2022 Chevrolet Express Recalls & Complaints

Incident: July 2, 2026 · Filed: July 2, 2026

Vehicle was in direct head on accident and air bags were not deployed.

Incident: October 15, 2025 · Filed: October 21, 2025

I have 2023 Jayco Redhawk SE mounted on a Chevy Express 4500 Cutaway chassis with only 5300 miles on it. Chevrolet dealer ran diagnostics and replaced an ABS sensor which had no impact on the problem. I have an appointment to have it looked at by another dealership recommended by Chevy Customer Service. It is not safe to drive, going up straight steep grades on the interstate the right rear wheel keeps locking up under acceleration. Best I can tell the system just starts braking hard on the right rear and maybe both rear wheels even though you are trying to accelerate. It gets worse on steep entrance and exit ramps or steep curvy roads. Almost always when this happens there is traffic following closely at highway speeds (55 to 70 MPH).

Incident: January 12, 2025 · Filed: January 16, 2025

THE VAN HAS A ELECTRICAL ISSUE . ALL THE VAN DOORS UNLOCK AND LOCK.. WHEN I AM DRIVING THE VAN THE LOCKS UNLOCK AND LOCK 5 TIMES IN 2 BLOCKS. WHEN THE VAN IS PARKED AND ENGINE IS OFF AND NO KEY IN THE IGNITION THE LOCKS STILL UNLOCK AND LOCK. I TOOK IT TO MY CHEVY DEALER 3 DAYS AGO TO HAVE THE ELECTRICAL ISSUE DIAGNOSED AND FIXED. MY VAN IS STILL SITTING AT MY CHEVY DEALERSHIP FOR 3 DAYS TODAY JANUARY 16TH 2025 MY VEHICLES STILL HAS NOT BEEN DIAGNOSED YET TO EVEN FIX THE ELECTRICAL DOORS LOCKING SYSTEM

Incident: May 10, 2024 · Filed: September 10, 2024

The contact owns a 2023 Gulf Stream Conquest built on a 2022 Chevrolet Express Chassis. The contact received notification of NHTSA Campaign Number: 23V231000 (Latches/Locks/Linkages, Structure); that was misplaced. The contact stated that the entry door latch had failed, and the door could only be locked or unlocked from the outside. The contact stated that he was physically disabled, and the failure required his wife to exit the RV through the front driver's side door to unlock or to lock the RV entry door. The RV was taken to the local dealer for the recall repair, but the dealer was unable to verify that the RV was covered under the recall. The RV was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 4,000.