How many recalls does the 2010 Thomas Built Buses MVP-EF have?

NHTSA lists 9 recall campaigns for the 2010 Thomas Built Buses MVP-EF as of October 16, 2026. Each includes the defect description, safety consequence, and the remedy Thomas Built Buses will perform. New recalls can be issued at any time; this page is refreshed from NHTSA daily.

How do I tell if my 2010 Thomas Built Buses MVP-EF is affected by a recall?

Enter your 17-character VIN — stamped at the base of the windshield on the driver side and on the door jamb sticker — at nhtsa.gov/recalls. NHTSA's VIN lookup shows whether your specific vehicle has an unrepaired recall; the list on this page covers every campaign for the 2010 Thomas Built Buses MVP-EF.

Are recall repairs on a 2010 Thomas Built Buses MVP-EF free?

Usually. Federal law requires Thomas Built Buses to remedy recalls on the 2010 MVP-EF free of charge at an authorized Thomas Built Buses dealer, regardless of how many owners the vehicle has had or how many miles are on the odometer — unless it was first sold more than 15 years before the recall was issued (5 years for tires).

Does a recall on the 2010 Thomas Built Buses MVP-EF affect resale value?

An open recall can reduce resale value; a recall that has been repaired (documented in the vehicle history report) generally does not. Before you buy or sell a used 2010 Thomas Built Buses MVP-EF, check the VIN at nhtsa.gov/recalls to confirm every recall has been remedied.

How many owner complaints are on file for the 2010 Thomas Built Buses MVP-EF?

No owner complaints have been filed with NHTSA on the 2010 Thomas Built Buses MVP-EF.

NHTSA vehicle safety data

2010 Thomas Built Buses MVP-EF Recalls, Ratings & Complaints

The 2010 Thomas Built Buses MVP-EF has 9 NHTSA recall campaigns and 0 owner complaints on file as of October 16, 2026. Recall repairs are usually free at an authorized Thomas Built Buses dealer.

NHTSA recall and complaint data for the 2010 Thomas Built Buses MVP-EF. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

EQUIPMENT:APPLIANCE:AIR CONDITIONER

NHTSA #11V223000

Reported April 6, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 64 vehicles

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER HDX, MVP-EF, AND MINOTOR NON SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Safety consequence

IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.

Manufacturer remedy

DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.

Notes

DTNA'S RECALL CAMPAIGN NUMBER IS FL-604.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

EQUIPMENT:APPLIANCE:AIR CONDITIONER

NHTSA #11V222000

Reported April 6, 2011 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 6,831 vehicles

Defect description

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Safety consequence

IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.

Manufacturer remedy

Notes

SEATS

NHTSA #10V486000

Reported October 14, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 294 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN THOMAS BUILT MVP-EF, HDX, AND SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MARCH 17, 2009, THROUGH DECEMBER 7, 2009, EQUIPPED WITH STABILUS BLOC-O-LIFT, P/N 5561ED, DRIVER SEATS. THE WELD WHICH HOLDS THE MOUNTING TAB TO THE SHOCK BODY WAS IMPROPERLY WELDED AND CAN BREAK.

Safety consequence

THE SEAT COULD DROP UNEXPECTEDLY WITHOUT PRIOR WARNING AND COULD CAUSE MOMENTARY LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED THOMAS BUILT BUSES SERVICE FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

SEATS

NHTSA #10V487000

Reported October 14, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 6 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN THOMAS BUILT MVP-EF AND HDX NON SCHOOL BUSES MANUFACTURED FROM MARCH 17, 2009, THROUGH DECEMBER 7, 2009, EQUIPPED WITH STABILUS BLOC-O-LIFT, P/N 5561ED, DRIVER SEATS. THE WELD WHICH HOLDS THE MOUNTING TAB TO THE SHOCK BODY WAS IMPROPERLY WELDED AND CAN BREAK.

Safety consequence

THE SEAT COULD DROP UNEXPECTEDLY WITH OUT PRIOR WARNING AND COULD CAUSE MOMENTARY LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.

Manufacturer remedy

Notes

ENGINE AND ENGINE COOLING

NHTSA #10V397000

Reported September 3, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 66 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 MVP-EF NON SCHOOL BUSES MANUFCATURED FROM SEPTEMBER 12, 2008 THROUGH JULY 16, 2010, EQUIPPED WITH THE MEGAFUSE JUNCTION BOX. ON AFFECTED VEHICLES THE MEGAFUSE JUNCTION BOX IS LOCATED IN AN AREA EXPOSED TO EXCESSIVE ROAD SPLASH AND SPRY. IN SOME APPLICATIONS THE CABLE CONNECTIONS MAY CORRODE RAPIDLY. IF UNDETECTED, EXTREME CORROSION MAY CAUSE A POWER CABLE TO BECOME SEPARATED FROM THE POWER SOURCE RESULTING IN AN UNEXPECTED ENGINE SHUTDOWN OR LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS.

Safety consequence

UNEXPECTED ENGINE SHUTDOWN OR A LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS IN CERTAIN TRAFFIC CONDITIONS COULD INCREASE THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

DAIMLER TRUCKS WILL REPLACE THE MEGA FUSE JUNCTION BLOCK AND ELECTRICAL BOX FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

ENGINE AND ENGINE COOLING

NHTSA #10V396000

Reported September 3, 2010 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 1,117 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 MVP-EF THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 12, 2008 THROUGH JULY 16, 2010, EQUIPPED WITH THE MEGAFUSE JUNCTION BOX. ON AFFECTED VEHICLES THE MEGAFUSE JUNCTION BOX IS LOCATED IN AN AREA EXPOSED TO EXCESSIVE ROAD SPLASH AND SPRY. IN SOME APPLICATIONS THE CABLE CONNECTIONS MAY CORRODE RAPIDLY. IF UNDETECTED, EXTREME CORROSION MAY CAUSE A POWER CABLE TO BECOME SEPARATED FROM THE POWER SOURCE RESULTING IN AN UNEXPECTED ENGINE SHUTDOWN OR LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS.

Safety consequence

UNEXPECTED ENGINE SHUTDOWN OR A LOSS OF VEHICLE LIGHTING AND WINDSHIELD WIPERS IN CERTAIN TRAFFIC CONDITIONS COULD INCREASE THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

DAIMLER TRUCKS WILL REPLACE THE MEGA FUSE JUNCTION BLOCK AND ELECTRICAL BOX FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 13, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Notes

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

NHTSA #09V462000

Reported December 1, 2009 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 5,082 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 THOMAS BUILT MVP-EF SCHOOL BUSES MANUFACTURED FROM FEBRUARY 15, 2005 THROUGH NOVEMBER 23, 2009. THE ACCELERATOR PEDAL MAY BECOME WEDGED AGAINST THE SCUFF PLATE AND BECOME STUCK IN FULL THROTTLE POSITION.

Safety consequence

A STUCK ACCELERATOR PEDAL MAY INCREASE THE RISK OF A CRASH.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL RAISE THE ACCELERATOR PEDAL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 17, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Notes

DAIMLER TRUCKS' CAMPAIGN NUMBER IS FL-570.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

OTHER:SCHOOL BUS STOP ARM ASSEMBLY

NHTSA #09V394000

Reported October 2, 2009 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 2,922 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009-2010 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 31, 2008 AND FEBRUARY 18, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.

Safety consequence

SHOULD THE LED LIGHTS STOP FUNCTIONING, VISIBILITY OF A STOPPED BUS WOULD BE DECREASED, POSSIBLY ENDANGERING A CHILD OR PEDESTRIAN TO INJURY BY PASSING VEHICLES.

Manufacturer remedy

THOMAS BUILT WILL NOTIFY OWNERS AND LIGHT KITS WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 3, 2010. OWNERS MAY CONTACT THOMAS BUILT AT 1-800-547-0712.

Notes

DAIMLER TRUCKS RECALL NO. FL-562.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

STRUCTURE

NHTSA #09V287000

Reported July 23, 2009 · DAIMLER TRUCKS NORTH AMERICA

Potentially affected: 35 vehicles

Defect description

DAIMLER TRUCKS IS RECALLING 35 MODEL YEAR 2010 MVP-EF AND HDX THOMAS BUILT TRANSIT BUSES MANUFACTURED FROM OCTOBER 22, 2008 THROUGH MARCH 25, 2009 THE EMERGENCY EXIT PUSH-OUT WINDOW MAY BE INSTALLED IMPROPERLY RESULTING IN BINDING OF THE WINDOW.

Safety consequence

IN THE EVENT OF AN EMERGENCY EVACUATION, BINDING EMERGENCY EXIT WINDOWS MAY DELAY EVACUATION AND MAY INCREASE THE RISK OF PERSONAL INJURY TO THE VEHICLE OCCUPANTS.

Manufacturer remedy

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DAIMLER TRUCKS DEALERSHIPS. THE SAFETY RECALL BEGAN ON NOVEMBER 5, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712 OR THOMAS BUILT CUSTOMER SUPPORT OFFICE AT 1-336-889-4871.

Notes

DAIMLER TRUCKS RECALL CAMPAIGN NO. FL-555.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

Other Thomas Built Buses MVP-EF model years

Check your 2010 Thomas Built Buses MVP-EF VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Thomas Built Buses MVP-EF at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Thomas Built Buses VIN