Filed: February 26, 2024

Rear axle pinion nut was loosening and pinion was leaking.I had this happen on another 2006 RAM 1500 where the nut backed all the way off and the drive shaft hit the road.

Air Bags

ODI #11570579

Crash

Incident: January 29, 2024 · Filed: February 7, 2024

Unknown

Electrical System

ODI #11560564

Incident: December 13, 2023 · Filed: December 17, 2023

I was adjusting the steering wheel and the power completely shuts off. I had no steering power.

Other Dodge Ram 1500 model years

Check your 2006 Dodge Ram 1500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Dodge Ram 1500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Dodge VIN