NHTSA vehicle safety data

2002 Pontiac Aztek Recalls, Ratings & Complaints

The 2002 Pontiac Aztek has 3 NHTSA recall campaigns and 121 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Pontiac dealer.

NHTSA recall and complaint data for the 2002 Pontiac Aztek, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2002 Pontiac Aztek owner complaints

Owners have filed 121 complaints with NHTSA about the 2002 Pontiac Aztek, describing incidents dated February 6, 2002 to April 7, 2017.

Most-cited components

Fuel/Propulsion System 27 complaints
Engine 24 complaints
Suspension 20 complaints
Electrical System 18 complaints
Service Brakes 16 complaints
Structure 11 complaints

Of the 121 complaints on file, 2 report a crash and 1 a fire; across all 121 complaints, owners report 2 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10971442 · Filed April 8, 2017
AS NOTED IN PREVIOUS STATEMENTS THIS VEHICLE IS DIFFICULTY AT STARTING AND CRANKING AT VARIOUS SITUATION. PLAYING THE RADIO WITH ENGINE OFF, MUST WAIT TEN MINUTES BEFORE ATTEMPTING TO START, THEN IT MAY CRANK OR YOU HAVE TO START OVER. ITS NOT THE RADIO ITS THE IGNITION LOCK CYLINDER AS DONE IN THE…
ODI #10905053 · Filed September 9, 2016
TL* THE CONTACT OWNS A 2002 PONTIAC AZTEK. AFTER REFUELING THE VEHICLE, IT WAS NOTICED THAT THE VEHICLE WAS LOSING FUEL FASTER THAN USUAL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK, FUEL PUMP, AND FUEL TANK LINES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS…
ODI #10870973 · Filed June 2, 2016
2002 PONTIAC AZTEK. CONSUMER WRITES IN REGARDS TO FUEL ODORS AND LEAKS BY THE FUEL TANK INLET. CONSUMERS INTERNET SEARCH FOUND AN EXPIRED RECALL BULLETIN FOR THE SAME ISSUE, REQUESTS ASSISTANCE WITH REPAIRS. *SMD THE CONSUMER NOTICED THE FUEL SMELL WAS STRONGER AFTER HE FILLED UP. *JB

Read all 121 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2002 Pontiac Aztek in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA07-006: FUEL TANK LEAKAGE
Closed September 13, 2007
- Recall 07V-349
Recall Query RQ06-009: FUEL TANK LEAKAGE
Closed April 18, 2007

Open and recently closed NHTSA defect investigations

FUEL TANK INLET CHECK VALVE WELD

NHTSA #07V349000 · Fuel System, Gasoline — Storage · NHTSA notice

Reported August 8, 2007 · GENERAL MOTORS CORP.

Potentially affected: 20,594 vehicles

Manufacturer campaign 06230 · Owners notified December 4, 2007 · Vehicles built June 1, 2001 – May 31, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Safety consequence

A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.

Notes

GM RECALL NO. 06230.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/FMVSS 225/OWNER'S MANUAL INFORMATION

NHTSA #03V250000 · Equipment — Other — Owners/Service/Other Manual · NHTSA notice

Reported July 15, 2003 · GENERAL MOTORS CORP.

Potentially affected: 1,707,825 vehicles

Manufacturer campaign 03039 · Owners notified August 20, 2003 · Vehicles built March 1, 2001 – June 30, 2002 (per NHTSA)

Defect description

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Safety consequence

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Notes

GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2002 Pontiac Aztek 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Safety Technology

2 investigations

121 owner complaints have been filed with NHTSA for the 2002 Pontiac Aztek.

Electrical System; Service Brakes; Engine

ODI #10971442

Incident: April 7, 2017 · Filed: April 8, 2017

AS NOTED IN PREVIOUS STATEMENTS THIS VEHICLE IS DIFFICULTY AT STARTING AND CRANKING AT VARIOUS SITUATION. PLAYING THE RADIO WITH ENGINE OFF, MUST WAIT TEN MINUTES BEFORE ATTEMPTING TO START, THEN IT MAY CRANK OR YOU HAVE TO START OVER. ITS NOT THE RADIO ITS THE IGNITION LOCK CYLINDER AS DONE IN THE PAST. IT DOESN'T MATTER, STOP, OR MOVING IT HAS DONE ALL YOU MENTION, AND WITH THE LIGHTS OFF AT NIGHT YOU CAN INJURED A PEDESTRIAN OR OURSELVES. THIS CAR WAS RECALL AND IT WAS SAID TO HAVE BEEN FIX BUT HERE WE STUCK HERE FROM 04/07/17 POSSIBLY WILL GET HELP FROM THE NEAREST GMC CAR DEALER ON 04/10/17. KEEP ALL THIS INFORMATION FOR OFFICIAL USED ONLY. THANKS UPDATED 05/17/17*LJ UPDATED 07/25/2017*JS

Fuel/Propulsion System

ODI #10905053

Incident: July 1, 2016 · Filed: September 9, 2016

TL* THE CONTACT OWNS A 2002 PONTIAC AZTEK. AFTER REFUELING THE VEHICLE, IT WAS NOTICED THAT THE VEHICLE WAS LOSING FUEL FASTER THAN USUAL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK, FUEL PUMP, AND FUEL TANK LINES FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,000.

Fuel System, Gasoline

ODI #10870973

Incident: January 1, 2016 · Filed: June 2, 2016

2002 PONTIAC AZTEK. CONSUMER WRITES IN REGARDS TO FUEL ODORS AND LEAKS BY THE FUEL TANK INLET. CONSUMERS INTERNET SEARCH FOUND AN EXPIRED RECALL BULLETIN FOR THE SAME ISSUE, REQUESTS ASSISTANCE WITH REPAIRS. *SMD THE CONSUMER NOTICED THE FUEL SMELL WAS STRONGER AFTER HE FILLED UP. *JB

Fuel/Propulsion System

ODI #10845724

Incident: February 16, 2016 · Filed: March 9, 2016

TL* THE CONTACT OWNS A 2002 PONTIAC AZTEK. THE CONTACT SMELLED A STRONG FUEL ODOR PRESENT IN THE VEHICLE WITHOUT WARNING. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. UPDATED 05/06/16*LJ THE CONSUMER STATED THERE WAS A FUEL LEAKING FROM THE VEHICLE WHENEVER THE IT WAS FILLED. THE CONSUMER WAS NOT INCLUDED IN THE RECALL DUE TO THE AGE OF THE VEHICLE. UPDATED 11/1/2017*JS

Electrical System

ODI #10780147

Incident: September 29, 2015 · Filed: October 6, 2015

TL* THE CONTACT OWNS A 2002 PONTIAC AZTEK. WHILE DRIVING 45 MPH, THE ALARM SYSTEM SOUNDED, THE LOCKS OPERATED ON THEIR OWN, AND THE TRUNK OPENED WITHOUT BEING PROMPTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 180,000.

Air Bags; Engine

ODI #10592684

Crash

Incident: March 31, 2014 · Filed: May 20, 2014

TL* THE CONTACT OWNS A 2002 PONTIAC AZTEK. THE CONTACT STATED WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT ANY WARNING AND CRASHED INTO A TREE. THE CONTACT MENTIONED THAT THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 192,000. THE CURRENT MILEAGE WAS 199,129. UPDATED 10/7/14*CN

Electrical System

ODI #10579226

Incident: April 30, 2010 · Filed: April 11, 2014

THE CAR KEY CAN BE REMOVED AFTER THE CAR HAS BEEN STARTED. THE VEHICLE CAN BE DRIVEN WITHOUT A KEY IN THE IGNITION. *JS

Fuel/Propulsion System

ODI #10544900

Incident: September 6, 2012 · Filed: September 23, 2013

2002 PONTIAC AZTEK WAS PARKED AND WAS IDLING. SMELLED STRONG ODOR OF FUEL. UPON EXAMINATION, FUEL WAS LEAKING PROFUSELY AROUND THE FILLER TUBE. TRIED TO HAVE IT SEALED BY A CERTIFIED MECHANIC. IT COULD NOT BE REPAIRED. TANK WILL LEAK OUT ANY FUEL QUANTITY OVER 3 US GALLON. IT DOES NOT LEAK WHEN KEPT UNDER THIS QUANTITY OF FUEL.

Service Brakes

ODI #10538336

Incident: July 25, 2013 · Filed: September 2, 2013

IN A HARD STOP IN STOP-AND-GO RUSH HOUR FREEWAY TRAFFIC, A CORRODED STEEL HYDRAULIC BRAKE LINE FAILED. THIS WAS THE LINE FROM THE ABS MODULE TO THE RIGHT FRONT BRAKE. AS SUCH IT IMMEDIATELY CAUSED A SUBSTANTIAL LOSS OF BRAKING ABILITY - I WAS IN THE FAR LEFT LANE AND I WAS ABLE TO ABRUPTLY MOVE TO THE LEFT SHOULDER. HAD I BEEN IN ONE OF THE CENTER LANES THERE WOULD HAVE BEEN A CRASH, IT WOULD HAVE BEEN UNAVOIDABLE, THE REAR BRAKES WERE STILL FUNCTIONAL AND I STILL HAD LIMITED BRAKING ABILITY. AT THE POINT THAT THIS LINE ACTUALLY BROKE, IT WAS SPRAYING BRAKE FLUID DIRECTLY ON THE EXHAUST SYSTEM. I AM NOT CERTAIN WHETHER THERE WAS A FIRE, THE MECHANIC SAYS THERE MAY HAVE BEEN. THERE CERTAINLY WAS A LOT OF SMOKE. THE LINE IN QUESTION IS SECURED TO THE FIREWALL AND IS ROUTED CLOSE TO THE EXHAUST AT THAT POINT. IT APPEARS THAT OVER TIME THIS COMBINATION ALLOWS CORROSION TO WEAKEN THE LINE AT THIS PARTICULAR POINT. THE REMAINING LINES ON THIS VEHICLE ARE IN GOOD CONDITION AND I BELIEVE THEY WILL LAST THE LIFE OF THE VEHICLE. *JS

Engine

ODI #10509525

Incident: March 31, 2013 · Filed: April 25, 2013

TL* THE CONTACT OWNS A 2002 PONTIAC AZTEK. THE CONTACT STATED THAT THE ENGINE OVERHEATING LIGHT ILLUMINATED WHILE SHE DROVE AT 50 MPH. THE VEHICLE WAS TOWED TO THE MECHANIC WHO LOCATED THE FAILURE AT THE HEAD GASKET AND THE INTAKE MANIFOLD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 127,000.

Other Pontiac Aztek model years

Check your 2002 Pontiac Aztek VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Pontiac Aztek at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Pontiac VIN