2020 Chevrolet Impala Recalls, Ratings & Complaints

Incident: June 23, 2026 · Filed: July 15, 2026

On XXX | purchased a 2020 Chevrolet Impala, VIN [XXX], from NYS Office of General Services via GovDeals Inventory #200075. OGS Bill of Sale #XXX stated 59,145 miles and Clean Title. Carfax shows: 1. 90,803 miles on 12/16/2024 while in OGS possession 2. Total Loss declared 5/21/2025 3. Accident with rear damage 5/21/2025 not disclosed Actual odometer reading on 7/3/2026: 99,241 miles. OGS rolled back 31,658 miles and sold Total Loss vehicle as Clean Title. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: May 4, 2026 · Filed: June 16, 2026

The component is the Evaporative Emission Control System (EVAP) Vapor Canister Purge Valve.The internal diaphragm or solenoid of the factory-installed purge valve has worn out prematurely or became contaminated, locking it permanently into a stuck-open position.The Manifestation or (Symptoms): The stuck-open valve continuously drafts raw fuel vapor and unmetered air into the engine intake manifold. This causes an improper air-fuel mixture, resulting in:Stumbling / Failure to Start Immediately After Refueling (the engine is flooded by gas tank vapors forced in during fill-up).Rough Idling (due to a continuous vacuum leak).Illuminated Check Engine Light tracking Diagnostic Trouble Codes (DTCs) P0496 (High Purge Flow) or P0442. Yes, it is available for inspection. The vehicle stumbles, hesitates, and fails to restart at busy gas pumps and intersections which places drivers, passengers, and other motorists at an immediate risk of a collision. Yes, the problem has been validated by an professional auto mechanic shop. No, it has not been inspected by anyone else other than the mechanicshop to diagnose the problem, issue. The check engine light came on as I cranked the vehicle up and it started idling. No known symptoms until check engine came on prior to failing. The check engine light first appeared in May 2026 as well as the codes mentioned above.

Incident: September 3, 2025 · Filed: September 7, 2025

Seatbelt warning and blinkers have no sound warnings and driver side blind spot warning are not working

Incident: January 1, 2025 · Filed: August 11, 2025

2020 Chevrolet Impala Premier purchased July, 2015, mileage: + or - 12 miles I started having hard steering and made several trips to the dealer while under warranty and the dealer could not gen an OBD reading and no on dash reading. Right after the warranty was up and at 5,322 miles they were able to get an OBD reading. Information from the dealer invoice: A multi-point inspection DI1 Multi-Point inspection 716106 CPC B C/S veh is hard to steer at times- acts like it has no electric steering ADV cause: DTC O800 power steering control module low voltage, found while battery sitting over TP test dead cell and low cca 185/535cca EGO1 drivability test 716106 CPC $69.95 1 88866309 $190.00 New Battery Final charge: $317.44 No hard steering for a while, and now at 7,500 + or - miles hard steering is back and becoming harder to steer at times, especially if breaking. I have been to the dealer more often and had wait for the a while to get checked in and by the time he gets to me and someone to drive my car the steering is back to normal again. They told me that without a dash or ODB reading there is nothing they can do. 5 years same problem and never know when it will happen.

Incident: July 8, 2025 · Filed: July 20, 2025

I Took My Car To Castle Villa Park On July 8 2025 And Explained To Tony That Check My Car In That It Sound As If It Was A Hub Bearing My Car Was Dropped Off At 7:00 AM Until Around 1:00PM I Was Told I Need A Tire To See If It Was My Hub Bearing Which Didn’t Make Sense To Me So I Ask For A Supervisor I Was Then Inform That They Could Tell If They Switch My Tires Later On I Was Told It Was A Tire Came Took My Car To Firestone This Sat 07/19/2025 I Was Told I Didn’t Need Tires It Is In Fact Both Of My Hub Bearing So I Paid 100.00 Diagnostic Fee To Castle And Risking My Life Driving My Car When They Knew In Fact That It Was My Hub Bearings My Car Is Under Warranty If It Wasn’t They Would Have Fixed It And Charge Me I Am Taking My Car Back Monday I Have Made Several Complaints On This Dealer And Nothing Is Happening This Is Unfair For Consumer To Take Advantage Of Customers

Incident: March 31, 2025 · Filed: March 31, 2025

I purchased this vehicle in a CHEVY DEALERSHIP in palatine, IL. [XXX]. 50k miles a chevy impala around 38k total with taxes and all. A month later I had to pay 200 for a diagnostic at the dealership to check an issue with the steering. They said nothing was wrong with it and it was just the floor mat making contact in the floor. When I returned home, I had the same issue occur AGAIN. I retook it and they wanted another 200 dollars. I complained to the seller of this vehicle, and he agreed to waive these 200 dollars. When it was rechecked, it was found out that it actually had to replace the wheel barring's on the front. It was around a 2,000$ job I have the receipts, and I actually didn't pay for anything at the time due to warranty. I also have been up to date with transmission oil, engine oil, fuel injectors, etc to keep the car running smooth. As of 01/2025 I started having issues with the transmission, the gears were very jumpy and very unsafe to drive. I called the dealership and i was told the warranty had a expire a month before. I had to call the bank to find out this telephone number since the dealership never responded back. the number I was looking for was the warranty which my contract that was given from the dealership coincidence didnt have it. I had to reach to the bank and ask for a new contract. I called them and was denied due to the time that has past and was out of luck. I took it to a mechanic for a transmission rebuilt and cost me 3,000 which im still paying off right now. It was repair around [XXX]. Now I have an issue with the power steering. I also have a check engine light now. I am in the process of taking it to the transmission job to look at it but most likely wont get fix. I now have to invest around another 1,500+ for these new jobs. I dont have that much now and its costing me a lot of headaches pain money and time and many more things. GM wont do anything about it and I still have to pay550 a month for this vehicle. IDK.HELP INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 29, 2024 · Filed: October 29, 2024

The contact's friend owned a 2020 Chevrolet Impala E. The contact stated that while her friend was driving at 25 MPH and approaching a curve, he inadvertently lost control of the vehicle.  As a result, the vehicle left the roadway, rolled, and came to a complete stop with all four wheels facing upwards after colliding with a tree. Though the vehicle rolled on its back no air bags were deployed. No warning lights were illuminated. The vehicle was towed to a tow yard but had yet to be deemed a total loss by the driver's insurance provider. A police report was filed and injuries were reported. The driver refused medical attention from EMS at the time of the accident but stated that he would seek medical evaluation at a later date as he had hit his head on the driver's side door window as a result of the accident, resulting in visible injuries. The manufacturer was not notified of the failure. The failure mileage was 85,000.

Incident: August 22, 2024 · Filed: September 21, 2024

The back window is leaking and water is getting all on my trunk and ruining my items. Ford did not do a good job of sealing the windows.

Incident: August 29, 2024 · Filed: September 19, 2024

I was driving down the highway in anchorage ak I heard a loud bang like a gunshot , when the vehicle was inspected I was told basically Evap, fuel system , fans , electrical , Cadillac converter exploded was the loud bang ! Serious issues have caused the vehicle to be inoperable !

Incident: November 19, 2023 · Filed: July 3, 2024

As I was driving my car in the interstate the car started making noises and began to shake and then it stop driving normally. I did my best to move to the curve and then called a towing truck to get the car. The car transmission stopped working properly. I conducted an analysis on this car in the internet and it has been written that the transmission has a manufacturer's defect. Also, the car dealer did a diagnostics test on the vehicle and proved that the transmission is not responding. The car dealer said the repair is not covered. This car is less than 5 years old. I was driving with an unsafe car. Data indicates that the transmission defects with a transmission fluid leak. I was in a dangerous situation while driving the car in the interstate. There were no warning signs and I believe this can be a dangerous situation for other consumers who may have the same car. The dealer and manufacturer does not want to cover the repair of the transmission since they said there has not been any recalls with the car. I want to put this complaint because I was at risk for something I had no control of. I contacted the corporate office and they told me to take it back to get a second diagnostic. In my opinion I have already done the diagnostic and they will not accept it unless is recent. The diagnostic was done in March 2024. Dealer wants me to pay for the repair. The transmission fluid leak is a problem that appears to be from the manufacturer because a transmission's life should last longer. The car has been undriveable.