NHTSA vehicle safety data

1996 Buick Regal Recalls, Ratings & Complaints

The 1996 Buick Regal has 4 NHTSA recall campaigns and 204 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Buick dealer.

NHTSA recall and complaint data for the 1996 Buick Regal, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

1996 Buick Regal owner complaints

Owners have filed 204 complaints with NHTSA about the 1996 Buick Regal, describing incidents dated October 5, 1995 to July 17, 2019.

Most-cited components

Service Brakes 40 complaints
Engine 37 complaints
Electrical System 24 complaints
Air Bags 21 complaints
Fuel/Propulsion System 19 complaints
Steering 18 complaints

Of the 204 complaints on file, 14 report a crash and 16 a fire; across all 204 complaints, owners report 21 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11265621 · Filed October 2, 2019
ON JULY 17, 2019 AT 8:40AM, I GOT INTO MY CAR IN MY DRIVEWAY. I TURNED THE KEY IN THE IGNITION AND THE AIRBAG EXPLODED. (THE CAR WAS NOT STARTED.) THE AIRBAG SOUNDED LIKE A SHOTGUN BEING FIRED AND A POWDER LIKE SUBSTANCE IMMEDIATELY FILLED THE CAR. THE AIRBAG ITSELF HIT ME IN THE ABDOMINAL AREA. I…
ODI #11088823 · Filed April 18, 2018
TL* THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT STATED THAT THE BRAKE AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT FACILITY FOR DIAGNOSTIC TESTING AND FAILURE CODES: C1265 (REAR ABS MOTOR CIRCUIT SHORTED TO GROUND) AND C1286 (EBCM/EBTCM FAILED TO ILLUMINATE…
ODI #10824631 · Filed February 6, 2016
DRIVERS SIDE DOOR DOES NOT OPEN FROM INSIDE OR OUTSIDE. THE DOOR DOES NOT WORK WITH KEY EITHER. LOCK SEEMS TO WORKING BUT DOOR DOES NOT OPEN. THE CAR ONLY HAS 60,000 MILES ON IT. THIS IS A VERY COMMON PROBLEM WITH THIS CAR AND SHOULD BE A RECALL.

Read all 204 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 1996 Buick Regal in 6 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA02-030: ENGINE COMPARTMENT FIRES
Closed March 9, 2004
- Recall 04V-090
Engineering Analysis EA03-019: POWER RACK AND PINION STEERING FAILURE
Closed December 18, 2003
- Recall 03V-527
Recall Query RQ03-001: POWER RACK AND PINION STEERING FAILURE
Closed September 15, 2003
Preliminary Evaluation PE02-050: ENGINE COMPARTMENT FIRES
Closed October 22, 2002
Engineering Analysis EA99-026: INADVERTENT AIR BAG DEPLOYMENT
Closed December 28, 2001
- Recall 00V-171

1 more NHTSA investigation

Engineering Analysis EA96-023: INAPPROPRIATE AIR BAG DEPLOYMENT
Closed February 13, 1998

Open and recently closed NHTSA defect investigations

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/STEERING GEAR BEARINGS

NHTSA #03V527000 · Steering — Rack and Pinion · NHTSA notice

Reported December 11, 2003 · GENERAL MOTORS CORP.

Potentially affected: 750,283 vehicles

Manufacturer campaign 03062 · Owners notified February 5, 2004 · Vehicles built January 1, 1996 – October 31, 1996 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.

Safety consequence

IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.

Notes

GM RECALL NO. 03062.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Fuel System, Gasoline — Fuel Injection System

NHTSA #96V116000 · NHTSA notice

Reported July 1, 1996 · GENERAL MOTORS CORP.

Potentially affected: 275,811 vehicles

Owners notified July 8, 1996 · Vehicles built July 1, 1995 – May 1, 1996 (per NHTSA)

Defect description

A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.

Safety consequence

THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.

Manufacturer remedy

DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.

Notes

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 3.8L V6 ENGINE. OWNER NOTIFICATION: OWNER NOTIFICATIONS BEGAN DURING JULY 1996. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300; PONTIAC AT 1-800-762-2737; OR OLDSMOBILE AT 1-800-442-6537. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Service Brakes, Hydraulic — Foundation Components — Hoses, Lines/Piping, and Fittings

NHTSA #96V069000 · NHTSA notice

Reported April 19, 1996 · GENERAL MOTORS CORP.

Potentially affected: 43,213 vehicles

Owners notified April 22, 1996 · Vehicles built April 1, 1995 – October 1, 1995 (per NHTSA)

Defect description

THE LEFT FRONT BRAKE LINE CAN CONTACT THE TRANSAXLE MOUNTING BRACKET OR ATTACHMENT BOLT.

Safety consequence

THIS CONDITION CAN CAUSE THE BRAKE LINE TO WEAR THROUGH, RESULTING IN LOSS OF BRAKE FLUID AND EVENTUAL LOSS OF ONE-HALF OF THE VEHICLE'S BRAKE SYSTEM, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Manufacturer remedy

DEALERS WILL INSPECT THE VEHICLE FOR PROPER BRAKE LINE CLEARANCE AND REPOSITION THOSE BRAKE LINES FOUND TO HAVE LESS THAN MINIMAL CLEARANCE. ADDITIONALLY, THOSE BRAKE LINES FOUND TO HAVE AN INDENTATION CAUSED BY THE CONTACT WILL BE REPLACED AND PROPERLY ROUTED.

Notes

SYSTEM: BRAKES; HYDRAULIC; LINES.VEHICLE DESCRIPTION: PASSENGER VEHICLES. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR BUICK AT 1-800-521-7300. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

1996 Buick Regal 2-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 3

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

6 investigations

204 owner complaints have been filed with NHTSA for the 1996 Buick Regal.

Air Bags

ODI #11265621

1 injury

Incident: July 17, 2019 · Filed: October 2, 2019

ON JULY 17, 2019 AT 8:40AM, I GOT INTO MY CAR IN MY DRIVEWAY. I TURNED THE KEY IN THE IGNITION AND THE AIRBAG EXPLODED. (THE CAR WAS NOT STARTED.) THE AIRBAG SOUNDED LIKE A SHOTGUN BEING FIRED AND A POWDER LIKE SUBSTANCE IMMEDIATELY FILLED THE CAR. THE AIRBAG ITSELF HIT ME IN THE ABDOMINAL AREA. I FOUND THE DOOR HANDLE, OPENED THE DOOR, AND ROLLED OUT OF THE CAR ONTO THE GROUND. AT THIS TIME, I YELLED FOR MY SON. MY SON PICKED ME UP OFF THE GROUND AND CALLED AN AMBULANCE DUE TO ME BEING IN A SEVERE AMOUNT OF PAIN AND IN SHOCK. I WAS TAKEN TO THE HOSPITAL VIA AMBULANCE AND OBSERVED FOR THE REMAINDER OF THE DAY. I HAD SEVERAL FOLLOW-UP APPOINTMENTS THAT CONTINUE TO THIS DAY. INSURANCE CAME TO LOOK AT CAR, FILLED OUT PAPERWORK, AND SAID THEY WERE GOING TO TOTAL THE VEHICLE. THE CAR HAS NOT BEEN MOVED SINCE THIS INCIDENT.

Electrical System; Service Brakes

ODI #11088823

Incident: April 2, 2018 · Filed: April 18, 2018

TL* THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT STATED THAT THE BRAKE AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT FACILITY FOR DIAGNOSTIC TESTING AND FAILURE CODES: C1265 (REAR ABS MOTOR CIRCUIT SHORTED TO GROUND) AND C1286 (EBCM/EBTCM FAILED TO ILLUMINATE THE RED BRAKE WARNING INDICATOR) WERE LOCATED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO THE DEALER (DON BROWN CHEVROLET, 2244 S KINGS HIGHWAY BLVD, ST. LOUIS, MO 63110, (314) 282-7887) WHERE IT WAS DETERMINED THAT THE CODES INDICATED THAT THERE WAS A REAR MOTOR SHORT TO THE GROUND AND THE ELECTRIC BRAKE CONTROL MODULE ACTIVATED THE BRAKE WARNING INDICATORS. FURTHER DIAGNOSTIC TESTING WOULD BE PERFORMED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

Structure

ODI #10824631

Incident: February 5, 2016 · Filed: February 6, 2016

DRIVERS SIDE DOOR DOES NOT OPEN FROM INSIDE OR OUTSIDE. THE DOOR DOES NOT WORK WITH KEY EITHER. LOCK SEEMS TO WORKING BUT DOOR DOES NOT OPEN. THE CAR ONLY HAS 60,000 MILES ON IT. THIS IS A VERY COMMON PROBLEM WITH THIS CAR AND SHOULD BE A RECALL.

Service Brakes; Engine; Fuel/Propulsion System

ODI #10786585

Fire

Incident: October 15, 2015 · Filed: October 28, 2015

WHILE MERGING ONTO THE FREEWAY, I WAS TAKING MY CAR TO BE SMOGGED. AT SPEED, I NOTICED A LITTLE WHITE PUFF OF SMOKE EMIT FROM THE RIGHT SIDE OF THE ENGINE BAY. AS I PROCEEDED TO START MOVING TO THE SHOULDER, THIS PUFF HAD TURNED INTO A GRAY PLUME. AS I FINALLY REACHED THE SHOULDER, THE ENTIRE FRONT OF THE ENGINE BAY WAS BILLOWING BLACK SMOKE. AS I TRIED TO STOP, THE BRAKE PEDAL WENT TO THE FLOOR, SO IT SEEMED THE FIRE HAD BURNT THROUGH A BRAKE LINE. I MANAGED TO ENGAGE THE EMERGENCY BRAKE SLOWLY AND MANAGED TO STOP ON THE SHOULDER. OPENING THE HOOD, I FOUND A SMALL FIRE BURNING AT THE REAR OF THE ENGINE, BUT IN FRONT OF THE FIREWALL. I HAD NOTHING WITH ME, SO I CALLED THE FIRE DEPARTMENT AND IT WAS EXTINGUISHED. HOWEVER, BY THE TIME THEY GOT THERE, THE ENTIRE ENGINE COMPARTMENT WAS TOTALED BEYOND EXTENSIVE REPAIR.

Engine; Fuel/Propulsion System

ODI #10703743

Fire

Incident: March 3, 2015 · Filed: April 4, 2015

MY CAR STARTED TO NOT START AFTER BEING DRIVEN AND SHORTLY AFTER DID NOT WANT TO START IN A SIMPLE IDLE. SOMEHOW FUEL HAS BEEN GETTING TRAPPED IN A PRESSURIZED LINE AND I'M HAVING TO RELEASE THE FUEL OUT. OIL LEAKED INTO THE SPARK PLUGS CAUSED A PILOT FLAME. I HAVE READ MULTIPLE ACCOUNTS OF THIS HAPPENING TO THAT SPECIFIC MAKE AND YEAR AS WELL A FEW OF THE OTHER 90 MODELS. EVERY ACCOUNT SAYS IT IS A FLAW IN THE ENGINE AND FUEL SYSTEM. *TR

Steering

ODI #10660661

Crash

Incident: February 2, 2015 · Filed: February 3, 2015

1996 BUICK REGAL. CONSUMER STATED THE POWER STEERING WAS NOT CRIMPED PROPERLY. THE BALL BEARING WENT THROUGH THE GEAR BOX WHICH CAUSED THE DRIVER TO LOSE CONTROL OF THE VEHICLE AND CRASHED. THE CONSUMER DISCOVERED THERE WAS A RECALL, ON THE STEERING. HOWEVER, HE WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. *JB

Air Bags

ODI #10463618

Incident: June 29, 2012 · Filed: June 29, 2012

TL* THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT STATED THAT AS THE VEHICLE WAS STARTED, THE AIR BAGS DEPLOYED ERRONEOUSLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 55,035.

Air Bags

ODI #10344035

1 injury

Incident: July 17, 2010 · Filed: July 19, 2010

TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH, WEN THE FRONT DRIVER SIDE AIR BAG DEPLOYED INADVERTENTLY WITHOUT IMPACT TO THE VEHICLE. THE CONTACT SUSTAINED ABRASIONS TO THE LEFT FOREARM. THE VEHICLE WAS DRIVEN WITH CAUTION TO HIS RESIDENCE. THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 182,000. UPDATED 10/20/10 *BF UPDATED 10/26/10*JB

Engine and Engine Cooling

ODI #10321739

Fire

Incident: February 23, 2010 · Filed: March 24, 2010

TL* THE CONTACT OWNS A 1996 BUICK REGAL LE. THE CONTACT STATED THERE WAS AN UNUSUAL LOUD EXPLOSION IMMEDIATELY AFTER THE VEHICLE WAS STARTED. SHE OPENED THE HOOD TO FURTHER INVESTIGATE AND WAS EXHUMED WITH THICK SMOKE EMITTING FROM THE ENGINE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DISCOVERED THAT THE TOP MANIFOLD MELTED. THE MECHANIC REPLACED THE MANIFOLD, INJECTORS, SENSOR WIRES, PCV VALVES, AND HOSES. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE APPROXIMATE CURRENT MILEAGE WAS 130,000.

Engine and Engine Cooling

ODI #10314670

Fire

Incident: February 16, 2010 · Filed: February 26, 2010

ON ENGINE START, LOUD EXPLOSION IN ENGINE COMPARTMENT. INSPECTION REVELED ENGINE COVER BROKEN, UPPER INTAKE MANIFOLD (PLENUM) SPLIT IN TWO PIECES. SMELL OF GAS, BROKEN VACUUM AND FUEL LINES. MUST REPLACE UPPER INTAKE MANIFOLD, FUEL RAIL, 2 INJECTORS, VARIOUS LINES. OLD PARTS ARE AVAILABLE. *TR

Other Buick Regal model years

Check your 1996 Buick Regal VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Buick Regal at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Buick VIN