NHTSA vehicle safety data

2007 BMW R1200 GS Recalls & Complaints

The 2007 BMW R1200 GS has 7 NHTSA recall campaigns and 42 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

Includes campaigns NHTSA files under the spelling "R 1200 GS".

NHTSA recall and complaint data for the 2007 BMW R1200 GS. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 BMW R1200 GS owner complaints

Owners have filed 42 complaints with NHTSA about the 2007 BMW R1200 GS, describing incidents dated September 10, 2008 to October 8, 2021.

Most-cited components

Fuel/Propulsion System 24 complaints
Service Brakes 10 complaints
Power Train 4 complaints
Engine 3 complaints
Air Bags 1 complaint
Electrical System 1 complaint

Of the 42 complaints on file, 3 report a crash; across all 42 complaints, owners report 3 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11436242 · Filed October 10, 2021
When starting the bike, suddenly fuel started dripping down onto the front wheel and onto the exhaust. I noticed the fuel on the suction side (right side) of the gas tank pooling up and spraying out. Upon disassembly, the male 90 degree fuel quick disconnect (replacement part number BMW 13537674765)…
ODI #11363262 · Filed October 7, 2020
DRIVE SHAFT FAILURE WHICH TOOK OUT THE SWING ARM WHILE DOING SPEED OF 35-45 MPH ON BACK COUNTRY ROAD. IF ON HIGHWAY OR INCREASES SPEED, INCIDENT MAY CAUSE LOSS OF LIFE
ODI #11361069 · Filed September 25, 2020
THE FUEL PUMP ON THE MOTORCYCLE IS LEAKING AND SPRAYING GAS ALL OVER ME WHEN I DRIVE

Read all 42 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2007 BMW R1200 GS in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA13-006: Fuel Leak - Motorycle
Closed January 31, 2014
- Recall 13V-617
Preliminary Evaluation PE12-036: Fuel Leak - Motorcycle
Closed July 22, 2013

Open and recently closed NHTSA defect investigations

Fuel Pump Flange may Leak

NHTSA #20V471000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 10, 2020 · BMW of North America, LLC

Potentially affected: 16,926 vehicles

Repair completion: 58.36% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 18, 2021

Defect description

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Safety consequence

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Manufacturer remedy

BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Accessory Turn Signals Non-Compliant/FMVSS 108

NHTSA #17E052000 · Exterior Lighting — Turn Signal · NHTSA notice

Reported August 21, 2017 · BMW of North America, LLC

Potentially affected: 9,000 vehicles

Repair completion: 0.39% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified October 25, 2017

Defect description

BMW of North America, LLC (BMW) is recalling certain accessory turn signals manufactured for 2006-2017 R1200GS, 2007-2008 and 2010-2017 R1200GS Adventure, 2017 F700GS and F800GS, 2013-2017 F800GT, 2015-2016 F800R, 2014-2017 F800GS Adventure, 2014-2016 S1000R, 2015-2017 R1200R, 2016-2017 R1200RS, and 2010-2017 S1000RR motorcycles. As designed, these accessory turn signals may be insufficiently visible to other drivers, and, as such, fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Safety consequence

If other drivers cannot easily see the turn signals, there would be an increased risk of a crash.

Manufacturer remedy

BMW will notify owners, and dealers will replace the turn signals, free of charge. The recall began October 25, 2017. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Rear Wheel Mounting Flange may Crack

NHTSA #15V141000 · Wheels — Lugs/Nuts/Bolts/Studs · NHTSA notice

Reported March 11, 2015 · BMW of North America, LLC

Potentially affected: 43,426 vehicles

Repair completion: 60.91% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified May 7, 2015 · Vehicles built January 6, 2004 – April 1, 2010 (per NHTSA)

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2010 R1200GS and R1200RT, 2006-2010 R1200GS Adventure, 2007-2010 R1200R, 2007 R1200S and K1200R Sport, 2005-2007 R1200ST, 2008-2009 HP2 Megamoto, 2006 HP2 Enduro, 2008-2010 HP2 Sport, 2005-2008 K1200S, 2006-2008 K1200R, K1200GT, 2009-2011 K1300S, 2010-2011 K1300R, and 2009-2010 K1300GT motorcycles. In the affected motorcycles, the rear wheel mounting flange may crack if the rear wheel mounting bolts are over tightened.

Safety consequence

If the rear wheel mounting flange cracks, the mounting bolts may loosen and the rear wheel may not remain secured to the motorcycle, causing a loss of stability and increasing the risk of a crash.

Manufacturer remedy

BMW will notify owners, and dealers will replace the existing aluminum rear wheel flange with a steel one, free of charge. The recall began on May 7, 2015. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fuel Pump Flange may Leak

NHTSA #13V617000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported December 12, 2013 · BMW of North America, LLC

Potentially affected: 50,184 vehicles

Repair completion: 59.33% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified April 16, 2014 · Vehicles built January 6, 2004 – March 30, 2011 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.

Safety consequence

A fuel leak in the presence of an ignition source may result in a fire.

Manufacturer remedy

BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FRONT BRAKE LINES

NHTSA #10V276000 · Service Brakes, Hydraulic · NHTSA notice

Reported June 18, 2010 · BMW OF NORTH AMERICA, LLC

Potentially affected: 15,532 vehicles

Owners notified September 20, 2010

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 R 1200 AND K 1200 SERIES MOTORCYCLES MANUFACTURED FROM AUGUST 2006 THROUGH MAY 2009. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, AND THEREFORE ASSOCIATED VIBRATION. THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINE COULD SPLIT AND START TO DEVELOP A LEAK.

Safety consequence

IF THIS GOES UNNOTICED, AND THE BRAKE FLUID RESERVOIR RUNS EMPTY, THE FRONT BRAKES COULD FAIL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND DEALERS WILL INSTALL NEW BRAKE LINES, CONTAINING A "SLEEVE" ALONG A PORTION OF THE LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 20, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FUEL PUMP CONTROL UNIT CORRISION

NHTSA #09V319000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 7, 2009 · BMW OF NORTH AMERICA, LLC

Potentially affected: 4,839 vehicles

Owners notified November 9, 2009 · Vehicles built August 1, 2006 – January 31, 2008 (per NHTSA)

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 R1200 GS MOTORCYCLES MANUFACTURED BETWEEN AUGUST 2006 AND JANUARY 2008. THE SEALING OF THE FUEL PUMP CONTROL UNIT HOUSING MIGHT BE INSUFFICIENT AND WATER COULD INTRUDE INTO THE CONTROL UNIT HOUSING CREATING A HUMID ATMOSPHERE. UNDER SUCH CONDITIONS, THE FUEL PUMP COULD CORRODE AND THEN FAIL.

Safety consequence

FAILURE OF THE FUEL PUMP WILL CAUSE INADEQUATE FUEL TO REACH THE ENGINE AND CAUSE THE ENGINE TO STOP RUNNING. A LOSS OF ENGINE POWER WITHOUT WARNING COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMP CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

FRONT BRAKE LINES

NHTSA #08V254000 · Service Brakes, Hydraulic — Foundation Components — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported June 5, 2008 · BMW OF NORTH AMERICA, LLC

Potentially affected: 4,922 vehicles

Owners notified August 1, 2008 · Vehicles built July 6, 2006 – July 6, 2007 (per NHTSA)

Defect description

BMW IS RECALLING 4,922 MY 2007-2008 R1200R, MY 2006-2007 R1200 GS, MY 2007 R1200 ST, AND MY 2008 R1200 GS ADVENTURE MOTORCYCLES. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINES COULD SPLIT AND START TO DEVELOP A LEAK. IF THE LEAK BECAME SIGNIFICANT, BRAKE FLUID COULD ESCAPE. IF THIS HAPPENED, THE LEVEL OF FLUID IN THE RESERVOIR OF THE FRONT BRAKE SYSTEM COULD DROP.

Safety consequence

IF FLUID LEVEL DROPS SIGNIFICANTLY, THE FRONT BRAKES COULD FAIL INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND INSTALL NEW BRAKE LINES WITH A MODIFIED ROUTING FREE OF CHARGE. THE RECALL BEGAN DURING AUGUST 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2007 BMW R1200 GS. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

42 owner complaints have been filed with NHTSA for the 2007 BMW R1200 GS.

Fuel/Propulsion System

ODI #11436242

Incident: October 8, 2021 · Filed: October 10, 2021

When starting the bike, suddenly fuel started dripping down onto the front wheel and onto the exhaust. I noticed the fuel on the suction side (right side) of the gas tank pooling up and spraying out. Upon disassembly, the male 90 degree fuel quick disconnect (replacement part number BMW 13537674765) came apart when trying to release the hose from the female coupling. Replacing the connector and the clamp resolved the issue and fuel is no longer leaking. The last time this area was serviced was in 2014 when one of the other fuel tank recalls was completed and a reinforcement ring was installed on the flange at this location to prevent the flange itself from cracking, but in this instance it was the fitting itself. Called BMW motorcycles or Jacksonville (Florida ) and they indicated there is no warranty / recall/ service bulletin for this repair and I was able to purchase the part and perform the replacement.

Suspension; Power Train

ODI #11363262

Crash 2 injuries

Incident: August 28, 2020 · Filed: October 7, 2020

DRIVE SHAFT FAILURE WHICH TOOK OUT THE SWING ARM WHILE DOING SPEED OF 35-45 MPH ON BACK COUNTRY ROAD. IF ON HIGHWAY OR INCREASES SPEED, INCIDENT MAY CAUSE LOSS OF LIFE

Fuel/Propulsion System

ODI #11361069

Incident: September 5, 2020 · Filed: September 25, 2020

THE FUEL PUMP ON THE MOTORCYCLE IS LEAKING AND SPRAYING GAS ALL OVER ME WHEN I DRIVE

Fuel/Propulsion System

ODI #11309054

Incident: February 12, 2020 · Filed: February 13, 2020

AFTER STARTING THE BIKE AND ALLOWING IT TO WARM UP, I NOTICED A LARGE PUDDLE FORMING UNDER THE FRONT OF THE BIKE. UPON CLOSER INSPECTION I FOUND THE FUEL LINE QUICK CONNECT TO THE FUEL PUMP HAD SPLIT AND SPRAYING FUEL WHEN UNDER PRESSURE. THIS WAS DRIPPING DOWN ONTO THE HOT HEADER.

Unknown or Other

ODI #11266390

Incident: July 10, 2019 · Filed: October 3, 2019

DO NUMBENOT R, INCLUDE VEHICLE ANY IDENTIFICATION PERSONAL NUMBER INFORMATION (VIN), ETC ... ). L SECURITY/DRIVER LICENSE THE RECALL FUEL FOR THIS PUMP ISSUE, RUPTURED BUT AND BMW BEGAN FEELS THAT SHOOTING IF THEY GASOLINE REPLACED ALL THE OVER FLANGE, MY LEG THERE AS I IS WAS NO NEED RIDING TO HOME. REPLACE THE APPARENTLY PUMP THERE AND IS THEY AN HAVE EXISTING HOME. SATISFIED THE RECALL. THE RECALL WAS ISSUED IN 2014 AS RECALL 13V-617. MY LEFT LEG WAS SOAKED IN GASOLINE BY THE TIME I GOT HOME. *BF 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

Fuel/Propulsion System

ODI #11153312

Incident: August 1, 2016 · Filed: November 23, 2018

TL* THE CONTACT OWNS A 2007 BMW R1200 GS MOTORCYCLE. THE CONTACT STATED THAT THE FUEL STRIP FRACTURED AND HAD TO BE REPLACED MORE THAN THREE TIMES BY MORTON'S BMW MOTORCYCLES (540-891-9844, LOCATED AT 5099A JEFFERSON DAVIS HIGHWAY, FREDERICKSBURG, VIRGINIA 22408). THE DEALER STATED THAT THEY WOULD REPLACE THE FUEL STRIP PER SERVICE INFORMATION BULLETIN: 1600214(17) REGARDING THE FUEL STRIP BMW EXTENDED WARRANTY CAMPAIGN. THE MOTORCYCLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V617000 (FUEL SYSTEM, GASOLINE) AND TWO TSBS WERE ISSUED BY THE MANUFACTURER FOR THE FUEL SYSTEM. THE MANUFACTURER WAS CONTACTED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

Fuel/Propulsion System

ODI #10917633

Incident: October 2, 2016 · Filed: October 20, 2016

TL* THE CONTACT OWNS A 2007 BMW R1200 GS MOTORCYCLE. WHILE THE VEHICLE WAS AT A STOP SIGN, THERE WAS AN ODOR OF FUEL AROUND THE VEHICLE. THE CONTACT LOOKED DOWN AND NOTICED FUEL ON HIS LEG, WHICH DRIPPED DOWN THE LEFT SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A CROCK FLANGE ON THE FUEL PUMP THAT NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 8,000.

Fuel System, Gasoline

ODI #10897569

Incident: August 19, 2016 · Filed: August 22, 2016

TL* THE CONTACT OWNS A 2007 BMW R 1200 GS ADVENTURE. WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS AN ODOR OF FUEL AND FUEL FUEL LEAKED ON THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 13V617000 (FUEL SYSTEM, GASOLINE), BUT THE REMEDY FAILED TO REPAIR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 26,000. THE VIN WAS NOT AVAILABLE. UPDATED 10/21/16*LJ *TR

Service Brakes

ODI #10864676

Incident: May 8, 2016 · Filed: May 12, 2016

BRAKE FAILURE WARNING, NO SPEEDOMETER, NO BRAKE LIGHTS, NO ODOMETER, BATTERY DIES. THE ABS UNIT HAS FAILED HAPPENED UPON KEY ON WITHOUT STARTING VEHICLE.

Fuel/Propulsion System

ODI #10775889

Incident: September 23, 2015 · Filed: September 24, 2015

FUEL PRESSURE CONTROL MODULE FAILED WITHOUT WARNING LEAVING ME STRANDED IN THE MIDDLE OF THE ROADWAY.

Other BMW R1200 GS model years

Check your 2007 BMW R1200 GS VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW R1200 GS at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN