try.vin
Log in

NHTSA vehicle safety data

2004 Itasca Horizon Recalls & Complaints

The 2004 Itasca Horizon has 5 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Itasca dealer.

NHTSA recall and complaint data for the 2004 Itasca Horizon. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Itasca Horizon owner complaints

Owners have filed 3 complaints with NHTSA about the 2004 Itasca Horizon, describing incidents dated April 8, 2004 to June 19, 2016.

Most-cited components

  • Electrical System 1 complaint
  • Exterior Lighting 1 complaint
  • Tires 1 complaint
  • Visibility/Wiper 1 complaint

Newest complaints

  • ODI #10875417 · Filed

    TL* THE CONTACT OWNS A 2004 ITASCA HORIZON EQUIPPED WITH SYNERGY AP400 TIRES (NA), SIZE: 295/75/R22.5 (NA). WHILE DRIVING 55 MPH, AN ABNORMAL NOISE WAS OBSERVED AND THE FRONT PASSENGER SIDE TIRE TREAD BEGAN TO SEPARATE. THE TIRE WAS NOT DIAGNOSED, BUT WAS REPAIRED BY ROADSIDE ASSISTANCE. DUE TO THE…

  • ODI #10447065 · Filed

    OUR MOTORHOME HAD A HAMSAR ELECTRO-MAGNETIC FLASHER WHICH IS USED TO MAKE THE HAZARD LIGHTS AND LEFT/RIGHT SIGNAL BLINK. IT IS LOCATED IN THE FUSE BOX IN THE OUTSIDE COMPARTMENT, NEAR DRIVER'S SIDE. IT STARTED SMOKING AND SMELLED BURNED, LOTS OF SMOKE STARTED COMING INTO THE MOTORHOME. THE HAZARD…

  • ODI #10086311 · Filed

    SINCE DRIVEN OFF THE SHOWROOM FLOOR, ITASCA HORIZON MOTORHOME'S WIPERS HAVE WORKED TWICE (15 SECONDS EACH TIME). WERE INOPERATIVE UPON PICKUP. FIRST REPAIR ALLOWED TWO SHORT USES, SECOND REPAIR BY THE LOCAL AUTHORIZED FREIGHTLINER DEALER WAS TO NO AVAIL.*AK

Read all 3 complaints

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

NHTSA #10V525000 · Equipment · NHTSA notice

Reported October 26, 2010 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 18,461 vehicles

Owners notified December 15, 2010

Defect description

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Safety consequence

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Manufacturer remedy

WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

STEERING GEAR SPACER/FREIGHTLINER/ZF

NHTSA #07V577000 · Steering — Gear Box — Shaft Pitman · NHTSA notice

Reported December 12, 2007 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 1,972 vehicles

Vehicles built July 14, 2003 – August 17, 2007 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN MOTOR HOME CHASSIS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATION BALLS TO ESCAPE FROM THE RECIRCULATION BALL CIRCUIT RESULTING IN A LOSS OF STEERING.

Safety consequence

THE OPERATOR MAY NOTICE HIGHER REQUIRED STEERING WHEEL INPUTS,OR THE NEED FOR MORE STEERING WHEEL ADJUSTMENTS, WHILE DRIVING IN A STRAIGHT LINE IN COMBINATION WITH METALLIC CRACKING NOISES PRIOR TO A LOSS OF STEERING. LOSS OF STEERING COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

WINNEBAGO IS WORKING WITH FREIGHTLINER AND ZF TO REPLACE THE STEERING GEAR FREE OF CHARGE. OWNERS MAY CONTACT WINNEBAGO AT 641-585-3535 OR FREIGHTLINER AT 1-800-547-0712.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY OUTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://

WINNEBAGO/AMSAFE/SEAT BELTS

NHTSA #04V608000 · Seat Belts — Front — Buckle Assembly · NHTSA notice

Reported December 18, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 6,201 vehicles

Manufacturer campaign 92 · Owners notified November 29, 2004 · Vehicles built September 8, 2003 – April 30, 2004 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Safety consequence

THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Manufacturer remedy

DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.

Notes

WINNEBAGO RECALL NO. 92.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

WINNEBAGO/ACCELERATOR PEDAL

NHTSA #04V471000 · Vehicle Speed Control — Accelerator Pedal · NHTSA notice

Reported September 27, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 240 vehicles

Manufacturer campaign 91 · Owners notified September 17, 2004 · Vehicles built January 6, 2004 – July 30, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON A FREIGHTLINER CHASSIS WITH A 400-HP CUMMINS ENGINE, A SHEET METAL "TAB" ON A WIRE COVER LOCATED BEHIND THE ACCELERATOR PEDAL HAS THE POTENTIAL TO CATCH ON THE ACCELERATOR PEDAL.

Safety consequence

IF THE ACCELERATOR PEDAL HANGS UP ON THE TAB OF THE WIRE COVER, A HAZARDOUS SITUATION COULD RESULT IN THE PEDAL NOT GOING BACK TO IDLE POSITION, INCREASING THE RISK OF PERSONAL INJURY, VEHICLE DAMAGE AND, A CRASH COULD OCCUR.

Manufacturer remedy

DEALERS WILL PROVIDE INSTRUCTIONS FOR OWNERS TO INSPECT AND IF NECESSARY HAVE THE WIRE COVER REPAIRED. IF OWNERS DO NOT FEEL COMFORTABLE PERFORMING THE INSPECTION, DEALERS WILL INSPECT AND REPAIR AS NECESSARY. THE RECALL BEGAN ON SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT WINNEBAGO AT 641-585-6939.

Notes

WINNEBAGO RECALL NO. 91.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

WINNEBAGO/LP TANK

NHTSA #04V114000 · Equipment — Recreational Vehicle/Trailer — LPG Systems — Tank Assembly · NHTSA notice

Reported March 4, 2004 · WINNEBAGO INDUSTRIES, INC.

Potentially affected: 5,143 vehicles

Manufacturer campaign 90 · Owners notified March 25, 2004 · Vehicles built April 28, 1999 – September 19, 2003 (per NHTSA)

Defect description

ON CERTAIN MOTORHOMES, THE LP TANK HAS STRESS ON WELD JOINTS AT THE POINT WHERE MOUNTING BRACKETS ARE WELDED TO THE TANK.

Safety consequence

THIS COULD CAUSE STRESS CRACKS AT THE WELD JOINTS AND LEAD TO AN LP LEAK AND CAUSE PERSONAL INJURY AND/OR VEHICLE DAMAGE.

Manufacturer remedy

DEALERS WILL REINSTALL A CRADLE-STYLE CARRIER, AND, IF NECESSARY REPLACE THE LP TANK. THE RECALL BEGAN ON MARCH 25, 2004. OWNERS SHOULD CONTACT WINNEBAGO AT 641-585-6939.

Notes

WINNEBAGO RECALL NO. 90.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Itasca Horizon model years

Check your 2004 Itasca Horizon VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Itasca Horizon at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check an Itasca VIN