NHTSA vehicle safety data
2000 Utilimaster Walk-In Van Recalls, Ratings & Complaints
The 2000 Utilimaster Walk-In Van has 3 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Utilimaster dealer.
NHTSA recall and complaint data for the 2000 Utilimaster Walk-In Van. Recall data is refreshed daily from NHTSA.
SEAT BELTS:FRONT:RETRACTOR
NHTSA #18V377000Reported June 6, 2018 · Spartan Motors USA
Potentially affected: 3,194 vehicles
Defect description
Spartan Motors USA (Spartan) is recalling certain 1991-2018 Utilimaster Aeromaster and Walk-In Vans. These vehicles were manufactured with front seat belts that do not have an emergency locking seat belt retractor or automatic locking seat belt retractor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Safety consequence
Without retractors, the seat belts may not accommodate different size occupants, therefore the occupants may not be properly restrained in the event of a crash, increasing the risk of injury.
Manufacturer remedy
Spartan will notify owners and will install seat belts with retractors, free of charge. The recall began on August 6, 2018. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 18019.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
NHTSA #03V275000Reported July 29, 2003 · UTILIMASTER CORPORATION
Potentially affected: 4,001 vehicles
Defect description
ON CERTAIN WALK-IN VANS, A FUSE WAS INSTALLED BY FORD. HOWEVER, UTILIMASTER INSTALLED A WIRE. THE FUSE IS NOT COMPATIBLE WITH THE WIRE GAUGE INSTALLED BY UTILIMASTER.
Safety consequence
SHOULD A FAILURE OCCUR IN A VEHICLE COMPONENT SUCH AS A FAN, HEATED MIRROR AND/OR OTHER IGNITION-HOT OPTION, THE INSULATION AROUND THE WIRING TO THE FAN COULD MELT.
Manufacturer remedy
OWNERS WILL BE PROVIDED WITH A REPLACEMENT FUSE. OWNER NOTIFICATION BEGAN OCTONER 1, 2003. OWNERS SHOULD CONTACT UTILIMASTER AT 1-800-582-3454.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
NHTSA #01V003000Reported January 5, 2001 · UTILIMASTER CORPORATION
Potentially affected: 15,762 vehicles
Defect description
VEHICLE DESCRIPTION: WALK-IN DELIVERY VANS SUPPLIED TO THE UNITED STATES POSTAL SERVICE. UNDER CERTAIN SNOW CONDITIONS, IF MOISTURE GETS INTO THE BLOWER MOTOR AND SUBSEQUENTLY REFREEZES, THE BLOWER MOTOR COULD SEIZE CAUSING A RESISTOR TO OVERHEAT.
Safety consequence
WHEN A RESISTOR OVERHEATS, THE PLENUM COULD MELT, RESULTING IN DEFORMATION AND POSSIBLE IGNITION.
Manufacturer remedy
UTILIMASTER WILL INSTALL FUSES BETWEEN THE RESISTORS AND THE POWER SUPPLY, WHICH WILL PROTECT THE RESISTOR ASSEMBLY IN THE EVENT OF AN OVERCURRENT SITUATION. AN EXISTING FUSE WILL BE RESIZED TO PROTECT THE WIRING HARNESS IN HIGH-SPEED FAN OPERATION. OWNER NOTIFICATION BEGAN JANUARY 24, 2001. ONLY US POSTAL SERVICE VEHICLES ARE INVOLVED IN THIS CAMPAIGN.
Other Utilimaster Walk-In Van model years
Check your 2000 Utilimaster Walk-In Van VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Utilimaster Walk-In Van at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Utilimaster VIN