NHTSA vehicle safety data

2005 Lexus ES330 Recalls, Ratings & Complaints

The 2005 Lexus ES330 has 2 NHTSA recall campaigns and 141 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Lexus dealer.

NHTSA recall and complaint data for the 2005 Lexus ES330, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2005 Lexus ES330 owner complaints

Owners have filed 141 complaints with NHTSA about the 2005 Lexus ES330, describing incidents dated September 9, 2004 to February 28, 2019.

Most-cited components

Vehicle Speed Control 51 complaints
Power Train 43 complaints
Air Bags 17 complaints
Service Brakes 13 complaints
Engine 12 complaints
Electrical System 8 complaints

Of the 141 complaints on file, 34 report a crash and 2 a fire; across all 141 complaints, owners report 18 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11210572 · Filed May 29, 2019
PASSENGER SEAT AIRBAG SENSOR LIGHT ON WHEN SEATED
ODI #11183306 · Filed February 28, 2019
THIS IS SIMILAR TO THE COMPLAIN ANOTHER CAR OWNER HAS FILED. MY CAR WAS PURCHASED NEW FROM THE LEXUS OF PLEASONTON,CA DEALERSHIP. I HAVE HAD NO MAJOR ACCIDENT OR NO AIRBAG DEPLOYMENT. CAR HAS BEEN LIGHTLY USED WITH 80K MILES ON THE ODOMETER CURRENTLY. THE AIRBAG CONTAINER ON THE PASSENGER DASH HAS…
ODI #11180923 · Filed February 18, 2019
THIS CAR WAS PURCHASED FROM THE LEXUS OF MEMPHIS DEALERSHIP AS USED IN 2010. I HAVE HAD NO ACCIDENTS OR AIRBAG DEPLOYMENT. I AM.NOT AWARE OF ANY A EVIDENT HISTORY FROM THE PREVIOUS OWNER. THE AIRBAG CONTAINER ON THE PASSENGER DASH HAS PROGRESSIVELY CRACKED AT THE TOPICAL SEAMS OVER TIME. I HAVE BEEN…

Read all 141 complaints

Owner-reported

2005 Lexus ES330 mileage at failure

103 of the 141 complaints on file for the 2005 Lexus ES330 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Vehicle Speed Control	Median 25,000 miles	Middle half 8,000–50,000 miles	Based on 41 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2005 Lexus ES330 in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Defect Petition DP05-002: VEHICLE SPEED CONTROL
Closed January 5, 2006

Open and recently closed NHTSA defect investigations

CRANKSHAFT PULLEY

NHTSA #11V539000 · Engine and Engine Cooling · NHTSA notice

Reported November 9, 2011 · Toyota Motor Engineering & Manufacturing

Potentially affected: 420,326 vehicles

Owners notified December 31, 2011 · Vehicles built June 1, 2004 – March 31, 2005 (per NHTSA)

Defect description

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Safety consequence

IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

TOYOTA/SEATBELT BUCKLE STATUS SWITCH

NHTSA #04V595000 · Seat Belts — Front — Buckle Assembly · NHTSA notice

Reported December 15, 2004 · TOYOTA MOTOR NORTH AMERICA, INC.

Potentially affected: 150,061 vehicles

Manufacturer campaign SSC 40M · Owners notified December 20, 2004 · Vehicles built July 23, 2003 – September 2, 2004 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A FRONT PASSENGER POWER SEAT, WHEN INSTALLING CERTAIN REAR-FACING INFANT CHILD SEAT BASES ONTO THE SEAT WITH AN EXCESSIVELY HIGH SEATBELT TENSION, IT MAY BE POSSIBLE TO UNSEAT A COMPONENT CALLED THE BUCKLE STATUS SWITCH FROM THE SEAT BELT BUCKLE.

Safety consequence

IF THE SWITCH BECOMES UNSEATED, THE FRONT PASSENGER OCCUPANT CLASSIFICATION SYSTEM MAY MISTAKE THE REAR-FACING CHILD RESTRAINT FOR AN UNBELTED ADULT OCCUPANT, AND MAY NOT SUPPRESS THE DEPLOYMENT OF THE FRONT PASSENGER AIRBAG.

Manufacturer remedy

DEALERS WILL REPLACE THE FRONT PASSENGER SEATBELT BUCKLE STATUS SWITCH. THIS SAFETY IMPROVEMENT CAMPAIGN (SSC 40M) BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987..

Notes

THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT.

2005 Lexus ES330 4-DR. w/SAB

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: Not Rated, Passenger: Not Rated

Side Crash

Not Rated

Driver: 5, Passenger: 4

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

1 investigation

141 owner complaints have been filed with NHTSA for the 2005 Lexus ES330.

Air Bags; Seats

ODI #11210572

Incident: May 31, 2015 · Filed: May 29, 2019

PASSENGER SEAT AIRBAG SENSOR LIGHT ON WHEN SEATED

Air Bags

ODI #11183306

Incident: February 28, 2019 · Filed: February 28, 2019

THIS IS SIMILAR TO THE COMPLAIN ANOTHER CAR OWNER HAS FILED. MY CAR WAS PURCHASED NEW FROM THE LEXUS OF PLEASONTON,CA DEALERSHIP. I HAVE HAD NO MAJOR ACCIDENT OR NO AIRBAG DEPLOYMENT. CAR HAS BEEN LIGHTLY USED WITH 80K MILES ON THE ODOMETER CURRENTLY. THE AIRBAG CONTAINER ON THE PASSENGER DASH HAS PROGRESSIVELY CRACKED AT THE TOPICAL SEAMS OVER TIME. I HAVE BEEN TOLD AN AIRBAG SHOULD NOT LOOK LIKE THIS. I AM CONCERNED ABOUT AN UNTIMELY DEPLOYMENT AND IF THE CONTAINER WILL GET WORSE. AT NO TIME HAS THE AIRBAG BEEN MANIPULATED, REPAIRED, ETC SINCE MY OWNERSHIP.

Air Bags

ODI #11180923

Incident: September 15, 2010 · Filed: February 18, 2019

THIS CAR WAS PURCHASED FROM THE LEXUS OF MEMPHIS DEALERSHIP AS USED IN 2010. I HAVE HAD NO ACCIDENTS OR AIRBAG DEPLOYMENT. I AM.NOT AWARE OF ANY A EVIDENT HISTORY FROM THE PREVIOUS OWNER. THE AIRBAG CONTAINER ON THE PASSENGER DASH HAS PROGRESSIVELY CRACKED AT THE TOPICAL SEAMS OVER TIME. I HAVE BEEN TOLD AN AIRBAG SHOULD NOT LOOK LIKE THIS. I AM CONCERNED ABOUT AN UNTIMELY DEPLOYMENT AND IF THE CONTAINER WILL GET WORSE. AT NO TIME HAS THE AIRBAG BEEN MANIPULATED, REPAIRED, ETC SINCE MY OWNERSHIP.

Steering; Electronic Stability Control (ESC); Engine

ODI #11113561

Incident: July 24, 2018 · Filed: July 25, 2018

MY CHECK ENGINE LIGHT IS ON AND WHEN THE DIGANOISED CODE CHECK IS PERFORMED "NO CODES APPEAR," BUT I DO HAVE A POWER STEERING LEAKAGE AND I HEAR THE POWER STEERING NOISE WHEN I AM TURNING AND FROM THE RECALL 11V53900 11/09/2011 ENGINE AND ENGINE COOLING ITS A HUGE PROBLEM. I CALL CUSTOMER SERVICE AND THEY WHERE NO HELP! I CALLED FOR SERVICING AND THEY STATED ON MY VIN THERE IS NO RECALL BUT ON THE NHTSA THERE POPS UP THIS RECALL SO NO COOL. I AM GOING TO WAIT UNTIL SOMETHING HAPPENS AND SUE THE HELL OUT OF LEXUS FOR REFUSING TO SERVICE MY VEHICLE AND NEGLECTING THE ISSUES WHEN I CALLED AND ALL THE CALLS ARE RECORDED. TROUBLE & HORRIBLE SERVICE I AM NOT A SATISFIED CUSTOMER. I GUESS YOU NEED TO BE IN CERTAIN FINANCIAL BRACKET TO RECEIVE EXCEPTIONAL SERVICE.

Air Bags

ODI #11079927

Incident: March 2, 2015 · Filed: March 17, 2018

PASSENGER AIRBAG ON THE DASHBOARD IS OPENING, AND MY CAR HAS NEVER BEEN INVOLVED IN AN IMPACT.

Air Bags; Service Brakes

ODI #11039368

Crash

Incident: October 21, 2017 · Filed: October 24, 2017

TAMARA RECALL ON MY AIRBAGS,NEVER REPAIRED. I GOT INTO AN ACCIDENT AND AIRBAGS DIDN'T COME OUT. HAVE TO REPLACE BRAKES EVERY FEW MONTHS ON THIS CAR ALSO

Air Bags

ODI #11022269

Incident: August 15, 2017 · Filed: September 8, 2017

FRONT PASSENGER AIRBAG COVER APPEARS TO BE SEPARATED ALONG THE SEAM NEAR WINDSHIELD ON DASHBOARD AND THERE IS A WIDER GAP ON THAT SIDE VS THE SIDE CLOSEST PASSENGER. I'VE NOT SEEN THIS BEFORE IN ANY OF MY OTHER LEXUS VEHICLES AND IT'S CAUSE FOR CONCERN OF SAFETY AS A RESULT.

Air Bags

ODI #11019563

Incident: August 15, 2017 · Filed: August 25, 2017

TL* THE CONTACT OWNS A 2005 LEXUS ES330. THE CONTACT NOTICED THAT THE FRONT PASSENGER AIR BAG COVER WAS BULGING AND HAD SEPARATED ALONG THE SEAM NEAREST THE WINDSHIELD ON THE DASHBOARD. THE PASSENGER AIR BAG AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO BUTLER LEXUS OF SOUTH ATLANTA (LOCATED AT 4025 JONESBORO RD, UNION CITY, GA 30291, (678) 783-2703) WHERE IT WAS DIAGNOSED THAT THE PASSENGER AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 212,000. *TT *TR

Steering; Electrical System

ODI #10967246

Incident: March 18, 2017 · Filed: March 20, 2017

TL* THE CONTACT OWNS A 2005 LEXUS ES330. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART ON THE FIRST ATTEMPT AND WAS DRIVEN HOME. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE STEERING PUMP AND ALTERNATOR FAILED AND NEEDED TO BE REPLACED. IN ADDITION, THE CONTACT NEEDED TO REPLACE HER KEY WITH ANOTHER KEY CHIP. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

Electrical System

ODI #10916491

Incident: October 15, 2016 · Filed: October 17, 2016

MY COMPLAINT IS IN REGARD TO THE IGNITION SWITCH FOR MY 2005 LEXUS ES-330. WHILE TRYING TO START MY VEHICLE THE CASE THAT HOUSES THE KEY BROKE APART. THE KEY WAS STILL IN THE IGNITION, THE CAR RUNNING, BUT THE OTHER HALF OF THE CASE WAS DANGLING FROM THE KEY ITSELF.AFTER I WAS ABLE TO STOP THE ENGINE BY TURNING IT OFF WITH THE KEY ITSELF AND GATHERING UP ALL THE PARTS OF THE IGNITION SWITCH, UPON OBSERVATION I FOUND A VERY SMALL SCREW THAT SUPPOSEDLY WAS USED TO SECURE THE SWITCH CASE TOGETHER HAD BECOME LOOSE AND THEREFORE ALLOWED THE SWITCH CASE TO BREAK OPEN FROM THE PRESSURE NEEDED TO START THE ENGINE. WITH A LITTLE BIT OF GLUE AND TRANSPARENT TAPE I WAS ABLE TO START THE CAR AND DRIVE IT TO THE LOCAL LEXUS DEALER ON ATLANTIC BLVD.IN JACKSONVILLE, FL.THE SERVICE MANAGER SEEMED UNCONCERNED ABOUT MY PROBLEM, AND SPOKE MOSTLY ABOUT THE REDESIGNED SWITCH PRESENTLY AVAILABLE, AND WAS TOTALLY UNCONCERNED ABOUT MY PROBLEM. I ASKED ABOUT OTHERS WITH THE SAME TYPE KEY CASE AS MINE AND IF A REMEDY HAD BEEN TAKEN TO THE SECURING OF THE SMALL SCREW THAT HOLDS THE CASE TOGETHER, HE SAID NOT HIS KNOWLEDGE. I GUESS MY QUESTION IS SIMPLY WHY NOT? THE SERVICE MANAGER IS [XXX], I WAS TOLD BY HIM MY ONLY SOLUTION WAS TO PURCHASE ANOTHER KEY AS IF THE PROBLEM WAS MINE INSTEAD OF THE DEALERS.COULD THERE BE A SAFETY CONCERN HERE? I AM [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Other Lexus ES330 model years

Check your 2005 Lexus ES330 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Lexus ES330 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Lexus VIN