NHTSA vehicle safety data

2007 Thomas Built Buses MVP-EF Recalls & Complaints

The 2007 Thomas Built Buses MVP-EF has 6 NHTSA recall campaigns and 1 owner complaint on file as of November 3, 2026. Recall repairs are usually free at an authorized Thomas Built Buses dealer.

NHTSA recall and complaint data for the 2007 Thomas Built Buses MVP-EF. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 Thomas Built Buses MVP-EF owner complaints

Owners have filed 1 complaint with NHTSA about the 2007 Thomas Built Buses MVP-EF, describing incidents dated February 7, 2010.

Most-cited components

Electrical System 1 complaint

The complaint on file reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10310767 · Filed February 16, 2010
MELTED TYCO CIRCUIT BOARD AFTER RECALL 07V-544 HAD BEEN COMPLETED. RECALL DOES NOT APPEAR TO BE CORRECTING THIS PROBLEM. *TR

Read the full complaint

GEN EM-1 EVAPORATORS/CARRIER

NHTSA #11V222000 · Equipment — Appliance — Air Conditioner · NHTSA notice

Reported April 6, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 6,831 vehicles

Manufacturer campaign FL-604 · Owners notified May 20, 2011 · Vehicles built January 2, 2006 – January 31, 2011 (per NHTSA)

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Safety consequence

IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-604.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

GEN EM-1 EVAPORATORS/CARRIER

NHTSA #11V223000 · Equipment — Appliance — Air Conditioner · NHTSA notice

Reported April 6, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 64 vehicles

Manufacturer campaign FL-604 · Owners notified May 20, 2011 · Vehicles built January 2, 2006 – January 31, 2011 (per NHTSA)

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER HDX, MVP-EF, AND MINOTOR NON SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Safety consequence

IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.

Manufacturer remedy

Notes

ACCELERATOR PEDAL

NHTSA #09V462000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported December 1, 2009 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 5,082 vehicles

Manufacturer campaign FL-570 · Owners notified March 17, 2010 · Vehicles built February 15, 2005 – November 23, 2009 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 THOMAS BUILT MVP-EF SCHOOL BUSES MANUFACTURED FROM FEBRUARY 15, 2005 THROUGH NOVEMBER 23, 2009. THE ACCELERATOR PEDAL MAY BECOME WEDGED AGAINST THE SCUFF PLATE AND BECOME STUCK IN FULL THROTTLE POSITION.

Safety consequence

A STUCK ACCELERATOR PEDAL MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL RAISE THE ACCELERATOR PEDAL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 17, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Notes

DAIMLER TRUCKS' CAMPAIGN NUMBER IS FL-570.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

DUAL POWER SWITCH

NHTSA #08V622000 · Electrical System — Wiring — Fuses and Circuit Breakers · NHTSA notice

Reported November 26, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 18,198 vehicles

Manufacturer campaign FL-539 · Owners notified July 6, 2009 · Vehicles built February 1, 2002 – October 17, 2008 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING 18,198 MY 2003-2009 THOMAS BUILT ER, MVP-ER, HDX, AND MVP-EF SCHOOL AND TRANSIT BUSES EQUIPPED WITH A DUAL POWER SWITCH AND MANUFACTURED FROM FEBRUARY 1, 2002 THROUGH OCTOBER 17, 2008. SOLID STATE CIRCUIT BREAKERS MAY TRIP UNNECESSARILY POTENTIALLY RESULTING IN A LOSS OF POWER TO THE BUS CHASSIS AND BODY ELECTRICAL CIRCUITS CAUSING AN UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING.

Safety consequence

UNEXPECTED LOSS OF ENGINE POWER AND EXTERIOR LIGHTING COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

THOMAS BUILT BUS DEALERS WILL REPLACE THE SOLID STATE DUAL POWER SWITCH WITH A MECHANICAL CIRCUIT PRODUCTION (MEGA FUSE). THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.

Notes

DAIMLER TRUCK RECALL NO. FL-539.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FMVSS 403/BRAUN WHEELCHAIR LIFTS/THRESHOLD WARNING

NHTSA #08V088000 · Equipment Adaptive/Mobility · NHTSA notice

Reported February 26, 2008 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 760 vehicles

Manufacturer campaign FL-524 · Owners notified August 8, 2008 · Vehicles built July 6, 2005 – July 19, 2006 (per NHTSA)

Defect description

DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.

Safety consequence

SHOULD THE THRESHOLD WARNING SYSTEM FAIL TO OPERATE, THE LIFT USER CAN FALL FROM THE VEHICLE AND BE SERIOUSLY INJURED.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.

Notes

DAIMLER TRUCKS RECALL NO. FL-524.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

WHEELCHAIR LIFTS/RICON

NHTSA #06V150000 · Equipment Adaptive/Mobility · NHTSA notice

Reported May 3, 2006 · FREIGHTLINER LLC

Potentially affected: 45 vehicles

Manufacturer campaign FL-473 · Owners notified June 23, 2006 · Vehicles built June 16, 2005 – July 1, 2005 (per NHTSA)

Defect description

CERTAIN MY 2004-2007 THOMAS BUILT MINOTOUR, FS65, MVP-EF, AND HDX MODEL SCHOOL BUSES, MANUFACTURED BETWEEN JUNE 16 AND JULY 1, 2005, EQUIPPED WITH RICON WHEELCHAIR LIFTS. CRACKS IN THE LIFT ARMS MAY ALLOW THE MECHANISM TO TWIST DURING STOWAGE, PREVENTING CLOSURE OF THE SAFETY INTERLOCK SWITCHES.

Safety consequence

IN THE EVENT THIS CONDITION OCCURS DURING PASSENGER OPERATIONS IT MAY NOT BE POSSIBLE TO CLOSE THE LIFT DOOR CAUSING THE VEHICLE INTERLOCKS TO REMAIN ENGAGED PREVENTING MOVEMENT OF THE VEHICLE OR THE ABILITY TO LOAD OR UNLOAD PASSENGERS WITH DISABILITIES FROM THE VEHICLE.

Manufacturer remedy

RICON IS CONDUCTING THIS RECALL (PLEASE SEE 06E008000) AND WILL REPLACE THE TWO VERTICAL ARMS EVEN IF ONLY ONE ARM IS CRACKED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON MAY 30, 2006. OWNERS MAY CONTACT RICON CUSTOMER SUPPORT DEPT. AT 800-322-2884 OR OWNERS MAY CONTACT THOMAS BUS CUSTOMER SUPPORT OFFICE AT 336-889-4871.

Notes

FREIGHTLINER RECALL NO. FL-473.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2007 Thomas Built Buses MVP-EF. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

1 owner complaint has been filed with NHTSA for the 2007 Thomas Built Buses MVP-EF.

Electrical System

ODI #10310767

Fire

Incident: February 7, 2010 · Filed: February 16, 2010

MELTED TYCO CIRCUIT BOARD AFTER RECALL 07V-544 HAD BEEN COMPLETED. RECALL DOES NOT APPEAR TO BE CORRECTING THIS PROBLEM. *TR

Other Thomas Built Buses MVP-EF model years

Check your 2007 Thomas Built Buses MVP-EF VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thomas Built Buses MVP-EF at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Thomas Built Buses VIN