2020 Kia Telluride Recalls, Ratings & Complaints

Incident: October 25, 2026 · Filed: October 25, 2026

Batter drainage issue. Have paid for a new battery and I just bought the car 09/14/2026

Incident: October 18, 2026 · Filed: October 19, 2026

I am reporting a serious safety concern involving my 2020 Kia Telluride SX with approximately 129,000 miles. The vehicle began experiencing delayed starting followed by a very strong gasoline odor. I also heard a hissing sound that continued after the engine was turned off. Due to safety concerns, I had the vehicle towed to a repair facility rather than continuing to drive it. The repair shop subsequently confirmed a significant fuel leak with gasoline spraying and pooling underneath the vehicle, reportedly extending from the front toward the rear. I am extremely concerned about the potential fire hazard this condition presents especially because I had been operating the vehicle before discovering the severity of the leak. I am requesting that NHTSA investigate whether this fuel-system failure represents a broader safety issue affecting 2020 Kia Telluride vehicles.

Incident: October 7, 2026 · Filed: October 17, 2026

1. Incident & Vehicle Identification •Vehicle: 2020 Kia Telluride •Owner Name: [XXX] •Contact Phone: [XXX] •Kia Customer Care Case Number: XXX •NHTSA Safety Recall Number: 26V430 2. Description of Safety Hazard & Manufacturer Reimbursement Refusal Plaintext COMPLAINT REGARDING MANUFACTURER NON-COMPLIANCE WITH 49 CFR § 573.13 (REIMBURSEMENT FOR PRE-NOTIFICATION REMEDIES) STATEMENT OF FACT & CHRONOLOGY: 1. In XXX, my 2020 Kia Telluride experienced a dangerous, uncommanded driver's power seat failure. The seat drifted to the full-forward position without user input and the switch/assembly became stuck, preventing adjustment. 2. I took the vehicle to an authorized Kia dealership to address this safety hazard. The dealership diagnosed the issue and performed repairs out-of-pocket. 3. Subsequent to my repair, Kia issued an official NHTSA Safety Recall concerning the driver's power seat switch/fuse assembly, warning owners that the switch could stick, overheat, and cause a vehicle fire. 4. I submitted my repair receipt and dealership invoice to Kia for reimbursement under the federal General Reimbursement Plan. 5. On September 25, 2026, Kia Customer Care formally denied my claim (Case #26382986), stating: "Per the invoice received, the electronic fuse assembly was not installed. Reimbursement request denied." REGULATORY VIOLATION UNDER FEDERAL LAW: Under 49 CFR § 573.13(d)(2)(v)(A), federal safety standards stipulate that a manufacturer's reimbursement plan MUST cover repairs that addressed "the defect or noncompliance that led to the recall OR A MANIFESTATION OF THE DEFECT OR NONCOMPLIANCE." Kia is violating federal regulations by imposing an arbitrary constraint requiring the dealership's pre-recall repair invoice to match the specific part number or component description identified in the subsequent recall, rather than recognizing that the repair INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: November 8, 2024 · Filed: October 16, 2026

hi- I bought a used Kia Telluride (2020) and after 2 months it stalled out and after 2 different mechanics and a Kia dealership telling me it was fixed- it was not. The car basically had no oil left with zero light or warning. after doing some research, there are tons of people complaining of the same issue. the engine is essentially ruined and needs to be replaced and Kia is not addressing this as an issue. my care has stalled out 3 times with my children in it at dangerous intersections. Kia is not taking responsibility of this- having to check oil every 3 days is not normal but Kia thinks it is I guess. The blue smoke coming from my exhaust is a serious problem. A local news station just reported on this of a woman needing an engine replacement and Kia not covering it, but after the news got to them they now are. We need this issue addressed as it is NOT SAFE and Kia needs to put a recall on this immediately- like 5 years ago this should have been addressed! I am not stuck with a car I still owe money on and have to figure out how to pay for a new engine!? KIA needs to do something- this is a safety issue! see article below! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 1, 2025 · Filed: October 14, 2026

I have this 2020 telluride and it’s consuming a lot of oil I have to add a quart of oil every 600 miles. I was wondering if there is any open recalls for this.

Incident: September 9, 2026 · Filed: October 9, 2026

The contact owns a 2020 Kia Telluride. The contact stated that while attempting to start the vehicle, the air bag warning light illuminated. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer where it was diagnosed with an electrical bleeding between the wiring harness. The contact was informed that the wiring harness needed to be replaced. The contact stated that the failure was an expensive out-of-pocket repair. The manufacturer was contacted by phone and made aware of the failure. The failure mileage was approximately 119,000.

Incident: October 6, 2026 · Filed: October 7, 2026

I am reporting a potential safety defect involving excessive engine oil loss and persistent oil leakage on my 2020 Kia Telluride, VIN [XXX]. The vehicle currently has approximately 100,367 miles. It has been experiencing significant oil loss, approximately one quart of engine oil per week. I am concerned that this amount of oil loss is abnormal and creates a potential safety hazard if the engine loses sufficient oil while the vehicle is being driven. The vehicle has also had repeated oil leaks, including an oil pan leak and timing cover leak. I have taken the vehicle to Kia for repairs multiple times, but the oil-related problems have continued. This has required me to continually monitor and add engine oil to prevent the oil level from becoming dangerously low. I specifically brought the vehicle to Kia because of the excessive oil consumption and ongoing leaks. However, the dealership has told me that they will not perform an oil-consumption test until the existing oil leaks are repaired. Kia Customer Care also opened case #[XXX], but I was subsequently told that Kia could not provide assistance because the vehicle is outside the standard warranty period. I am concerned that the underlying cause of the excessive oil loss has not been properly diagnosed. I am also concerned about the possibility of engine damage or engine failure if the vehicle continues losing oil at this rate. Kia has also issued a 2026 warranty extension concerning an engine oil-filter-housing gasket leak on certain 2020–2025 Telluride vehicles. I have asked Kia to determine whether my vehicle is affected by this condition and whether the current oil leaks are related, but I have not received a satisfactory resolution. I am asking NHTSA to review this complaint along with other complaints involving 2020 Kia Tellurides experiencing excessive oil consumption and/or recurring engine oil leaks to determine whether there is a potential safety defect or broader pattern that warrant INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Incident: October 6, 2026 · Filed: October 7, 2026

This afternoon i noticed that my 2020 Kia Telluride paint has and continues to peel in large chunks in my driveway. All was good this morning and then all of the sudden large pieces of paint started to break away. Near the windshield hood area.

Incident: May 23, 2023 · Filed: October 6, 2026

I am filing this safety report regarding my 2020 Kia Telluride, which currently has approximately 133,000 miles. The vehicle is experiencing severe internal oil consumption, burning through multiple quarts of engine oil rapidly between normal service intervals without triggering any dashboard warning lights, creating a high risk of sudden engine failure or stalling at highway speeds. Additionally, the vehicle is losing coolant at an accelerated rate, risking severe engine overheating. Furthermore, the suspension system has been a recurring safety nightmare; the shocks have failed and been replaced twice, and a critical structural defect caused the tires to rub directly against suspension components while driving, prematurely destroying the tires and severely compromising vehicle stability and steering control. I do not feel safe driving this car or transporting my kids everyday. When I spoke to Kia customer service, I was told they could not do anything despite being just under 100,000 miles at the time.

Incident: September 19, 2025 · Filed: October 2, 2026

LED running light of driver's side headlamp assembly inoperable On 10/14/24 BOTH headlamp assemblies were under recall warranty and replaced at Sons Kia in McDonough GA. On 10/8/25 I returned to Sons Kia for service and to have the LED checked on the driver's side as it was no longer operable, less than a year after replacement. I was advised there was no warranty on the LED running light but only the halogen bulb. They priced this headlamp assembly replacement cost at $1169. I believe Kia should accept responsibility of the failure of the new assembly that they sent a recall for and replace this one assembly at no charge to the customer. Kia Customer Service stated this was under warranty but denied by dealership service manager