NHTSA vehicle safety data

2006 BMW R1200 GS Recalls & Complaints

The 2006 BMW R1200 GS has 10 NHTSA recall campaigns and 9 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

Includes campaigns NHTSA files under the spelling "R 1200 GS".

NHTSA recall and complaint data for the 2006 BMW R1200 GS. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 BMW R1200 GS owner complaints

Owners have filed 9 complaints with NHTSA about the 2006 BMW R1200 GS, describing incidents dated September 26, 2008 to August 26, 2020.

Most-cited components

Fuel/Propulsion System 6 complaints
Wheels 2 complaints
Service Brakes 1 complaint
Suspension 1 complaint

Newest complaints

ODI #11353005 · Filed September 3, 2020
TL* THE CONTACT OWNS A 2006 BMW R-1200 GS. THE CONTACT STATED THAT UPON START OF THE MOTORCYCLE, HE NOTICED THAT FUEL BEGAN TO SPEW OUT OF HIS MOTORCYCLE. THE CONTACT CALLED WAGNER MOTORSPORTS (700 PLANTATION ST, WORCESTER, MA 01605) WHERE HE WAS INFORMED THAT HE WOULD HAVE TO BRING IN THE…
ODI #10652059 · Filed November 3, 2014
TL* THE CONTACT OWNS A 2006 BMW R 1200 GS. THE CONTACT STATED THAT THE REAR WHEEL CARRIER WAS FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FLANGE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE…
ODI #10578505 · Filed April 9, 2014
THE REAR WHEEL ASSEMBLY/SWINGARM IS DESCRIBED BY BMW AS "MAINTENANCE FREE," MEANING THAT THE OIL LEVEL IN THE REAR SWING-ARM CANNOT BE CHECKED OR REFILLED. MY MOTORCYCLE HAS DEVELOPED AN OIL LEAK FROM SAID ASSEMBLY, AND HAS BEEN SLOWLY LEAKING FOR THE LAST 10,000+ MILES. IF THE OIL LEVEL DROPS LOW…

Read all 9 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2006 BMW R1200 GS in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA13-006: Fuel Leak - Motorycle
Closed January 31, 2014
- Recall 13V-617
Preliminary Evaluation PE12-036: Fuel Leak - Motorcycle
Closed July 22, 2013

Open and recently closed NHTSA defect investigations

Fuel Pump Flange may Leak

NHTSA #20V471000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 10, 2020 · BMW of North America, LLC

Potentially affected: 16,926 vehicles

Repair completion: 58.36% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 18, 2021

Defect description

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Safety consequence

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Manufacturer remedy

BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Accessory Turn Signals Non-Compliant/FMVSS 108

NHTSA #17E052000 · Exterior Lighting — Turn Signal · NHTSA notice

Reported August 21, 2017 · BMW of North America, LLC

Potentially affected: 9,000 vehicles

Repair completion: 0.39% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified October 25, 2017

Defect description

BMW of North America, LLC (BMW) is recalling certain accessory turn signals manufactured for 2006-2017 R1200GS, 2007-2008 and 2010-2017 R1200GS Adventure, 2017 F700GS and F800GS, 2013-2017 F800GT, 2015-2016 F800R, 2014-2017 F800GS Adventure, 2014-2016 S1000R, 2015-2017 R1200R, 2016-2017 R1200RS, and 2010-2017 S1000RR motorcycles. As designed, these accessory turn signals may be insufficiently visible to other drivers, and, as such, fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Safety consequence

If other drivers cannot easily see the turn signals, there would be an increased risk of a crash.

Manufacturer remedy

BMW will notify owners, and dealers will replace the turn signals, free of charge. The recall began October 25, 2017. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Rear Wheel Mounting Flange may Crack

NHTSA #15V141000 · Wheels — Lugs/Nuts/Bolts/Studs · NHTSA notice

Reported March 11, 2015 · BMW of North America, LLC

Potentially affected: 43,426 vehicles

Repair completion: 60.91% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified May 7, 2015 · Vehicles built January 6, 2004 – April 1, 2010 (per NHTSA)

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2010 R1200GS and R1200RT, 2006-2010 R1200GS Adventure, 2007-2010 R1200R, 2007 R1200S and K1200R Sport, 2005-2007 R1200ST, 2008-2009 HP2 Megamoto, 2006 HP2 Enduro, 2008-2010 HP2 Sport, 2005-2008 K1200S, 2006-2008 K1200R, K1200GT, 2009-2011 K1300S, 2010-2011 K1300R, and 2009-2010 K1300GT motorcycles. In the affected motorcycles, the rear wheel mounting flange may crack if the rear wheel mounting bolts are over tightened.

Safety consequence

If the rear wheel mounting flange cracks, the mounting bolts may loosen and the rear wheel may not remain secured to the motorcycle, causing a loss of stability and increasing the risk of a crash.

Manufacturer remedy

BMW will notify owners, and dealers will replace the existing aluminum rear wheel flange with a steel one, free of charge. The recall began on May 7, 2015. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fuel Pump Flange may Leak

NHTSA #13V617000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported December 12, 2013 · BMW of North America, LLC

Potentially affected: 50,184 vehicles

Repair completion: 59.33% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified April 16, 2014 · Vehicles built January 6, 2004 – March 30, 2011 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.

Safety consequence

A fuel leak in the presence of an ignition source may result in a fire.

Manufacturer remedy

BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1-800-525-7417 or email BMW at [email protected].

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

FUEL PUMP CONTROL UNIT CORRISION

NHTSA #09V319000 · Fuel System, Gasoline — Delivery — Fuel Pump · NHTSA notice

Reported August 7, 2009 · BMW OF NORTH AMERICA, LLC

Potentially affected: 4,839 vehicles

Owners notified November 9, 2009 · Vehicles built August 1, 2006 – January 31, 2008 (per NHTSA)

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 R1200 GS MOTORCYCLES MANUFACTURED BETWEEN AUGUST 2006 AND JANUARY 2008. THE SEALING OF THE FUEL PUMP CONTROL UNIT HOUSING MIGHT BE INSUFFICIENT AND WATER COULD INTRUDE INTO THE CONTROL UNIT HOUSING CREATING A HUMID ATMOSPHERE. UNDER SUCH CONDITIONS, THE FUEL PUMP COULD CORRODE AND THEN FAIL.

Safety consequence

FAILURE OF THE FUEL PUMP WILL CAUSE INADEQUATE FUEL TO REACH THE ENGINE AND CAUSE THE ENGINE TO STOP RUNNING. A LOSS OF ENGINE POWER WITHOUT WARNING COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND REPLACE THE FUEL PUMP CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT BRAKE LINES

NHTSA #08V254000 · Service Brakes, Hydraulic — Foundation Components — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported June 5, 2008 · BMW OF NORTH AMERICA, LLC

Potentially affected: 4,922 vehicles

Owners notified August 1, 2008 · Vehicles built July 6, 2006 – July 6, 2007 (per NHTSA)

Defect description

BMW IS RECALLING 4,922 MY 2007-2008 R1200R, MY 2006-2007 R1200 GS, MY 2007 R1200 ST, AND MY 2008 R1200 GS ADVENTURE MOTORCYCLES. DUE TO THE CURRENT ROUTING OF THE FRONT BRAKE LINES, IT IS POSSIBLE THAT DURING RIDING, THE BRAKE LINES COULD BE UNDER STRAIN. IF THE VIBRATION/STRAIN IS SIGNIFICANT, THE BRAKE LINES COULD SPLIT AND START TO DEVELOP A LEAK. IF THE LEAK BECAME SIGNIFICANT, BRAKE FLUID COULD ESCAPE. IF THIS HAPPENED, THE LEVEL OF FLUID IN THE RESERVOIR OF THE FRONT BRAKE SYSTEM COULD DROP.

Safety consequence

IF FLUID LEVEL DROPS SIGNIFICANTLY, THE FRONT BRAKES COULD FAIL INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND INSTALL NEW BRAKE LINES WITH A MODIFIED ROUTING FREE OF CHARGE. THE RECALL BEGAN DURING AUGUST 2008. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

CROSS-SPOKE WHEEL WITH TPM

NHTSA #06V486000 · Tires — Valve · NHTSA notice

Reported December 21, 2006 · BMW OF NORTH AMERICA, LLC

Potentially affected: 144 vehicles

Owners notified January 12, 2007 · Vehicles built September 6, 2006 – October 13, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, THE TIRE INFLATION VALVE HOLE IN THE RIM OF THE CROSS-SPOKE WHEEL WHICH IS EQUIPPED WITH THE OPTIONAL TIRE PRESSURE MONITORING SYSTEM (TPM) WAS INCORRECTLY MANUFACTURED. A LEAK MAY DEVELOP AT THIS LOCATION POSSIBLY CAUSING SUDDEN DEFLATION OF THE TIRE.

Safety consequence

IF THIS HAPPENED, MOTORCYCLE HANDLING AND CONTROL WOULD BE COMPROMISED, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL TEMPORARILY DEACTIVATE THE TPM SYSTEM, REMOVE THE CORRESPONDING VALVES AND INTEGRAL TPM SENSORS, AND THEN REPLACE THEM WITH STANDARD VALVES. WHEN A PERMANENT REPAIR IS AVAILABLE, OWNERS WILL BE NOTIFIED TO BRING THEIR VEHICLES IN FOR REACTIVATION OF THE TPM SYSTEM AND REPLACEMENT OF THE INTEGRAL TPM SENSORS AND VALVES. THE RECALL BEGAN ON JANUARY 12, 2007. OWNERS MAY CONTACT BMW AT 1-800-331-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

ABS INTERVENTION

NHTSA #06V164000 · Service Brakes, Hydraulic — Antilock/Traction Control/Electronic Limited Slip · NHTSA notice

Reported May 15, 2006 · BMW OF NORTH AMERICA, LLC

Potentially affected: 13,200 vehicles

Owners notified June 5, 2006 · Vehicles built January 1, 2004 – February 28, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, UNDER RAPID, REPEATED, AND UNUSUALLY HARSH BRAKING, LOSS OF ABS CAPABILITY COULD TEMPORARILY OCCUR.

Safety consequence

TEMPORARY LOSS OF ABS BRAKING COULD INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL ADD A PHYSICAL RESTRICTION, IN THE FORM OF A BANJO BOLT WITH A FLOW RESTRICTOR TO THE BRAKE LINE, AND ON CERTAIN MODELS DEALERS WILL INSTALL NEW FRONT BRAKE DISCS OF A SLIGHTLY LARGER THICKNESS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006, AND WILL BE A PHASED MAILING THROUGH OCTOBER 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT ABS SENSOR CABLE ROUTING

NHTSA #06V134000 · Service Brakes, Hydraulic · NHTSA notice

Reported April 24, 2006 · BMW OF NORTH AMERICA, LLC

Potentially affected: 9,260 vehicles

Owners notified June 5, 2006 · Vehicles built January 1, 2004 – February 28, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, IF CERTAIN PROCEDURES ARE PERFORMED THAT INVOLVES REMOVAL OF THE FRONT LEFT BRAKE CALIPER, THE ABS SENSOR CABLE CAN BE ROUTED INCORRECTLY AND WHEN THE CALIPER IS REINSTALLED, THE SENSOR CABLE CAN COME INTO CONTACT AND RUB AGAINST THE FRONT BRAKE DISC. OVERTIME, IF THE CHAFING BECOMES SEVERE, IT IS POSSIBLE TO LOSE THE ABS FUNCTION.

Safety consequence

LOSS OF ABS FUNCTION COULD INCREASE THE RISK OF A CRASH DURING CERTAIN RIDING CONDITIONS.

Manufacturer remedy

DEALERS WILL ATTACH ADDITIONAL RETAINING CLIPS FREE OF CHARGE TO THE ABS SENSOR CABLE, WHICH WILL PROVIDE A MORE SECURE CONNECTION TO THE WHEEL CARRIER. THE RECALL BEGAN ON JUNE 5, 2006, AND WILL BE A PHASED MAILING THROUGH OCTOBER 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

CLUTCH COMPONENT

NHTSA #06V104000 · Power Train — Clutch Assembly · NHTSA notice

Reported April 4, 2006 · BMW OF NORTH AMERICA, LLC

Potentially affected: 453 vehicles

Owners notified April 20, 2006 · Vehicles built January 20, 2006 – January 24, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTORCYCLES, THE CLUTCH COMPONENTS COULD BECOME LOOSE WHILE THE MOTORCYCLE IS BEING OPERATED.

Safety consequence

IF THIS HAPPENED, THE COMPONENTS COULD EXIT THROUGH THE ENGINE CASTING INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSTALL NEW CLUTCH COMPONENTS FREE OF CHARGE. ALL MOTORCYCLES ARE LOCATED AT DEALERS. NO MOTORCYCLES HAVE BEEN SOLD TO CUSTOMERS.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2006 BMW R1200 GS. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

9 owner complaints have been filed with NHTSA for the 2006 BMW R1200 GS.

Fuel System, Gasoline

ODI #11353005

Incident: August 26, 2020 · Filed: September 3, 2020

TL* THE CONTACT OWNS A 2006 BMW R-1200 GS. THE CONTACT STATED THAT UPON START OF THE MOTORCYCLE, HE NOTICED THAT FUEL BEGAN TO SPEW OUT OF HIS MOTORCYCLE. THE CONTACT CALLED WAGNER MOTORSPORTS (700 PLANTATION ST, WORCESTER, MA 01605) WHERE HE WAS INFORMED THAT HE WOULD HAVE TO BRING IN THE MOTORCYCLE FOR INSPECTION. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE AND THEY INFORMED HIM TO TAKE THE MOTORCYCLE TO A DEALER TO BE SERVICED. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 13V617000 (FUEL SYSTEM, GASOLINE) WHICH HE LINKED TO HIS FAILURE. NEITHER THE DEALER NOR THE MANUFACTURER NOTIFIED THE CONTACT WHETHER HIS MOTORCYCLE WAS INCLUDED IN THE RECALL. THE VIN TOOL SHOWED THAT THE MOTORCYCLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 22,000.

Wheels

ODI #10652059

Incident: June 13, 2014 · Filed: November 3, 2014

TL* THE CONTACT OWNS A 2006 BMW R 1200 GS. THE CONTACT STATED THAT THE REAR WHEEL CARRIER WAS FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FLANGE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

Suspension; Wheels

ODI #10578505

Incident: February 17, 2010 · Filed: April 9, 2014

THE REAR WHEEL ASSEMBLY/SWINGARM IS DESCRIBED BY BMW AS "MAINTENANCE FREE," MEANING THAT THE OIL LEVEL IN THE REAR SWING-ARM CANNOT BE CHECKED OR REFILLED. MY MOTORCYCLE HAS DEVELOPED AN OIL LEAK FROM SAID ASSEMBLY, AND HAS BEEN SLOWLY LEAKING FOR THE LAST 10,000+ MILES. IF THE OIL LEVEL DROPS LOW ENOUGH, I FEAR THE REAR WHEEL COULD LOCK WHILE RIDING, RESULTING IN A CRASH. *TR

Fuel/Propulsion System

ODI #10535545

Incident: August 12, 2013 · Filed: August 15, 2013

WITH TURNING ON THE KEY, FUEL LEAKED OUT OF THE LEFT SIDE OF THE MOTORCYCLE. THE LEAK COMES FROM THE FUEL LINE ATTACHMENT TO THE FUEL PUMP MOUNT ON THE LEFT SIDE OF THE FUEL TANK. THE FUEL SPRAYS OUT OF THE PLASTIC FUEL PUMP MOUNT WHEN THE KEY IS TURNED ON. THE PLASTIC CONNECTION IN THE FUEL LINE HAS CRACKED. THIS SEEMS VERY DANGEROUS. *TR

Fuel/Propulsion System

ODI #10508135

Incident: April 6, 2013 · Filed: April 13, 2013

SMELL OF GASOLINE WHILE RIDING. DISCOVERD FUEL LEAK FROM CRACKS IN PLASTIC FLANGE WHERE FUEL LINE ATTACHES TO FUEL TANK. FOUND OUT THIS IS A COMMON FAILURE. NEW MODELS HAVE A UPDATED PART. *TR

Fuel/Propulsion System

ODI #10493015

Incident: December 1, 2012 · Filed: January 15, 2013

AFTER STOPPING AT LOCAL GAS STATION TO FILL UP WITH GAS AS PER NORMAL, NOTICED GAS SMELL, BUT COULD NOT DETECT ANY VISIBLE LEAK. RODE FOR A SHORT DISTANCE, RETURNED HOME. AFTER STOPPING ENGINE AND DISMOUNTING, NOTICED MY LEFT PANT-LEG WAS SOAKED IN GASOLINE. AFTER REMOVING SIDE [LEFT] PANEL WAS ABLE TO SEE VISIBLE FUEL LEAK (MORE OF A SPRAY). LEAK ONLY OCCURRED WHEN FUEL PUMP WAS OPERATING. SOURCE OF LEAK WAS THE FEMALE CONNECTOR OF THE FUEL LINE. *TR

Fuel/Propulsion System

ODI #10475150

Incident: September 11, 2012 · Filed: September 12, 2012

WHILE RIDING THE VEHICLE ON SEPTEMBER 11, 2012 I NOTICED A STRONG FUEL SMELL. WHEN I ARRIVED AT MY DESTINATION MY LEFT PANT LEG WAS SOAKED IN FUEL. AFTER FURTHER INVESTIGATION I DETERMINED THAT THE FUEL PUMP HOUSING HIGH PRESSURE FUEL DISCONNECT FLANGE WAS CRACKED AND LEAKING FUEL DOWN THE LEFT FAIRING IN CLOSE PROXIMITY TO THE VEHICLES LEFT EXHAUST PIPE AND IGNITION. MY EXPERIENCE MATCHES THAT OF ODI ID NUMBER : 10428629. *TR

Fuel/Propulsion System

ODI #10474390

Incident: September 9, 2012 · Filed: September 9, 2012

FUEL PUMP FLANGE IS CRACKED, ALLOWING 40PSI OF FUEL PRESSURE TO STREAM OUT OF TANK. GREAT RISK OF FIRE AS FUEL LANDS DIRECTLY ON EXHAUST. THERE WAS ONLY NO FIRE BECAUSE I NOTICED THE LEAD AND SUBSEQUENT PUDDLE OF FUEL BEFORE BIKE/PIPES GOT HOT. *TR

Service Brakes, Hydraulic

ODI #10276585

Incident: September 26, 2008 · Filed: July 13, 2009

HAND GUARD ROTATED INTO A POSITION THAT RESTRICTED THE BRAKE LEVER FROM FULLY DISENGAGING THE BRAKES. THIS CAUSED THE BRAKES TO OPERATE WHILE THE MOTORCYCLE WAS IN MOTION. THE OPERATOR NOTICED THAT THE BRAKES WERE SLIGHTLY ENGAGED (DUE TO THE NOISE OF THE BRAKE SERVOS) EVEN THOUGH THE BRAKE LEVER AND PEDAL WERE NOT BEING ENGAGED BY THE OPERATOR. THE PROBLEM WAS RECTIFIED BY TWISTING THE HAND GUARD BACK INTO POSITION. HAD THE PROBLEM NOT BEEN RECTIFIED IN A TIMELY MANNER, OVERHEATING OF THE BRAKE SYSTEM COULD HAVE OCCURRED LEADING TO THE BREAKS LOCKING. BMW IS AWARE OF THIS DEFECT ON THESE MOTORCYCLES AND HAS APPARENTLY STOPPED MAKING THE REPLACEMENT PART. THEY HAVE DESIGNED A PART THAT CAN NOT INTERFERE WITH THE BRAKE OPERATION. RATHER THAN REPLACE THE DEFECTIVE HAND GUARDS, THEY HAVE RECENTLY (IN THE PAST WEEK) NOTIFIED OWNERS BY MAIL WITH A WARNING ABOUT THIS SITUATION, AND SOME STICKERS THAT CAN BE PLACED INSIDE THE HAND GUARDS. *TR

Other BMW R1200 GS model years

Check your 2006 BMW R1200 GS VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW R1200 GS at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN