NHTSA vehicle safety data

2002 Jayco Greyhawk Recalls & Complaints

The 2002 Jayco Greyhawk has 2 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Jayco dealer.

NHTSA recall and complaint data for the 2002 Jayco Greyhawk. Recall data is refreshed daily from NHTSA.

2002 Jayco Greyhawk owner complaints

Owners have filed 2 complaints with NHTSA about the 2002 Jayco Greyhawk, describing incidents dated July 14, 2004 to December 4, 2004.

Most-cited components

Tires 2 complaints

Newest complaints

ODI #10104807 · Filed December 30, 2004
DRIVING 60 MPH ON INTERSTATE 44. FELT SUDDEN VIBRATION. THOUGHT IT WAS ROUGHNESS IN THE ROAD, SO I MOVED TO A DIFFERENT LANE. VIBRATION DID NOT STOP. I THEN THOUGHT THAT IT MIGHT BE ANOTHER FIRESTONE STEELTEX RADIAL TIRE TREAD SEPARATING BECAUSE I HAVE HAD EIGHT (8) PREVIOUS FIRESTONE STEELTEX…
ODI #10088908 · Filed August 31, 2004
FIRESTONE, STEELTEX RADIAL TIRE TREAD SEPARATED FROM CORE EXPLOSIVELY ON OUR MOTORHOME WITH ONLY 28,070 MILES ON IT. THIS IS 1ST FIRESTONE STEELTEX RADIAL TIRE TO FAIL ON THIS MOTORHOME, BUT IT FOLLOWS ALL SEVEN (7) OF THE FIRESTONE STEELTEX RADIAL TIRES ON OUR LAST (IDENTICAL) MOTORHOME FAILING IN…

Read all 2 complaints

SPEED CONTROL DEACTIVATION SWITCH/FORD

NHTSA #06V320000 · Vehicle Speed Control · NHTSA notice

Reported August 30, 2006 · JAYCO, INC.

Potentially affected: 6,285 vehicles

Vehicles built July 1, 1993 – June 30, 2002 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Safety consequence

OVERHEATING COULD RESULT IN SMOKE OR BURNING, AND IN AN UNDERHOOD FIRE.

Manufacturer remedy

FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286) AND WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR JAYCO AT 1-800-283-8267.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

JAYCO/SAMSUNG/MICROWAVES

NHTSA #03V383000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported October 9, 2003 · JAYCO, INC.

Potentially affected: 6,442 vehicles

Vehicles built July 6, 2001 – October 15, 2003 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR JAYCO AT 1-574-825-0608.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2002 Jayco Greyhawk. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2002 Jayco Greyhawk.

Tires

ODI #10104807

Incident: December 4, 2004 · Filed: December 30, 2004

DRIVING 60 MPH ON INTERSTATE 44. FELT SUDDEN VIBRATION. THOUGHT IT WAS ROUGHNESS IN THE ROAD, SO I MOVED TO A DIFFERENT LANE. VIBRATION DID NOT STOP. I THEN THOUGHT THAT IT MIGHT BE ANOTHER FIRESTONE STEELTEX RADIAL TIRE TREAD SEPARATING BECAUSE I HAVE HAD EIGHT (8) PREVIOUS FIRESTONE STEELTEX RADIAL TIRES SUFFER CATASTROPHIC TREAD SEPARATION FAILURES! BEFORE I COULD MOVE TO THE RIGHT AND GET OFF THE HIGHWAY, THE TREAD PEELED ALL THE OFF. IT DAMAGED THE MOTORHOME SEVERELY. NOTE THAT, ALTHOUGH ALL 8 PREVIOUS TREAD SEPARATION FAILURES OCCURRED EXPLOSIVELY, THIS ONE DID NOT EXPLODE. I GOT OFF THE HIGHWAY, LET THE AIR OUT OF THE FAILED TIRE AND INSTALLED THE SPARE TIRE UNTIL I COULD GO GET A NEW REPLACEMENT TIRE.*AK

Tires

ODI #10088908

Incident: July 14, 2004 · Filed: August 31, 2004

FIRESTONE, STEELTEX RADIAL TIRE TREAD SEPARATED FROM CORE EXPLOSIVELY ON OUR MOTORHOME WITH ONLY 28,070 MILES ON IT. THIS IS 1ST FIRESTONE STEELTEX RADIAL TIRE TO FAIL ON THIS MOTORHOME, BUT IT FOLLOWS ALL SEVEN (7) OF THE FIRESTONE STEELTEX RADIAL TIRES ON OUR LAST (IDENTICAL) MOTORHOME FAILING IN EXACTLY THE SAME WAY ONE BY ONE OVER A PERIOD OF JUST A YEAR OR SO. THESE TIRES CAME ALREADY ON THE MOTORHOMES WHEN WE BOUGHT THEM NEW.*AK

Other Jayco Greyhawk model years

Check your 2002 Jayco Greyhawk VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Jayco Greyhawk at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Jayco VIN