NHTSA vehicle safety data

2006 Dodge Grand Caravan Recalls, Ratings & Complaints

The 2006 Dodge Grand Caravan has 4 NHTSA recall campaigns and 284 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Dodge dealer.

NHTSA recall and complaint data for the 2006 Dodge Grand Caravan, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Dodge Grand Caravan owner complaints

Owners have filed 284 complaints with NHTSA about the 2006 Dodge Grand Caravan, describing incidents dated January 13, 2006 to April 30, 2025.

Most-cited components

Steering 61 complaints
Air Bags 54 complaints
Electrical System 38 complaints
Structure 36 complaints
Engine 31 complaints
Fuel/Propulsion System 31 complaints

Of the 284 complaints on file, 12 report a crash and 3 a fire; across all 284 complaints, owners report 21 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11701888 · Filed November 28, 2025
The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing…
ODI #11661014 · Filed May 14, 2025
The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the…
ODI #11603521 · Filed July 20, 2024
My complaint involves more than one incident...it is the braking system on this vehicle. One incident was in Panama City Beach, Florida. My entire braking system locked up and I had numerous items replaced. Another more recent incident happened in Alabama. My left front brake heated up to the point…

Read all 284 complaints

Owner-reported

2006 Dodge Grand Caravan mileage at failure

254 of the 284 complaints on file for the 2006 Dodge Grand Caravan give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Steering	Median 55,000 miles	Middle half 40,000–75,000 miles	Based on 57 complaints
Air Bags	Median 50,000 miles	Middle half 35,000–80,000 miles	Based on 48 complaints
Electrical System	Median 80,000 miles	Middle half 60,000–125,000 miles	Based on 34 complaints
Structure	Median 60,000 miles	Middle half 50,000–90,000 miles	Based on 32 complaints
Fuel/Propulsion System	Median 95,000 miles	Middle half 70,000–115,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Dodge Grand Caravan in 5 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Audit Query AQ10-001: Fleet Vehicle Recall Completion Audit
Closed December 28, 2015
Defect Petition DP14-002: Engine Stall After Refueling
Closed April 6, 2015
Engineering Analysis EA11-010: Loss of headlight illumination
Closed November 29, 2012
Recall Query RQ09-003: FRONT AIR BAG CRASH SENSOR FAILURE
Closed February 18, 2010
- Recall 10V-008
Engineering Analysis EA06-003: FRONT AIR BAG CRASH SENSOR FAILURE
Closed May 22, 2007
- Recall 07V-192

Open and recently closed NHTSA defect investigations

6-WAY POWER SEAT BASE

NHTSA #10V338000 · Seats · NHTSA notice

Reported July 27, 2010 · DRIVING SPECIALTIES LTD

Potentially affected: 2 vehicles

Owners notified July 28, 2010 · Vehicles built March 9, 2006 – March 9, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DRIVING SPECIALTIES LTD IS RECALLING 2 MODEL YEAR 2006 AND 2007 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.

Safety consequence

THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.

Manufacturer remedy

DRIVING SPECIALTIES WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT DRIVING SPECIALTIES AT 1-707-553-1515.

Notes

THIS RECALL ONLY PERTAINS TO VEHICLES ALTERED BY DRIVING SPECIALTIES AND HAS NO RELATION TO ANY VEHICLES MANUFACTURED BY CHRYSLER.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT AIR BAG CRASH SENSOR FAILURE

NHTSA #10V008000 · Air Bags — Frontal — Sensor/Control Module-Inactive · NHTSA notice

Reported January 11, 2010 · CHRYSLER GROUP LLC

Potentially affected: 308,950 vehicles

Manufacturer campaign J38 · Owners notified April 19, 2010 · Vehicles built January 19, 2005 – April 5, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.

Safety consequence

IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.

Manufacturer remedy

CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes

CHRYSLER'S CAMPAIGN NUMBER IS J38. CHRYSLER HAS NOT DECIDED THAT THIS IS A DEFECT RELATED TO MOTOR VEHICLE SAFETY.HOWEVER, CHRYSLER HAS INFORMED NHTSA THAT IT WILL PROVIDE THE MODIFICATIONS DESCRIBED ABOVE AT NO COST.

CURVED TEMPERED AUTOMOTIVE REPLACEMENT GLASS

NHTSA #07E104000 · Visibility — Glass, Side/Rear · NHTSA notice

Reported December 11, 2007 · SAFELITE FULFILLMENT, INC.

Potentially affected: 1,657 vehicles

Owners notified January 15, 2008

Defect description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Manufacturer remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT WINDSHIELD WIPER MOTOR

NHTSA #06V067000 · Visibility — Windshield Wiper/Washer — Motor · NHTSA notice

Reported March 8, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 268,800 vehicles

Manufacturer campaign F10 · Owners notified June 19, 2006 · Vehicles built September 27, 2005 – December 13, 2005 (per NHTSA)

Defect description

ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.

Safety consequence

DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F10.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Dodge Grand Caravan

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

5 investigations

284 owner complaints have been filed with NHTSA for the 2006 Dodge Grand Caravan.

Engine and Engine Cooling

ODI #11701888

Incident: November 5, 2013 · Filed: November 28, 2025

The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle idled roughly, jerked and stalled while driving. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed with power train failure. The vehicle was taken to the dealer, where the contact was informed that the vehicle was missing the Exhaust Gas Recirculation (EGR) valve. The contact was provided DTCs: P0403 and P0404. The vehicle was not repaired. In 2019, the vehicle was taken to a tire business and the EGR valve was installed on the vehicle. The failure was progressively worsened, and the vehicle was no longer being driven. Upon further investigation, the contact found information on various auto websites indicating that the vehicle was manufactured in Canada and imported to the United States. The contact was the second owner. The contact found information on other auto websites that stated that the EGR valve was removed from the vehicle, and it was removed in stages. The manufacturer was notified of the failure. The contact was informed that the VIN was not under recall. The failure mileage was approximately 122,000.

Power Train; Electrical System; Visibility

ODI #11661014

Incident: April 30, 2025 · Filed: May 14, 2025

The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The contact stated that the failure occurred while driving near the residence. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. Additionally, the contact stated that the sliding doors had failed to close and lock automatically and sometimes opened while driving. Additionally, the contact stated that one of the windows failed to roll down. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.

Service Brakes

ODI #11603521

Incident: March 27, 2024 · Filed: July 20, 2024

My complaint involves more than one incident...it is the braking system on this vehicle. One incident was in Panama City Beach, Florida. My entire braking system locked up and I had numerous items replaced. Another more recent incident happened in Alabama. My left front brake heated up to the point it smelled like the vehicle was on fire. I have had several calipers and rotors replaced, numerous brake pads and not all of these repairs has been done by the same garage. I read complaints from others about the manufacturers brake system is too small for this style vehicle. They have experienced the same problems I have had. I bought this vehicle in 2015 and I have 155,000 miles on it. I have had to replace a water pump and spark plugs and wires, regular oil changes, etc. The only real problem I have had has been the brakes. I have spent almost $3,500 on brakes alone. I would think the braking system could be a very hazardous situation in the traffic of today. Please help me and others who are experiencing this problem with the braking systems on the 2006 Dodge Grand Caravans. Thank you.

Air Bags

ODI #11545805

Incident: May 16, 2023 · Filed: September 21, 2023

The contact owns a 2006 Dodge Grand Caravan. The contact stated that on several occasions, the air bag warning light illuminated for two minutes and then disappeared. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 146,032.

Exterior Lighting

ODI #11421495

Incident: June 19, 2021 · Filed: June 19, 2021

The headlights and taillights come on randomly throughout the day and night while the car is parked and off. The warning dings for accidentally leaving your lights on happens every time you open the doors even though the lights are off. This has been going on since we got the vehicle.

Exterior Lighting; Air Bags

ODI #11299939

Incident: January 15, 2020 · Filed: January 16, 2020

LIGHTS GO OUT WHEN THE RAIN GETS UP UNDER THE CAR FROM SPLASHING ON THE ROAD. YOU HAVE TO PULL OVER TO THE SIDE OF THE ROAD, TURN IT OFF AND TURN IT BACK ON SEVERAL TIMES AND IT STAYS ON FOR A SHORT TIME. PROCEDURE IS REPEATED AGAIN. ONLY IN RAINY WEATHER AND OREGON GETS A LOT OF SPORADIC RAIN. ALSO, THE IGNITION TENDS TO TURN THE AIRBAG LIGHTS ON AND OFF WHENEVER I TURN A CORNER LEFT OR RIGHT OF HIT A BUMP.

Engine

ODI #11280214

Incident: December 1, 2018 · Filed: November 14, 2019

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE OIL PRESSURE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. ON NOVEMBER 9, 2019, WHILE DRIVING 55 MPH, WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS LOSING SPEED, BUT WAS ABLE TO BE PULLED OVER TO THE SIDE OF THE ROAD. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT CALLED THE POLICE DUE TO HER DISABLED HUSBAND BEING IN THE COLD FOR OVER TWO HOURS. A POLICE REPORT WAS FILED. HE WAS TRANSPORTED TO THE HOSPITAL, BUT THERE WERE NO INJURIES OR MEDICAL ATTENTION NEEDED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT WAS INFORMED THAT THERE WAS AN OIL LEAK IN THE ENGINE AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

Unknown or Other

ODI #11280071

Incident: November 10, 2019 · Filed: November 10, 2019

SLIDING DOOR LOCK ACTUATOR FROZE UP.THIS RENDERSTHE SLIDING DOOR COMPLETELY INOPERABLE.IF THAT DOOR WAS NEEDED FOREGRESS,IT WOULDNT BE AVAILABLE!!

Steering

ODI #11245591

Incident: August 21, 2019 · Filed: August 21, 2019

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD NOISES COMING FROM THE STEERING COLUMN. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE VIN WAS INCLUDED IN AN UNKNOWN RECALL; HOWEVER, NO RECALL WAS FOUND. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000.

Unknown or Other

ODI #11223007

Incident: June 27, 2019 · Filed: June 27, 2019

DRIVER SIDE SLIDING DOOR IS LOCKED AND CAN'T BE UNLOCKED MANUALLY OR WITH FOB OR OVERHEAD BUTTON. VERY WORRIED ABOUT PASSENGERS NOT BEING ABLE TO EXIT DURING AN EMERGENCY. *DT CONSUMER STATED SHE WILL TAKE IT TO HER LOCAL DODGE DEALER.*JB

Other Dodge Grand Caravan model years

Check your 2006 Dodge Grand Caravan VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Dodge Grand Caravan at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Dodge VIN