NHTSA vehicle safety data

2004 Audi Allroad Recalls & Complaints

The 2004 Audi Allroad has 3 NHTSA recall campaigns and 15 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Audi dealer.

NHTSA recall and complaint data for the 2004 Audi Allroad. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Audi Allroad owner complaints

Owners have filed 15 complaints with NHTSA about the 2004 Audi Allroad, describing incidents dated February 25, 2005 to March 14, 2016.

Most-cited components

Vehicle Speed Control 5 complaints
Engine 2 complaints
Fuel/Propulsion System 2 complaints
Suspension 2 complaints
Tires 2 complaints
Visibility/Wiper 2 complaints

Of the 15 complaints on file, 3 report a crash and 2 a fire; across all 15 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10851719 · Filed March 26, 2016
WHILE DRIVING MY ENGINE LIGHT CAME ON, AND I SMELLED GAS. I BROUGHT THE CAR TO A SHOP TO HAVE IT REPAIRED. THERE IS A GAS LEAK FROM ROLLOVER VALVE ON THE GAS TANK. WAS RECALLED IN 2009, REPAIRED BY THE DEALER. I HAVE JUST BOUGHT THE CAR USED AND FOUND THAT THE SAME PROBLEM IS OCCURRING AGAIN. WITH…
ODI #10758950 · Filed August 24, 2015
TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. WHILE DRIVING AT AN UNKNOWN SPEED, BURNING FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A FIRE ERUPTED NEAR THE TURN SIGNALS AND THE STEERING COLUMN AREA. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH WATER. THE…
ODI #10633244 · Filed September 15, 2014
WHILE DRIVING DOWN THE INTERSTATE THE MOON ROOF SPONTANEOUSLY EXPLODED! IT WAS NOT HIT BY ANYTHING, IT JUST EXPLODED. I HAVE DONE A LITTLE RESEARCH AND HAVE FOUND THAT AUDI HAS HAD A PROBLEM IN THE PAST WITH FAULTY GLASS CAUSING THEIR MOON ROOFS TO EXPLODE AND HAD TO ISSUED A RECALL FOR THIS…

Read all 15 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2004 Audi Allroad in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE08-008: FUEL TANK LEAK
Closed May 30, 2008
- Recall 08V-156
- Recall 08V-157

Open and recently closed NHTSA defect investigations

FUEL TANK ROLLOVER VALVE

NHTSA #08V157000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported April 8, 2008 · VOLKSWAGEN OF AMERICA, INC

Potentially affected: 68,240 vehicles

Manufacturer campaign 20L8/JY · Owners notified June 27, 2008 · Vehicles built June 2, 2001 – June 1, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

VOLKSWAGEN IS RECALLING 68,240 MY 2001-2004 AUDI A6 QUATTRO VEHICLES EQUIPPED WITH 2.7L, 2.8L, OR 3.0L ENGINES AND MY 2001-2005 ALLROAD QUATTRO VEHICLES EQUIPPED WITH 2.7L OR 4.2L ENGINES. THE AGING OF THE PLASTIC MATERIAL IN THE FUEL TANK ROLLOVER VALVE COMBINED WITH BENDING STRESS FROM THE ALUMINUM VENTILATION LINE TO THE ROLLOVER VALVE NIPPLE MAY LEAD TO CRACKING OF THE NIPPLE. IF THIS HAPPENS, A FUEL LEAK MAY RESULT.

Safety consequence

A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD LEAD TO A VEHICLE FIRE.

Manufacturer remedy

DEALERS WILL REINFORCE THE NIPPLE ON THE ROLLOVER VALVE TO PREVENT LEAKAGE OR REPAIR THE CRACKING AT THE NIPPLE. THE RECALL BEGAN ON JUNE 27, 2008. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

Notes

VW RECALL NO. 20L8/JY.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

CROSSMEMBER COVER/DRIVERS SIDE DASH FIRE

NHTSA #06V198000 · Electrical System · NHTSA notice

Reported June 5, 2006 · VOLKSWAGEN OF AMERICA, INC

Potentially affected: 70,512 vehicles

Manufacturer campaign JN · Owners notified December 16, 2006 · Vehicles built August 1, 1997 – June 30, 2005 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH HALOGEN LOW BEAM HEADLIGHTS, CERTAIN CONNECTOR PINS IN THE HEADLIGHT SWITCH CONNECTOR COME INTO CONTACT WITH EACH OTHER CAUSING A SHORT CIRCUIT. NOTE: VEHICLES WITH XENON LOW BEAM HEADLIGHTS ARE NOT AFFECTED BECAUSE THE CIRCUIT IN THESE VEHICLES CONTAINS A FUSE, WHICH PRECLUDES EXCESSIVE CURRENT FLOW IN THE CASE OF A SHORT CIRCUIT. AUDI S6 AND S6 AVANT VEHICLES ARE ALL EQUIPPED WITH XENON LOW BEAM HEADLIGHTS AND, THEREFORE, ARE NOT LONGER AFFECTED BY THIS RECALL.

Safety consequence

THIS CONDITION COULD LEAD TO OVERHEATING OR FIRE.

Manufacturer remedy

DEALERS WILL REROUTE THE WIRING HARNESS BY INSTALLING A JUMPER WIRING HARNESS. THE RECALL BEGAN ON DECEMBER 16, 2006. OWNERS MAY CONTACT AUDI AT 1-800-822-2834.

Notes

VOLKSWAGEN (AUDI) RECALL NO. JN.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

VW/DRIVERS SIDE DASH FIRE

NHTSA #04V133000 · Electrical System · NHTSA notice

Reported March 18, 2004 · VOLKSWAGEN OF AMERICA, INC

Potentially affected: 172,866 vehicles

Owners notified July 26, 2004 · Vehicles built August 14, 1997 – February 12, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN PASSENGER VEHICLES, IF A DRIVER'S KNEES PUSH AGAINST THE KNEE BOLSTER (CRASH ELEMENT) LOCATED UNDER THE DASHBOARD, IT CAN CONTACT THE HEADLIGHT SWITCH WIRING HARNESS, AND AN ELECTRICAL SHORT COULD OCCUR.

Safety consequence

A FIRE COULD ORIGINATE IN THE LEFT DASHBOARD AREA.

Manufacturer remedy

DEALERS WILL INSTALL A PROTECTIVE COVERING ON THE KNEE BOLSTER (CRASH ELEMENT). IN ADDITION, THE WIRING HARNESS AS WELL AS THE FELT PROTECTOR ON THE LEFT SIDE OF THE DASHBOARD CARRIER WILL BE CHECKED, AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JULY 26, 2004. OWNERS SHOULD CONTACT AUDI AT 1-800-822-2834.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2004 Audi Allroad w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

Electronic Stability Control

1 investigation

15 owner complaints have been filed with NHTSA for the 2004 Audi Allroad.

Fuel/Propulsion System

ODI #10851719

Incident: March 14, 2016 · Filed: March 26, 2016

WHILE DRIVING MY ENGINE LIGHT CAME ON, AND I SMELLED GAS. I BROUGHT THE CAR TO A SHOP TO HAVE IT REPAIRED. THERE IS A GAS LEAK FROM ROLLOVER VALVE ON THE GAS TANK. WAS RECALLED IN 2009, REPAIRED BY THE DEALER. I HAVE JUST BOUGHT THE CAR USED AND FOUND THAT THE SAME PROBLEM IS OCCURRING AGAIN. WITH SOME RESEARCH I FOUND OUT THAT THE DEALER FIXED THE PROBLEM WITH EPOXY.

Electrical System; Fuel/Propulsion System

ODI #10758950

Fire

Incident: August 23, 2015 · Filed: August 24, 2015

TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. WHILE DRIVING AT AN UNKNOWN SPEED, BURNING FUMES EMITTED INTO THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A FIRE ERUPTED NEAR THE TURN SIGNALS AND THE STEERING COLUMN AREA. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES WITH WATER. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND LATER TO A DEALER FOR INSPECTION AND DIAGNOSTIC TESTING. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 08V157000 (FUEL SYSTEM, GASOLINE), 06V198000 (ELECTRICAL SYSTEM), AND 04V133000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.

Visibility; Structure

ODI #10633244

Incident: September 11, 2014 · Filed: September 15, 2014

WHILE DRIVING DOWN THE INTERSTATE THE MOON ROOF SPONTANEOUSLY EXPLODED! IT WAS NOT HIT BY ANYTHING, IT JUST EXPLODED. I HAVE DONE A LITTLE RESEARCH AND HAVE FOUND THAT AUDI HAS HAD A PROBLEM IN THE PAST WITH FAULTY GLASS CAUSING THEIR MOON ROOFS TO EXPLODE AND HAD TO ISSUED A RECALL FOR THIS PROBLEM. I CONTACTED AUDI AND REQUESTED THEM TO REPLACE MY MOON ROOF. THEY GAVE ME THE RUN AROUND AND THEN UNFORTUNATELY, DECIDED THAT THEY ARE UNWILLING TO ASSIST ME WITH THE REPLACEMENT OF MY OWN MOON ROOF BECAUSE IT WAS NOT ONE OF THE MODELS RECALLED AND MY CAR IS OVER 10 YEARS OLD SO IT IS OUT OF WARRANTY. THANK GOD MY CHILDREN WERE NOT IN THE CAR TO BE INJURED BY EXPLODING GLASS AND THANK GOD IT WAS 5:00 IN THE MORNING SO THERE WAS NO TRAFFIC AROUND FOR THE EXPLOSION TO HAVE CAUSED AN ACCIDENT! AUDI HAS TREATED THIS LIKE IT'S NOT BIG DEAL, SOMETHING THAT SHOULD BE EXPECTED TO HAPPEN AFTER OWNING ONE OF THEIR CARS FOR 10 YEARS, AND THAT IT IS MY PROBLEM FOR HAVING AN "OLD" CAR. SHAME ON AUDI FOR NOT TAKING RESPONSIBILITY FOR THIS! *TR

Vehicle Speed Control; Engine

ODI #10629613

Crash

Incident: August 9, 2014 · Filed: August 30, 2014

ON AUG. 09 2014 COMMING TO A STOP I APPLIED THE BRAKES. ALL OF A SUUDEN THE ENGINE STARTED TO ACCELERATE UNCONTROLABLE TRYING TO MOVE THE CAR FORWARD. I PRESSED THE BRAKES AS HARD AS I COULD AND I STOPED THE CAR AFTER I HIT THE CAR IN FRONT WHEN I WAS ABLE TO TURN THE IGNITION KEY OFF. THIS SUDDEN UNINTENDED ACCELERATION MALFUNCTION ALSO HAPPENED ON JAN. 29, 2006 AND JAN. 30, 2011, ALSO REPORTED TO NHTSA AT THOSE TIMES. IT IS A LIFE SAFETY ISSUE AND SHOULD BE ADDRESSED A.S.A.P. THE MANUFACTURER REFUSE TO TAKE ANY ACTION. *TR

Vehicle Speed Control; Engine

ODI #10621341

Crash

Incident: August 9, 2014 · Filed: August 11, 2014

TL* THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT THE BRAKES FAILED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THE FAILURE COULD NOT BE DUPLICATED. WHILE DRIVING 30 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE DID NOT STOP. THE FAILURE CAUSED THE CONTACT TO REAR END ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING ON THE RESULTS OF THE DIAGNOSTIC TEST FROM THE DEALER. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 10,848. UPDATED 09/15/14*LJ THE CONSUMER STATED THE FAILURE IS UNINTENDED ACCELERATION NOT BRAKE FAILURE. MANUFACTURER REFUSED ASSISTANCE. UPDATED 1/16/15 *JS

Seats

ODI #10606513

Fire

Incident: November 12, 2013 · Filed: June 27, 2014

TL * THE CONTACT OWNS A 2004 AUDI ALLROAD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A FIRE ERUPTED IN THE VEHICLE DUE TO THE HEATED SEATS. THE VEHICLE WAS TAKEN TO DEALER WHERE THE REPAIRS WERE UNKNOWN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 108,000.

Suspension; Tires

ODI #10456964

Incident: April 13, 2012 · Filed: April 30, 2012

THE SUSPENSION IN FRONT TIRES KEEP GOING OUT. AND WHEN I DID THE RESEARCH AS TO HOW TO FIX THIS PROBLEM ON AN AUDI IT STATED THAT THEY ARE FAMILIAR WITH THE PROBLEM AND ARE OF THIS PROBLEM BUT SEE ANY REASON AS TO WHY THEY SHOULD FIX IT. EVEN THOUGH THE PROBLEM EXISTED WHEN THE CAR REACHED A CERTAIN PART. *JS

Unknown or Other

ODI #10380950

Incident: January 30, 2011 · Filed: February 7, 2011

SUDDEN UNINTENDED ACCELERATION , COMING TO A STOP SIGN, APPLYING THE BRAKES, THE ENGINE STARTED TO ACCELERATE UNCONTROLLED. I WAS ABLE TO STOP IT AFTER I PUSHED THE CAR IN FRONT. I SHIFTED IN PARK, THE ENGINE CONTINUED TO ACCELERATE AT HIGHER RATE WHEN I WAS ABLE TO TURN THE KEY OFF. *LN

Vehicle Speed Control

ODI #10379663

Crash 1 injury

Incident: January 30, 2011 · Filed: January 31, 2011

TL*THE CONTACT OWNS A 2004 AUDI ALLROAD 4.2(NA). WHILE COMING TO A STOP AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE CONTINUED TO MOVE FORWARD. THE RPMS INCREASED RAPIDLY AND THE CONTACT REAR ENDED THE VEHICLE IN FRONT. ONE PERSON WAS INJURED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CONTACT PLANNED TO WRITE THE MANUFACTURER. THE FAILURE MILEAGE WAS 27,745. UPDATED 03/15/11*LJ UPDATED 12/30/11 *CN

Vehicle Speed Control

ODI #10323748

Incident: March 27, 2007 · Filed: April 5, 2010

TL* THE CONTACT OWNS A 2004 AUDI QUATTRO 4 (N/A) THE CONTACT STATED THAT VEHICLE GAS PEDAL STICKS. THE FIRST OCCURRENCE WAS ABOUT 3 YEARS AGO. THE CONTACT WAS ENTERING HIGHWAY GOING ABOUT 60 MPH ON A DRY DAY , HE TOOK HIS FOOT OFF THE ACCELERATOR AND THE VEHICLE JUST "TOOK OFF". HE MANAGED TO GET THE VEHICLE STOPPED. THE PROBLEM HAS REOCCURED ON AND OFF SINCE THEN. THE VEHICLE WAS TAKEN TO DEALER AND THE TECHNICIAN STATED THAT THE PROBLEM WAS THE FLOOR MATS. THE MATS WERE RE-ADJUSTED AND THE PROBLEM CONTINUED. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER AND WAS STILL AT THE DEALER AT THE TIME OF THE COMPLAINT. AUDI HAS CALLED IN AN EXPERT TO DIAGNOSE THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 46,000. THE CURRENT MILEAGE IS APPROXIMATELY 110,000. THE VIN UNKNOWN.

Other Audi Allroad model years

Check your 2004 Audi Allroad VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Audi Allroad at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Audi VIN