1998 Subaru Impreza Recalls & Complaints

Incident: September 1, 2016 · Filed: September 6, 2017

AIR BAG RECALL AND IMPENDING SUIT AGAINST AIR BAG COMPANY

Incident: September 12, 2006 · Filed: September 14, 2006

98 SUBARU IMPREZA 2.5RS. I HAD THE HEAD GASKETS REPLACED UNDER WARRANTY THE FIRST TIME . AROUND A YEAR AFTER THAT,THE CAR OVER HEATED AGAIN. I HAD IT TOWED TO A AUTO REPAIR SHOP THAT I WORKED AT AND HAD THEM TEST THE CAR TO SEE THE PROBLEM. IT WAS A BLOWN HEAD GASKET AGAIN. THEY DETERMINED THIS BY TESTING FOR ANY EMISSIONS IN THE COOLANT. THERE WAS ALSO A LARGE AMOUNT OF SLUDGE BUILD UP IN THE COOLANT RESERVOIR(OIL)AS WELL. SUBARU WOULD NOT WARRANTY THERE ORIGINAL WORK SO THE CAR SAT FOR A BIT BEFORE I COULD AFFORD TO HAVE IT FIXED. WHEN I SAVED UP SOME MONEY FOR THE REPAIR, I BROUGHT IT TO THE SUBARU DEALER TO HAVE THEM DO THE WORK ON IT. I WAS EXTREMELY UPSET WITH THE WORK THEY DID BUT GOT THE CAR BACK WITH A FUNCTIONAL ENGINE. NOT MORE THAN A YEAR AND A HALF LATER, THE SAME THING HAPPEN(OVERHEAT). AGAIN, I PULLED OVER RIGHT AWAY TO LIMIT ANY FURTHER DAMAGE TO THE ENGINE. AT THAT POINT, I HAD THE CAR TOWED TO MY HOME AND IT SAT FOR ABOUT A YEAR BEFORE THE BAD CHOICE TO REPAIR IT AGAIN. THIS TIME I SENT IT TO BOFFO AUTO REPAIR. THEY RECOMMENDED A NEW MOTOR BECAUSE THE LAST TIME THE "HEADS" HAD BEEN DONE, THEY MILLED THE HEADS SMOOTH AND NEW "HEADS" WERE NOT TO FAR OF THE PRICE OF A USED ENGINE. BOFFO FINALLY FOUND A USED ENGINE FOR MY CAR THAT APPARENTLY IS VERY DIFFICULT TO FIND. THE ENGINE HAD 32K ON IT AND WAS REPORTED TO HAVE BEEN CHECKED OVER AS A SAFE,RELIABLE MOTOR. AFTER SPENDING OVER $4000 THIS TIME AROUND, I HAD A WORKING CAR AGAIN. THE CAR CAME BACK TO ME NOT EVEN 3 MONTHS AGO. THE ENGINE OVER HEATED "AGAIN" THE OTHER DAY AND AGAIN I HAVE A HEAD GASKET LEAK(OIL INTO THE COOLANT). I HAVE BEEN LOOKING ON THE INTERNET ABOUT THIS PROBLEM AND IT SEEMS TO BE A BIG ONE ON THE 98 VEHICLE. I FOUND OUT THAT THEY ONLY MADE THAT MOTOR FOR THE MODEL YEAR 98 ONLY. WHY IS THIS? I HAVE BEEN INFORMED BY A SUBARU EMPLOYEE BECAUSE OF THE HEAD GASKET PROBLEM. I NEED YOUR HELP. I HAVE CONTACTED AN ATTORNEY THIS MORNING AND WILL HAVE HIM GET IN TOUCH WITH SUBARU. *NM

Incident: March 15, 2001 · Filed: February 13, 2005

HEAD GASKET FAILURE ENGINE OVERHEATED ON 16 HOUR TRIP.. TOOK TO SUBARU DEALERSHIP, THEY PUT IN A NEW "STARTER BOLT" STATED IT WAS A BAD GROUND?? ON RETURN HOME CAR OVER HEATED AGAIN.. WAS REPAIRED BY SUBARU, TECH SAID IT WAS COMMON. 2ND HEAD GASKET FAILURE, TWO MONTHS LATER, OIL IN ANTIFREEZE... DRIVING 55-65 MPH FOR 10 MIN IN 75-80F WEATHER, NOT UNDER HARD ACCELERATION. FEAR THAT IT WILL HAPPEN AGAIN. CURRENT RECALL ON 99-01 MODELS FOR "COOLANT ADDITIVE". POOR HEAD GASKET DESIGN IS LEADING TO FAILURE... SEEMS TO BE COMMON PROBLEM ON 98'S (2.5RS DOHC EJ25 PHASE 1) *JB

Incident: June 4, 2004 · Filed: August 10, 2004

INTERMITTENT FAILURE/SHORT OF POWER TO THE MAIN COMPUTER (ECU) AT APPOX. 120K MILES. CAR WOULD NOT START, NO CHECK-ENGINE LIGHT. AFTER WAITING FOR TOW TRUCK, IT STARTS AND RUNS FINE. TOOK TO MECHANIC, AND HE SAYS NOTHING WRONG. TWO WEEKS LATER, SAME THING. HOOK UP OBD II MONITOR AND IT SAYS ECU RECIEVING "NO PWR." TOWED TO SHOP. MECHANIC DIAGNOSED AS FAILED ECU AND REPLACED. TWO WEEKS LATER, SAME SYMPTOMS (NO CHECK ENGINE LIGHT, "NO PWR" ON OBD II MONITOR), BUT AN HOUR LATER CAR STARTED FINE AND OBD II SHOWED NO PROBLEMS. TOOK TO MECHANIC WHO FOUND NOTHING WRONG. HAPPENED AGAIN A WEEK LATER, MECHANIC FINDS NOTHING. TWO WEEKS AFTER THAT, FAILED AGAIN, WOULD NOT START AFTER MANY DAYS AND STILL SAYS "NO PWR." TOWED TO MECHANIC, AND ONCE IT GOT TO SHOP, STARTED FINE -- MOVEMENT DURING TOWING CAUSED POWER TO BE RESTORED TO ECU. THUS, IT'S A SHORT IN THE POWER PATH THAT RUNS THE ECU. MECHANIC CANNOT FIND PROBLEM. MECHANIC DISMANTLED FUSEBOXES AND FINDS NO APPARENT SIGNS OF SHORT ANYWHERE. SAYS IT'S A "SUBARU BUG." COST TO DATE: APPOX. $2000, AND NOT YET FIXED.

Incident: December 15, 2003 · Filed: July 16, 2004

THE ENGINE KEPT OVERHEATING AND AIR WOULD APPEAR IN THE RADIATOR. ANTIFREEZE WOULD BE PUSHED OUT OF RADIATOR AND THE HEATER WOULD BLOW COLD AIR. THE CAR HAD TO BE SHUT OFF REPEATEDLY AND ALLOWED TO COOL DOWN AND THE ANTIFREEZE REPLACED. A CHECK OF THE COOLING SYSTEM DETECTED NO LEAKS. WE WERE TOOK THE CAR TO A NUMBER OF GARAGES UNTIL FINALLY ONE GARAGE TOLD US THAT THE ENGINE BLOCK WAS MOST LIKELY CRACKED AND THE ENGINE NEEDED TO BE REPLACED AT A COST OF $3600. ACCORDING TO THE GARAGE, THEY HAVE REPLACED A NUMBER OF ENGINES FOR THIS PARTICULAR MODEL, SPECIFICALLY ONE WITH THE DOHC.*AK

Incident: June 17, 2004 · Filed: June 17, 2004

1998 SUBARU IMPREZA 53,000 MILES AND THE AUTO TECH AT SUBARU SAYS I HAVE A PISTON SLAP, $2500.00 TO PULL ENGINE AND CHECK THIS OUT. I HAVE CHANGED OIL EVERY 3,000 MILES BROUGHT IT IN FOR THE 30,000 MILEAGE OVER ALL CHECK UP - WHAT IS UP WITH THIS MOTOR? *JB

Incident: September 15, 2003 · Filed: January 15, 2004

THIS CAR NEEDED REPLACEMENT OF BOTH REAR WHEEL BEARINGS AT SLIGHTLY OVER 67,000 MILES. NO OTHER SUBARU I HAVE OWNED OR HEARD OF NEEDED SUCH REPAIRS. MY PREVIOUS SUBARU HAD OVER 100,000 MILES ON IT WITH NO DEFECTS. THE SHOP PERSONEL AT THE DEALER SAID THIS WAS A PROBLEM WITH SOME OTHER IMPREZAS, AS WELL AS FORESTERS. I WROTE A LETTER TO SUBARU AMERICA, AFTER SIX DAYS I HAVEN'T RECIEVED ANY RESPONSE. I INCLUDED A COPY OF MY REPAIR BILL AS WELL AS MY RENTAL CAR FEES.

Incident: January 4, 2003 · Filed: May 18, 2003

ENGINE STALLS WHEN TRYING TO TAKE OFF AFTER STOPPING AT TRAFFIC LIGHT. THERE IS ALSO A RAPPING NOISE IN ENGINE UNTIL ITS BEEN RUNNING AWHILE. *JB

Incident: February 26, 2003 · Filed: February 28, 2003

THE WHEEL BEARINGS FAILED PREMATURELY.*JB

Incident: January 21, 2000 · Filed: January 15, 2003

TRANSFER CLUTCH ON THE POWERTRAIN OF MY 1998 SUBARU IMPREZA BUCKS AND BINDS IN TURNS, APPARENTLY DUE TO THE TRANSFER CLUTCH HANGING UP AND STAYING APPLIED. THIS HAS OCCURRED AT LEAST SINCE THE 50,000 MILE MARK AND CONTINUES TO DATE. DESPITE THIS PROBLEM FALLING UNDER SUBARU'S POWERTRAIN WARRANTY, TWO SEPARATE SUBARU DEALERS HAVE REFUSED TO FIX IT UNDER WARRANTY, AND INSTEAD HAVE "ADDED LIMITED SLIP DIFFERENTIAL ADDITIVE" TO THE DIFFERENTIAL-A FIX I HAVE BEEN TOLD BY ANOTHER SUBARU DEALER IS NOT AN AUTHORIZED FIX FOR THIS PROBLEM. I AM NOW FACED WITH $900 IN REPAIR BILLS. THIS PROBLEM HAS BEEN PREVIOUSLY REPORTED FOR 1997 SUBARU IMPREZAS (NHTSA ITEM NUMBER SB053575).