NHTSA vehicle safety data

2002 Dodge Ram 1500 Recalls & Complaints

The 2002 Dodge Ram 1500 has 6 NHTSA recall campaigns and 815 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Dodge dealer.

NHTSA recall and complaint data for the 2002 Dodge Ram 1500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2002 Dodge Ram 1500 owner complaints

Owners have filed 815 complaints with NHTSA about the 2002 Dodge Ram 1500, describing incidents dated November 20, 2001 to October 15, 2024.

Most-cited components

Structure 278 complaints
Power Train 99 complaints
Electrical System 93 complaints
Engine 80 complaints
Suspension 71 complaints
Unknown or Other 62 complaints

Of the 815 complaints on file, 55 report a crash and 14 a fire; across all 815 complaints, owners report 62 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11726774 · Filed March 24, 2026
I bought this truck new I still own problem is the cooling system does not function properly I have put new radiator and all heat and cooling in it the heat and air does not operate properly I have talked with crysler several times and they will help with issue it’s been like this about as long as I…
ODI #11625032 · Filed November 13, 2024
Dodge Ram 2002 ABS brake module failure. No recourse for repairs. Dodge has rendered this part obsolete and although they have the technology to repair or replace it they neglect to help thousands of vehicle owners.
ODI #11594041 · Filed June 12, 2024
The contact owns a 2002 Dodge Ram 1500. The contact stated that while driving at an undisclosed speed at night, he became aware that the external lights and turn signal lights were not functioning properly. The lamp out warning light was illuminated. The vehicle was not taken to the dealer or an…

Read all 815 complaints

Owner-reported

2002 Dodge Ram 1500 mileage at failure

576 of the 815 complaints on file for the 2002 Dodge Ram 1500 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Structure	Median 75,000 miles	Middle half 60,000–100,000 miles	Based on 197 complaints
Power Train	Median 80,000 miles	Middle half 35,000–140,000 miles	Based on 80 complaints
Electrical System	Median 85,000 miles	Middle half 40,000–120,000 miles	Based on 79 complaints
Engine	Median 75,000 miles	Middle half 40,000–110,000 miles	Based on 56 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2002 Dodge Ram 1500 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE02-096: REAR AXLE FAILURE
Closed May 15, 2003

Open and recently closed NHTSA defect investigations

WHEEL HUB ASSEMBLY

NHTSA #10E040000 · Wheels — Hub · NHTSA notice

Reported August 23, 2010 · FEDERAL-MOGUL CORPORATION

Potentially affected: 34,604 vehicles

Owners notified September 15, 2010

Defect description

FEDERAL-MOGUL IS RECALLING CERTAIN CARQUEST, NATIONAL, AND PERCISION BRAND WHEEL HUB ASSEMBLIES, P/NOS 515073 AND 515073, SOLD FOR USE AS REPLACEMENT EQUIPMENT ON MODEL YEAR 2002 THROUGH 2008 DODGE RAM 1500 PICKUP TRUCKS. THE INBOARD ROLL FORM USED TO MAINTAIN THE HUB ASSEMBLY CAN FATIGUE RESULTING IN NOISE AND/OR WHEEL SEPARATION ON THE TWO WHEEL DRIVE (2WD) APPLICATIONS. THE RISK OF THESE ISSUES DO NOT OCCUR ON THE FOUR WHEEL DRIVE (4WD) APPLICATIONS, AND INSTALLATION ON THE 4WD APPLICATIONS ARE NOT PART OF THIS RECALL.

Safety consequence

A VEHICLE CRASH CAN OCCUR IF THE WHEEL SEPARATES FROM THE VEHICLE.

Manufacturer remedy

FEDERAL-MOGUL WILL NOTIFY OWNERS OF RECORD AND TECHNICIANS WILL REPLACE THE AFFECTED HUB ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 15, 2010. OWNERS MAY CONTACT FEDERAL-MOGUL AT 1-877-489-6659.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT CARQUEST AND NATIONAL WHEEL HUB ASSEMBLIES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DODGE RAM 1500 VEHICLES MANUFACTURED BY CHRYSLER LLC.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

CURVED TEMPERED AUTOMOTIVE REPLACEMENT GLASS

NHTSA #07E104000 · Visibility — Glass, Side/Rear · NHTSA notice

Reported December 11, 2007 · SAFELITE FULFILLMENT, INC.

Potentially affected: 1,657 vehicles

Owners notified January 15, 2008

Defect description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Manufacturer remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

REPLACEMENT AIR INTAKE SYSTEMS/DEBRIS CAN ENTER

NHTSA #06E024000 · Engine and Engine Cooling · NHTSA notice

Reported March 15, 2006 · K&N ENGINEERING, INC.

Potentially affected: 44,386 vehicles

Owners notified April 20, 2006

Defect description

CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.

Safety consequence

A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.

Manufacturer remedy

K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.

Notes

THIS RECALL ONLY PERTAINS TO REPLACEMENT K&N FUEL PERFORMANCE KITS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DODGE VEHICLES MANUFACTURED BY DAIMLERCHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

DAIMLERCHRYSLER/FMVSS 120/TIRES

NHTSA #03V504000 · Tires · NHTSA notice

Reported December 10, 2003 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 214 vehicles

Manufacturer campaign C40 · Owners notified December 22, 2003 · Vehicles built July 1, 1999 – July 31, 2001 (per NHTSA)

Defect description

ON CERTAIN 4X4 PICKUP TRUCKS EQUIPPED WITH THE SNOW PLOW PREPARATION PACKAGE, THE TIRES SUPPLIED ON SOME VEHICLES MAY HAVE GROSS AXLE WEIGHT RATINGS THAT SLIGHTLY EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Manufacturer remedy

DEALERS WILL PROVIDE REPLACEMENT P245/75R16 TIRES TO MEET THE LOAD CARRYING CAPACITY SPECIFIED ON THE VEHICLE CERTIFICATION LABEL AND ACCOMMODATE THE ADDITION OF A COMMERCIALLY AVAILABLE SNOW PLOW AND HARDWARE. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

Notes

DAIMLERCHRYSLER RECALL NO. C40.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DAIMLERCHRYSLER/STEERING COLUMN ELECTRICAL CONNECT

NHTSA #03V078000 · Steering — Column · NHTSA notice

Reported March 10, 2003 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 287,725 vehicles

Manufacturer campaign C11 · Owners notified April 10, 2003 · Vehicles built July 1, 2001 – July 1, 2002 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS, THE ELECTRICAL CONNECTOR AT THE BOTTOM OF THE STEERING COLUMN CONTAINS AN UNDER-SIZED TERMINAL FOR THE HVAC BLOWER MOTOR CIRCUIT. LOCALIZED HEATING FROM CURRENT FLOW WITH THE BLOWER SPEED SET ON HIGH MAY CAUSE THE TERMINAL CONTACTS TO RELAX AND LOSE ELECTRICAL CONTACT. THIS CAN CAUSE THE HVAC BLOWER MOTOR TO BECOME INOPERATIVE.

Safety consequence

THIS CONDITION COULD CAUSE IMPAIRMENT OF VISIBILITY IN INCLEMENT WEATHER, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A WIRING HARNESS OVERLAY TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN APRIL 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. C11.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

DAIMLERCHRYSLER/EXTERIOR MIRRORS

NHTSA #03V077000 · Visibility — Rearview Mirrors/Devices — Exterior · NHTSA notice

Reported March 10, 2003 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 195,500 vehicles

Manufacturer campaign C10 · Owners notified April 10, 2003 · Vehicles built March 2, 2001 – April 18, 2003 (per NHTSA)

Defect description

ON CERTAIN PICKUP TRUCKS, THE DETENT SYSTEM ON THE EXTERIOR MIRROR HOUSINGS MAY LOSE THE FUNCTIONALITY.

Safety consequence

THIS COULD POTENTIALLY AFFECT REARWARD FIELD OF VISION, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL A MIRROR DETENT RETAINER KIT TO CORRECT THIS CONDITION. OWNER NOTIFICATION BEGAN ON APRIL 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. C10.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2002 Dodge Ram 1500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

815 owner complaints have been filed with NHTSA for the 2002 Dodge Ram 1500.

Engine

ODI #11726774

Incident: January 1, 2004 · Filed: March 24, 2026

I bought this truck new I still own problem is the cooling system does not function properly I have put new radiator and all heat and cooling in it the heat and air does not operate properly I have talked with crysler several times and they will help with issue it’s been like this about as long as I have had it please help me and there’s a whole lot more people with same issue and it’s a very bad problem with the windshield keeps fogging up can not see the road or traffic

Service Brakes

ODI #11625032

Incident: October 15, 2024 · Filed: November 13, 2024

Dodge Ram 2002 ABS brake module failure. No recourse for repairs. Dodge has rendered this part obsolete and although they have the technology to repair or replace it they neglect to help thousands of vehicle owners.

Exterior Lighting

ODI #11594041

Incident: June 12, 2024 · Filed: June 12, 2024

The contact owns a 2002 Dodge Ram 1500. The contact stated that while driving at an undisclosed speed at night, he became aware that the external lights and turn signal lights were not functioning properly. The lamp out warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

Electrical System

ODI #11553692

Incident: March 30, 2023 · Filed: November 5, 2023

The heat stopped working so i replaced the blower motor and blower relay the heater switch and still have no heat. The wire gets hot to the touch. The heater only use to work on high then all of a sudden it just stopped all the way around

Suspension; Unknown or Other

ODI #11531959

Incident: July 13, 2023 · Filed: July 13, 2023

To put it as simple as I can describe it is a death wobble. that occurs every time you hit a bump in the road, hole, or pot hole. This truck has always had this death wobble from factory. The reason why this is a safety issue is because it causes the steering wheel to go out of balance and go into other lanes in the road and potentially cause an accident.

Electrical System

ODI #11507456

Incident: July 1, 2018 · Filed: February 15, 2023

The contact owns a 2002 Dodge Ram 1500. The contact stated while attempting to turn on the heat in the vehicle, the HVAC system failed to operate as needed. The vehicle was taken to the dealer and the contact was informed that the instrument panel needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated there was no recall for the failure. There was no additional assistance provided. The failure mileage was 50,000.

Tires

ODI #11466612

Incident: May 28, 2022 · Filed: May 29, 2022

I was driving on the highway at about 65mph and at first I noticed that it felt like my tie rod ends were going bad. And then all of a sudden I felt an explosion and my truck made a sharp right dive into the right hand lane and caused the car in that lane to swerve right. I was then able to gain back control and gradually came to a stop on the right hand berm of the highway. The right rear tire appeared just as it does in the attached photos. The tire size is p264/70R17 no authorities were notified and the tire has not been inspected by anyone.

Air Bags; Unknown or Other

ODI #11436510

Crash 1 injury

Incident: October 11, 2021 · Filed: October 12, 2021

While traveling at normal speeds approximately 40 mph a car ran a stop sign I t-boned them on their passenger side with my front end I hit them at approximately 40 mph my airbags did not deploy my face and chest hit the steering wheel and dash

Power Train

ODI #11436280

Incident: September 7, 2021 · Filed: October 11, 2021

Pinion nut became loose. It was caught before it totally fell off, however if it did fall off the rear axle could possible seize up and cause loss of control of the vehicle. This is a 2002 Dodge Ram with the 9.25" rear axle and they appear to still have issues to this day with that axle model. The recall Dodge had in 2009/10 does not even begin to cover the number of Dodge Ram/Dakota vehicles with this issue. The axle in this vehicle was replaced in 2009 for another issue with an axle retainer clip falling off and causing the internal assembly to grind on the boss for the axle. So as the original owner, and with only 137,140 miles on the vehicle in 19 years, it has had multiple problems fixed under warranty, including total axle replacement and now it will have rebuilt again. There should be a real safety concern for all Dodge pickups with the 9.25" rear axle and a recall for every one of them, not just 2009/10. This has been happening for 20 years. When will NHTSA step up and hold Dodge to task for this issue. Regards, [XXX] Minden, NV INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Service Brakes

ODI #11423015

Incident: June 25, 2012 · Filed: June 30, 2021

The brakes failed due to corrosion of the brake line from the master cyl. to the LH front brake flex hose. The brake fluid simply came out of the line. There was insifficient fluid pressure to do any wheel braking. Luckily, I had just moved off from a stop and was applying the brakes to slow down on a bend. The corrosion occured under a plastic clip that is there to keep adjacent brake lines from vibrating against each other. The corrosion occured in an area that is not inspectable unless the front wheel and wheel arch cover is first removed.

Other Dodge Ram 1500 model years

Check your 2002 Dodge Ram 1500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Dodge Ram 1500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Dodge VIN