NHTSA vehicle safety data

2001 Pontiac Aztek Recalls, Ratings & Complaints

The 2001 Pontiac Aztek has 6 NHTSA recall campaigns and 216 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Pontiac dealer.

NHTSA recall and complaint data for the 2001 Pontiac Aztek, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2001 Pontiac Aztek owner complaints

Owners have filed 216 complaints with NHTSA about the 2001 Pontiac Aztek, describing incidents dated October 16, 2000 to May 2, 2019.

Most-cited components

Electrical System 40 complaints
Fuel/Propulsion System 39 complaints
Service Brakes 29 complaints
Engine 28 complaints
Equipment 28 complaints
Air Bags 26 complaints

Of the 216 complaints on file, 14 report a crash and 6 a fire; across all 216 complaints, owners report 18 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11209417 · Filed May 23, 2019
BOUT 3 WEEKS AGO CAR JUST KEEP ACTING UP HAD IT FOR ONE YEAR CANT READ CODES ON CAR KEEP OVERHEATING REPLACED RADIATOR CVL AXLE BRAKES OIL CHANGE TRANSMISSION FLUID CAR JUST DECIDED TO NOT PASS 50MPH BE DRIVEABLE ONE DAY DRIVING IT WENT TO A STOP SIGN BRAKE CAR CUT OFF I SEE CHECK GAUGES COME ON…
ODI #11090947 · Filed April 30, 2018
I HAVE REPLACE 2 IGNITION SWITCHES, AND STILL HAVING PROBLEMS..THE KEY WILL NOT COME OUT/UNLOCK WHEN SWITCHING CAR OFF..WHICH KILLS THE BATTERY BECAUSE I CAN'T TURN OFF THE CAR THIS IS TERRIBLE ..IT'S THE IGNITION SWITCH OR THE STEERING COLUMN, THIS HAPPENS WHEN PUTTING THE CAR IN PARK!!!!KEY WILL…
ODI #10945461 · Filed January 16, 2017
GM HAS ISSUED A SAFETY BULLETIN IN REGARDS TO A BROKEN FUEL TANK THAT COULD CAUSE EXPLOSIONS, OR FIRE. I HAVE TRIED TO GET THEM TO PERFORM THE REPAIR BUT THEY ARE REFUSING. THE PROBLEM IS FOR ALL YEARS OF THE PONTIAC AZTEK AND BUICK RENDEZVOUS. I HAVE A LEAK FROM THIS LOCATION, THE FUEL INLET, AND…

Read all 216 complaints

Owner-reported

2001 Pontiac Aztek mileage at failure

118 of the 216 complaints on file for the 2001 Pontiac Aztek give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Fuel/Propulsion System	Median 75,000 miles	Middle half 50,000–110,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2001 Pontiac Aztek in 2 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA07-006: FUEL TANK LEAKAGE
Closed September 13, 2007
- Recall 07V-349
Recall Query RQ06-009: FUEL TANK LEAKAGE
Closed April 18, 2007

Open and recently closed NHTSA defect investigations

FUEL TANK INLET CHECK VALVE WELD

NHTSA #07V349000 · Fuel System, Gasoline — Storage · NHTSA notice

Reported August 8, 2007 · GENERAL MOTORS CORP.

Potentially affected: 20,594 vehicles

Manufacturer campaign 06230 · Owners notified December 4, 2007 · Vehicles built May 1, 2000 – October 31, 2001 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).

Safety consequence

A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.

Notes

GM RECALL NO. 06230.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

AFTERMARKET FUEL PRESSURE REGULATORS

NHTSA #07E021000 · Fuel System, Other — Storage — Tank Assembly — Pressure Relief Devices · NHTSA notice

Reported March 12, 2007 · DELPHI

Potentially affected: 742 vehicles

Owners notified April 27, 2007

Defect description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Safety consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Manufacturer remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET DELPHI FUEL PRESSURE REGULATORS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED BY GENERAL MOTORS.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

GM/FMVSS 225/OWNER'S MANUAL INFORMATION

NHTSA #03V250000 · Equipment — Other — Owners/Service/Other Manual · NHTSA notice

Reported July 15, 2003 · GENERAL MOTORS CORP.

Potentially affected: 1,707,825 vehicles

Manufacturer campaign 03039 · Owners notified August 20, 2003 · Vehicles built February 1, 2000 – October 31, 2001 (per NHTSA)

Defect description

CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.

Safety consequence

THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Manufacturer remedy

OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.

Notes

GM RECALL NO. 03039.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/PASSENGER AIR BAG MISSING CHECK VALVE PIN

NHTSA #02V329000 · Air Bags — Frontal · NHTSA notice

Reported December 9, 2002 · GENERAL MOTORS CORP.

Potentially affected: 272 vehicles

Manufacturer campaign 02061 · Owners notified December 16, 2002 · Vehicles built September 1, 2000 – March 30, 2001 (per NHTSA)

Defect description

ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.

Safety consequence

THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.

Manufacturer remedy

DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.

Notes

GM RECALL NO. 02061. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/FMVSS 225/SEAT LATCH ANCHOR WIRE

NHTSA #01V383000 · Seats — Front Assembly — Recliner · NHTSA notice

Reported December 13, 2001 · GENERAL MOTORS CORP.

Potentially affected: 75,816 vehicles

Manufacturer campaign 01077 · Owners notified April 10, 2002 · Vehicles built April 1, 2000 – October 31, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.

Safety consequence

IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

GM/AIR BAG INFLATOR MODULE

NHTSA #01V026000 · Air Bags — Frontal · NHTSA notice

Reported February 1, 2001 · GENERAL MOTORS CORP.

Potentially affected: 38 vehicles

Manufacturer campaign 01004 · Owners notified January 29, 2001 · Vehicles built July 1, 2000 – July 31, 2000 (per NHTSA)

Defect description

VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.

Safety consequence

IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.

Manufacturer remedy

DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.

Notes

ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2001 Pontiac Aztek 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 3, Passenger: 4

Side Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Pole

Not Rated

Rollover

Safety Technology

2 investigations

216 owner complaints have been filed with NHTSA for the 2001 Pontiac Aztek.

Electrical System; Vehicle Speed Control; Fuel/Propulsion System

ODI #11209417

Incident: May 2, 2019 · Filed: May 23, 2019

BOUT 3 WEEKS AGO CAR JUST KEEP ACTING UP HAD IT FOR ONE YEAR CANT READ CODES ON CAR KEEP OVERHEATING REPLACED RADIATOR CVL AXLE BRAKES OIL CHANGE TRANSMISSION FLUID CAR JUST DECIDED TO NOT PASS 50MPH BE DRIVEABLE ONE DAY DRIVING IT WENT TO A STOP SIGN BRAKE CAR CUT OFF I SEE CHECK GAUGES COME ON SERVICE LIGHT ON CANT READ CODES TO FIND OUT ANYTHING I THINK THE WIRING IS MESS UP REPLACED STARTED AS WELL JUST TO MUCH ONLY HAD IT FOR A 1AND A HALF

Unknown or Other

ODI #11090947

Incident: April 26, 2018 · Filed: April 30, 2018

I HAVE REPLACE 2 IGNITION SWITCHES, AND STILL HAVING PROBLEMS..THE KEY WILL NOT COME OUT/UNLOCK WHEN SWITCHING CAR OFF..WHICH KILLS THE BATTERY BECAUSE I CAN'T TURN OFF THE CAR THIS IS TERRIBLE ..IT'S THE IGNITION SWITCH OR THE STEERING COLUMN, THIS HAPPENS WHEN PUTTING THE CAR IN PARK!!!!KEY WILL NOT TURN CAR OFF/CAN'T GET KEY OUT TOO

Fuel/Propulsion System

ODI #10945461

Incident: January 14, 2017 · Filed: January 16, 2017

GM HAS ISSUED A SAFETY BULLETIN IN REGARDS TO A BROKEN FUEL TANK THAT COULD CAUSE EXPLOSIONS, OR FIRE. I HAVE TRIED TO GET THEM TO PERFORM THE REPAIR BUT THEY ARE REFUSING. THE PROBLEM IS FOR ALL YEARS OF THE PONTIAC AZTEK AND BUICK RENDEZVOUS. I HAVE A LEAK FROM THIS LOCATION, THE FUEL INLET, AND AM NEARLY AFRAID TO DRIVE THE VEHICLE, BUT AT A COST OF OVER 2000 DOLLARS, GM IS ALSO INFLATING THE COST BECAUSE THEY KNOW THE REPAIR NEEDS TO BE DONE.

Electrical System

ODI #10851496

Incident: March 24, 2016 · Filed: March 24, 2016

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE VEHICLE FAILED TO START WITHOUT WARNING. THE CONTACT CHARGED THE BATTERY AND STARTED THE VEHICLE, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT IT WAS NOT A BATTERY ISSUE. THE TECHNICIAN SUSPECTED AN IGNITION FAILURE AND PLANNED TO RUN A DIAGNOSTIC TEST THE FOLLOWING DAY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000.

Air Bags

ODI #10731393

Incident: June 30, 2015 · Filed: June 30, 2015

THE DRIVER SIDE SEAT AIRBAG DEPLOYED AFTER THE DRIVER SHUT THEIR DOOR, WHILE THE CAR WAS IN PARK.

Air Bags

ODI #10714071

Incident: May 1, 2015 · Filed: May 1, 2015

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. WHILE ATTEMPTING TO CLOSE THE DOOR, THE AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

Electrical System; Service Brakes

ODI #10700603

Crash 1 injury

Incident: October 1, 2014 · Filed: March 20, 2015

THE CAR WAS PARK! THE KEYS IN, I PULLED KEYS OUT N THE CAR ROLLED BACKWARDS I HOP IN THE CAR N TURN THE WHEEL AND I FLEW OUT AND THE CAR RAN ME OVER TIRE ON MY BACK THE CAR DIDN'T STOP I PUSHING THE BRAKES NOTHING! *TR

Fuel System, Gasoline

ODI #10610949

Incident: May 12, 2011 · Filed: July 16, 2014

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO INDICATE THE AMOUNT OF FUEL THAT WAS STORED IN THE FUEL TANK AFTER IT WAS REFUELED. NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSE THAT THE FUEL GAUGE FLOATER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

Suspension

ODI #10610945

Incident: February 13, 2014 · Filed: July 16, 2014

TL* THE CONTACT OWNS A 2001 PONTIAC AZTEK. THE CONTACT STATED THAT AFTER REVERSING OUT OF A DRIVE WAY, THE VEHICLE MADE A LOUD NOISE AS THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS PLACED INTO PARK AND THE IGNITION WAS TURNED OFF. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT A ROUND OBJECT FELL FROM UNDER THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSE THAT THE POWER STEERING FAILED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE 100,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

Steering; Electrical System

ODI #10609503

Incident: May 21, 2014 · Filed: July 10, 2014

THE KEY CAN BE PULLED OUT OR FALL OUT OF THE IGNITION CYLINDER WITH ALMOST NO RESISTANCE IN THE RUN POSITION, AND DOOR AJAR, KEYS IN IGNITION CHIMES NO LONGER OPERATE AFTER FIRST OCCURRENCE OF KEY FALLOUT. KEY FALLOUT OCCURS EASIER AS TIME GOES ON, I AM UNSURE OF THE EXACT DATE OF FIRST OCCURRENCE. *TR

Other Pontiac Aztek model years

Check your 2001 Pontiac Aztek VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Pontiac Aztek at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Pontiac VIN