2010 Ram 3500 Recalls & Complaints

Incident: September 15, 2024 · Filed: September 18, 2024

The contact owns a 2010 Dodge Ram 3500. The contact stated while driving approximately 30 MPH, the air bag warning light illuminated. The contact stated that the vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the driver's side air bag needed to be replaced. The mechanic informed the contact of NHTSA Campaign Number: 16V947000 (Air Bags). The contact called a dealer and was informed that the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,000.

Incident: July 1, 2023 · Filed: December 5, 2023

The contact owns a 2010 Dodge Ram 3500. The contact stated that while driving at various speeds, the vehicle shut off without warning. The contact stated that the failure occurred after driving over a bump in the roadway. The contact stated that occasionally, while wiggling the ignition key the engine would turn on before shutting off. The vehicle was taken to the local dealer who determined that the ignition switch was faulty and needed to be replaced. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 14V373000 (Electrical System). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 270,000.

Incident: June 12, 2022 · Filed: June 12, 2022

Fobik key ignition vibrates causing switching from (RUN) position to (ACC) position, shutting off the engine and making it almost impossible to steer a 3000kg machine without power steering increasing the risk for accidents.

Incident: November 16, 2020 · Filed: November 22, 2021

Truck totally destroyed by spontaneous fire, suspected to be related to short in radio or dashboard. Assessment done by fire department and truck paid off by Progressive Insurance but no compensation for contents of truck. Truck in driveway, not running and fire damaged adjacent vehicle at cost of $7000 paid by vehicle owner and USAA insurance.

Incident: July 9, 2021 · Filed: July 30, 2021

My husband, our son, and I were traveling down the highway at about 60-65mph when we started hearing a low winding sound. Seconds later, before my husband could get the truck over to the shoulder of the road, there was a loud banging sound coming from underneath the truck that sounded like something was coming through the floorboard. He was finally able to get the truck pulled to the shoulder of the road but wasn't able to put the truck in the park position. He had to use the park brake to get the truck to completely stop. Once the tow truck safely lifted the truck, you could clearly see gears hanging amd what looked to be remains of the transfer case. The truck was towed to a body shop where several codes were discovered, which all pertained to the truck going into 4wd by itself without any warning and unknowing to the driver. This glitch is what appears to have caused the transfer case to grenade, further causing damage to the drive shaft and smashing the fuel line. We, as owners, had the transfer case serviced and fluids flushed just two weeks prior to this happening After further investigation and conversations with the local Dodge dealer, it appears that this has happened in several situations yet no safety recalls have been issued. There is a national backorder for transfer cases for our particular year which is a red flag. We're now left with an over $8100.00 bill and everyone pointing the finger at each other. This could have ended tragically had there been more traffic on the road when the truck began stalling on the busy interstate.

Incident: July 9, 2021 · Filed: July 21, 2021

My family and I were traveling down the interstate about 60-65mph in 2 wheel drive when out of nowhere we started hearing a whining/roaring noise that quickly got louder. Seconds later, there was a loud rumbling noise that sounded like something was coming through the floorboard of the truck. Luckily, I was able to steer the truck to the shoulder of the road and get it to stop, but the truck would not go into park. I had to use the park brake to make sure that it wouldn't roll. After the tow truck arrived and safely jacked the truck up, we immediately noticed that it was the transfer case that had exploded. Gears were hanging out in plain site and it caused a bend in my front driveshaft. There were no warning signs and I had just had the transfer case and my transmission serviced and flushed 2 weeks prior. This put my family's and other lives in danger because had there been more traffic on the road at the time this happened, I wouldn't have had time or room to maneuver my truck safely to get it off the road. We could have been rear ended or had broken parts fly off the truck, that would have been out of my control. The truck was towed to the shop where I had the transfer case serviced, but as of now there's a national backorder on transfer cases for this truck. In speaking with the dealer and doing my own research, I've also learned that there has been a recall on the transfer cases of 2016 and newer Ram 3500 trucks. This needs to be looked into asap. Codes pulled from the truck at the auto shop where the truck currently is are c1404, c1405, c140d stating that the transfer case motor puts the system in 4wd by itself while driving without any warning.

Incident: July 13, 2021 · Filed: July 13, 2021

WIN ignition module has slowly been causing difficult starting problems. Now, over even slight bumps, the sloppiness in the connection between the key and the WIN module allows the key to move and the vehicle to shut off while driving. This is becoming more and more common and is very dangerous. Just on my 10 minute drive home from work today, it occurred 4 times. One time, I had just turned right on a red light (with plenty of space between me and oncoming traffic) and the truck shut off completely. Without the key being in the exact right position, I had difficulty restarting the truck and could have been very dangerous to me and the vehicle coming toward me.

Incident: March 29, 2021 · Filed: March 29, 2021

WHILE DRIVING, THE TRUCK JUST SHUTS OFF. RESULTING IN LOSS OF STEERING, LIGHTS AND POWER BREAKS.

Incident: February 18, 2021 · Filed: February 23, 2021

DURING FUELING WITH THE VEHICLE STATIONARY, FUEL WILL SPILL OUT OF SPOUT WHEN TANK IS FULL AS FUEL DISPENSER SHUTS OFF. THIS HAPPENS ANY TIME VEHICLE IS FUELED.

Incident: September 26, 2020 · Filed: October 24, 2020

WHILE TRAVELING ON THE HIGHWAY AT APPROXIMATELY 75 MPH WITH A LOAD IN THE BED OF THE TRUCK AND TOWING A TRAILER, THE VEHICLE ENGINE STOPPED, ELIMINATING POWER STEERING AND POWER BRAKES. AFTE HAVING THE VEHICLE TOWED TO THE DEALER FOR DIAGNOSIS, IT WAS DETERMINED THAT THE CP$ HIGH PRESSURE FUEL PUMP HAD DISCINTEGRATED.