try.vin
Log in

NHTSA vehicle safety data

2003 Itasca Suncruiser Recalls & Complaints

The 2003 Itasca Suncruiser has 5 NHTSA recall campaigns and 4 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Itasca dealer.

NHTSA recall and complaint data for the 2003 Itasca Suncruiser. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Itasca Suncruiser owner complaints

Owners have filed 4 complaints with NHTSA about the 2003 Itasca Suncruiser, describing incidents dated June 1, 2005 to March 13, 2010.

Most-cited components

  • Service Brakes 3 complaints
  • Engine 1 complaint

Newest complaints

  • ODI #10321911 · Filed

    I HAVE A 2003 ITASCA SUNCRUISER WITH THE WORKHORSE CHASSIS THAT IS UNDER RECALL FOR THE BRAKE CALIPER PROBLEMS. I ENCOUNTERED THE PROBLEM LAST SUMMER AND TOOK IT TO PARKVIEW RV IN SMYRNA, DE. THEY REBUILT THE FRONT AND BACK BRAKES, SEALS, CALIPERS, PADS AND SENSORS WHICH HAD MELTED. AT THE TIME THEY…

  • ODI #10252856 · Filed

    BRAKE PROBLEM ON WORKHOUSE CHASSIS MOTORHOME. CALIPERS LOCKUP, APPARENTLY DO TO PINS. THIS IS A CONTINUOUS PROBLEM. REPLACED ALL 4 ROTOR. 4CALIPERS.2 SETS BRAKE PADS, 4 OIL SEALS, 4 BRAKE HOSE,2 AXLE GASKETS. ALL AT A COST OF $3502.97 I HAVE ROTORS, CALIPERS. *TR

  • ODI #10241029 · Filed

    TL*THE CONTACT OWNS A 2003 ITASCA SUNCRUISER RV. WHILE DRIVING 60 MPH, THE CONTACT NOTICED A VIBRATION IN THE STEERING WHEEL. HE TURNED OFF THE VEHICLE. WHEN HE RESTARTED IT, HE NOTICED THAT THE BRAKE PEDAL WAS HIGHER THAN USUAL AND HE HAD TO APPLY EXTREME PRESSURE TO STOP THE VEHICLE. THE VEHICLE…

Read all 4 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #10V525000 · Equipment · NHTSA notice

Reported October 26, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 18,461 vehicles

Owners notified December 15, 2010

Defect description

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR FIRE/NORCOLD

NHTSA #09V300000 · Equipment · NHTSA notice

Reported July 29, 2009 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,547 vehicles

Owners notified August 31, 2009 · Vehicles built May 10, 2001 – March 26, 2003 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

WINNEBAGO IS RECALLING 1,547 MODEL YEAR 2001-2003 RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Safety consequence

IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD AND NORCOLD WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE (PLEASE SEE 09E-027). OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

REFRIGERATOR ROOF VENT RELOCATION

NHTSA #05V407000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported September 14, 2005 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,367 vehicles

Manufacturer campaign 96 · Owners notified September 9, 2005 · Vehicles built May 2, 2002 – August 12, 2005 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED.

Safety consequence

THIS CAN ALLOW EXCESSIVE HEAT BUILDUP WHICH HAS THE POTENTIAL TO IGNITE SURROUNDING MATERIALS, RESULTING IN PERSONAL INJURY AND/OI VEHICLE AND PROPERTY DAMAGE.

Manufacturer remedy

DEALERS WILL RELOCATE THE ROOF VENT. THE RECALL BEGAN ON SEPTEMBER 9, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

Notes

WINNEBAGO RECALL NO. 96.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

WINNEBAGO/CROSSMEMBER CLEARANCE/FUEL LINE

NHTSA #04V609000 · Fuel System, Gasoline — Delivery — Hoses, Lines/Piping, and Fittings · NHTSA notice

Reported December 22, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 3,538 vehicles

Manufacturer campaign 93 · Owners notified January 7, 2005 · Vehicles built August 6, 2003 – September 3, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

Safety consequence

WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Manufacturer remedy

DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO RECALL NO. 93. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

WINNEBAGO/BRAKE SYSTEM WARNING INDICATOR

NHTSA #03V060000 · Service Brakes, Hydraulic — Brake Fluid Low Warning — Lamp · NHTSA notice

Reported February 21, 2003 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 8,532 vehicles

Manufacturer campaign 88 · Owners notified April 25, 2003 · Vehicles built August 1, 1999 – January 31, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.

Safety consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.

Manufacturer remedy

DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.

Notes

WINNEBAGO RECALL NO. 88.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Itasca Suncruiser model years

Check your 2003 Itasca Suncruiser VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Itasca Suncruiser at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Itasca VIN