NHTSA vehicle safety data

2006 BMW 5 Series Recalls & Complaints

The 2006 BMW 5 Series has 8 NHTSA recall campaigns and 85 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized BMW dealer.

NHTSA recall and complaint data for the 2006 BMW 5 Series. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 BMW 5 Series owner complaints

Owners have filed 85 complaints with NHTSA about the 2006 BMW 5 Series, describing incidents dated July 15, 2005 to May 22, 2019.

Most-cited components

Air Bags 36 complaints
Electrical System 19 complaints
Engine 8 complaints
Power Train 8 complaints
Exterior Lighting 7 complaints
Service Brakes 7 complaints

Of the 85 complaints on file, 4 report a crash and 2 a fire; across all 85 complaints, owners report 5 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11209794 · Filed May 24, 2019
TL* THE CONTACT OWNS A 2006 BMW 5 SERIES. THE CONTACT STATED THAT THE VEHICLE LEAKED OIL AND THE BRAKES FAILED WHILE DRIVING AT LOW SPEEDS. THE BRAKES WORKED NORMALLY WHEN APPLIED AT HIGH SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A NEW POWER BRAKE BOOSTER AND VACUUM…
ODI #11024085 · Filed September 18, 2017
FRONT PASSENGER SEAT OCCUPANCY DETECTION MAT HAD TO BE REPLACED AS IT WAS DEFECTIVE. THOUGH NOT IN PREVIOUS RECALLS IN SIMILAR BMWS AND SIMILAR YEARS, THE ERROR PRESENTED A SAFETY ISSUE THAT WOULD DISABLE THE FRONT PASSENGER AIR BAGS AND INCREASE THE RISK OF INJURY DURING A CRASH. WITH THIS ERROR, I…
ODI #10984319 · Filed May 8, 2017
NAVIGATION DISPLAY REBOOTS CONSTANTLY. WORKS PERIODICALLY. THIS DISPLAY GIVES ME ACCESS TO ALL OF THE CARS FEATURES INCLUDING WARNINGS AND MALFUNCTIONS WITH THE VEHICLE. IF THE DISPLAY WORKS WHEN THE CAR IS ON IT MAY NOT WORK IF YOU TURN OFF THE CARD AND TURN IT BACK ON.

Read all 85 complaints

Owner-reported

2006 BMW 5 Series mileage at failure

78 of the 85 complaints on file for the 2006 BMW 5 Series give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Air Bags	Median 70,000 miles	Middle half 55,000–80,000 miles	Based on 33 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 BMW 5 Series in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA08-001: BMW AIRBAG LIGHT ILLUMINATION
Closed December 31, 2008
- Recall 08V-384
Preliminary Evaluation PE07-045: BMW AIRBAG LIGHT ILLUMINATION
Closed January 4, 2008

Open and recently closed NHTSA defect investigations

PCV Heater May Short Circuit

NHTSA #22V119000 · Engine and Engine Cooling — Exhaust System — Emission Control — Crankcase (PCV) · NHTSA notice

Reported March 2, 2022 · BMW of North America, LLC

Potentially affected: 917,106 vehicles

Repair completion: 35.82% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified July 22, 2022

Defect description

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Safety consequence

An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Manufacturer remedy

This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Engine Cooling Fan Assemblies/Service Parts

NHTSA #12E029000 · Engine and Engine Cooling — Cooling System — Fan · NHTSA notice

Reported August 10, 2012 · Valeo

Potentially affected: 585 vehicles

Repair completion: 33.1% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified August 22, 2012

Defect description

This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on the fan assembly motor circuit board to overheat and short.

Safety consequence

This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.

Manufacturer remedy

Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

BATTERY CABLE INSULATED BULKHEAD CONNECTOR

NHTSA #12V126000 · Electrical System — 12V/24V/48V Battery — Cables · NHTSA notice

Reported March 26, 2012 · BMW OF NORTH AMERICA, LLC

Potentially affected: 367,682 vehicles

Owners notified April 30, 2012 · Vehicles built June 1, 2003 – December 31, 2009 (per NHTSA)

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.

Safety consequence

OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.

Manufacturer remedy

BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

BRAKE VACUUM PUMP

NHTSA #10V446000 · Service Brakes, Hydraulic — Power Assist — Vacuum · NHTSA notice

Reported October 1, 2010 · BMW OF NORTH AMERICA, LLC

Potentially affected: 198,352 vehicles

Owners notified November 24, 2010

Defect description

BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.

Safety consequence

POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FRONT PASSENGER SEAT OCCUPANT DETECTION MAT

NHTSA #08V384000 · Air Bags — Frontal · NHTSA notice

Reported August 5, 2008 · BMW OF NORTH AMERICA, LLC

Potentially affected: 200,000 vehicles

Owners notified November 6, 2008 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.

Safety consequence

IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.

Manufacturer remedy

DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Notes

BMW IS EXTENDING THE WARRANTY TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT TO THE FOLLOWING VEHICLES:MY 2006 6-SERIES, 3-SERIES (STANDARD SEAT), MY 2004-2005 Z4, MY 2004-2006 7-SERIES, MY 2006 X5, AND MY 2004-2006 5-SERIES (COMFORT SEAT).UNDER THE EXTENDED WARRANTY PROGRAM, THE OCCUPANT DETECTION MAT IN A VEHICLE THAT EXPERIENCES THIS SPECIFIC ISSUE WILL BE REPLACED AT NO CHARGE TO THE CUSTOMER.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REAR SHOCK ABSORBERS

NHTSA #06V277000 · Suspension — Rear — Shock Absorber · NHTSA notice

Reported July 26, 2006 · BMW OF NORTH AMERICA, LLC

Potentially affected: 11,640 vehicles

Owners notified September 13, 2006 · Vehicles built January 5, 2006 – April 26, 2006 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES, THE LOWER RUBBER MOUNT OF THE REAR SHOCK ABSORBERS MAY NOT HAVE BEEN MANUFACTURED TO SPECIFICATIONS AND MAY NOT ADHERE CORRECTLY TO ITS HOUSING WITHIN THE SHOCK ABSORBER.

Safety consequence

THE BUSHING COULD LOOSEN AND OVER TIME COULD SEPARATE FROM ITS HOUSING. THE DRIVER WILL EXPERIENCE IMPAIRED VEHICLE HANDLING AND CONTROL INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE REAR SHOCK ABSORBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 13, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FRONT AXLE CONTROL ARM AND TENSION STRUT NUTS

NHTSA #06V187000 · Suspension — Front — Control Arm · NHTSA notice

Reported May 30, 2006 · BMW OF NORTH AMERICA, LLC

Potentially affected: 40 vehicles

Owners notified June 28, 2006 · Vehicles built February 13, 2006 – February 13, 2006 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES, THE NUTS WHICH SECURE THE FRONT AXLE CONTROL ARM AND TENSION STRUT TO THE FRONT WHEEL HUB MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATION. OVER TIME THE NUTS COULD LOOSEN AND THE CONTROL ARM AND TENSION STRUT COULD BE DAMAGED.

Safety consequence

VEHICLE HANDLING AND CONTROL COULD COMPROMISE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL RETIGHTEN THE FRONT AXLE CONTROL ARM AND TENSION STRUT NUTS TO THE CORRECT SPECIFICATIONS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

PARK PAWL GUIDE PLATE

NHTSA #05V504000 · Power Train — Automatic Transmission · NHTSA notice

Reported November 1, 2005 · BMW OF NORTH AMERICA, LLC

Potentially affected: 240 vehicles

Owners notified November 30, 2005 · Vehicles built August 1, 2005 – September 30, 2005 (per NHTSA)

Defect description

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.

Safety consequence

THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.

Manufacturer remedy

DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT BMW AT 1-800-332-4269.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 BMW 5 Series 4-DR w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

Electronic Stability Control

2 investigations

85 owner complaints have been filed with NHTSA for the 2006 BMW 5 Series.

Service Brakes; Engine

ODI #11209794

Incident: May 22, 2019 · Filed: May 24, 2019

TL* THE CONTACT OWNS A 2006 BMW 5 SERIES. THE CONTACT STATED THAT THE VEHICLE LEAKED OIL AND THE BRAKES FAILED WHILE DRIVING AT LOW SPEEDS. THE BRAKES WORKED NORMALLY WHEN APPLIED AT HIGH SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A NEW POWER BRAKE BOOSTER AND VACUUM PUMP NEEDED TO BE INSTALLED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 104,932. *DT

Air Bags

ODI #11024085

Incident: June 21, 2017 · Filed: September 18, 2017

FRONT PASSENGER SEAT OCCUPANCY DETECTION MAT HAD TO BE REPLACED AS IT WAS DEFECTIVE. THOUGH NOT IN PREVIOUS RECALLS IN SIMILAR BMWS AND SIMILAR YEARS, THE ERROR PRESENTED A SAFETY ISSUE THAT WOULD DISABLE THE FRONT PASSENGER AIR BAGS AND INCREASE THE RISK OF INJURY DURING A CRASH. WITH THIS ERROR, I WAS FORCED TO REPAIR THE SEAT MAT AND EXPENDED $1.5K TO REMEDY THIS SAFETY ISSUE. THIS SEAT MAT ISSUE IS A KNOWN BMW PROBLEM THAT BMW AND NHTSA HAVE NOT ADDRESSED. VIN: [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Electrical System; Unknown or Other

ODI #10984319

Incident: May 2, 2016 · Filed: May 8, 2017

NAVIGATION DISPLAY REBOOTS CONSTANTLY. WORKS PERIODICALLY. THIS DISPLAY GIVES ME ACCESS TO ALL OF THE CARS FEATURES INCLUDING WARNINGS AND MALFUNCTIONS WITH THE VEHICLE. IF THE DISPLAY WORKS WHEN THE CAR IS ON IT MAY NOT WORK IF YOU TURN OFF THE CARD AND TURN IT BACK ON.

Electrical System; Exterior Lighting

ODI #10979421

Incident: April 1, 2017 · Filed: April 20, 2017

HEAD LIGHTS ANGLE LIGHTS WIRES GETTING VERY DRY FROM THE HEAT OF THE LIGHT AND THE INSULATION COMING OFF THE OPTICAL WIRES, LIGHTS GO OUT, POSSIBLE SHORTING AND BECOME VERY UNSAFE.

Air Bags; Seats; Engine

ODI #10939903

Incident: February 26, 2014 · Filed: January 5, 2017

THE PASSENGER SEAT AIRBAG MALFUNCTIONED CASING THE SEAT TO HAVE TO BE REMOVED AND SENSOR REPLACED. THERE WAS A RECALL ON THIS BUT MY CAR, AND 2 OF MY FRIENDS CARS WERE NOT INCLUDED ON THE RECALL, MY FRIENDS WERE CHARGED BY THE DEALERSHIP. MY ENGINE LEAKS OIL ONTO THE EXHAUST MANIFOLD CAUSING SMOKE IN THE CAB AND POTENTIAL FIRE HAZARD. ON EVERY BM I HAVE EVER OWNED THE RADIATOR LEAKS FLUID WHICH IS ENVIRONMENTALLY HAZARDOUS AND SHOULD HAVE BEEN RECALLED.

Air Bags

ODI #10846358

Incident: January 12, 2016 · Filed: March 13, 2016

MY PASSENGER AIR BAG WARNING LIGHT CAME ON ABOUT A MONTH AGO FOR APPARENT REASON AND STAY ON EVER SINCE. I CONTACTED THE LOCAL BMW DEALER AND WAS TOLD MY VIN WAS NOT ON THE RECALL LIST. I WAS VERY DISAPPOINTED AND DONT UNDERSTAND WHY SOME CARS WERE ON THE RECALL AND SOME WERE NOT. APPARENTLY THIS IS A COMMON PROBLEM WITH ALL BMWS AND A VERY SERIOUS SAFETY ISSUE. THIS SAFETY ISSUE SHOULD BE TAKEN CARE OF BY THE MANUFACTURE.

Electrical System; Engine

ODI #10744826

Incident: March 1, 2015 · Filed: July 29, 2015

AIR CONDITIONING STOP WORK CAUSING MOTOR TO HEAT

Steering; Electrical System

ODI #10744822

Incident: February 1, 2015 · Filed: July 29, 2015

STEERING WHEEL MALFUNCTION LOCKS PREVENTING THE VEHICLE TO START STEERING WHEEL LOCKS WHILE DRIVING

Electrical System; Exterior Lighting

ODI #10683432

Incident: February 14, 2015 · Filed: February 14, 2015

A MESSAGE ON THE VEHICLE DISPLAY SCREEN INDICATED THAT THE RIGHT-SIDE LOW BEAM HEADLIGHT WAS MALFUNCTIONING. I REMOVED THE HEADLIGHT ASSEMBLY TO REPLACE THE BULB AND FOUND THE WIRING INSULATION IS CRUMBLING TO THE TOUCH, RESULTING IN A SHORT CIRCUIT. THE HEADLIGHT BULB IS NOT ACTUALLY BURNED OUT. THERE ARE MANY COMPLAINTS ABOUT THIS ON THE BMW FORUMS BUT BMW AND THE HEADLIGHT MANUFACTURER, HELLA, REFUSES TO ACKNOWLEDGE THE PROBLEM OR DO ANYTHING ABOUT IT. *TR

Engine

ODI #10677109

Incident: June 4, 2013 · Filed: January 21, 2015

THE 2006 BMW 5 SERIES USED ALUMINUM HEAD AND VALVE COVER BOLTS WHICH WERE OVER-TORQUED DURING ASSEMBLY AND BREAK AFTER APPROXIMATELY 80K. BMW ADMITS THIS PROBLEM EXISTS BUT REFUSES TO ISSUE A RECALL. BMW'S REPAIR COST IS ~$6000. THESE BOLTS ARE NON SERVICEABLE AND SHOULD NEVER BE REMOVED, WHEN BROKEN THEY CAUSE MASSIVE OIL LEAKS AND POSSIBLY FIRE. I CONTACTED BMW, THEY REQUESTED TO REVIEW THE CAR. BMW AGREED THAT THE BOLTS WERE BROKEN THEN REFUSED TO FIX THE PROBLEM CLAIMING THE CAR HAS TOO MANY MILES. BMW KNEW THE MILEAGE WHEN THEY REQUESTED TO REVIEW THE PROBLEM ... WHY WASTE MY TIME IF THEY KNEW THEY WERE GOING TO DO NOTHING? MY VEHICLE NOW LOSSES APPROXIMATELY 1-2 QUARTS OF OIL PER 100 MILES. I AM CHAGRINED THAT BMW WILL NOT ADMIT THEIR MANUFACTURING DEFECT. I HAVE MAINTAINED THIS CAR WITH CARE AND OTHER THAN THE OIL LEAK FROM THE BROKEN BOLTS THE CAR IS IN PERFECT CONDITION - BUT IS NO LONGER DRIVABLE. *TR

Other BMW 5 Series model years

Check your 2006 BMW 5 Series VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your BMW 5 Series at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a BMW VIN