NHTSA vehicle safety data

2006 Honda Element Recalls, Ratings & Complaints

The 2006 Honda Element has 11 NHTSA recall campaigns and 122 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Honda dealer.

NHTSA recall and complaint data for the 2006 Honda Element, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 Honda Element owner complaints

Owners have filed 122 complaints with NHTSA about the 2006 Honda Element, describing incidents dated June 10, 2006 to July 19, 2026.

Most-cited components

Air Bags 55 complaints
Visibility/Wiper 13 complaints
Electrical System 11 complaints
Structure 11 complaints
Suspension 10 complaints
Seats 9 complaints

Of the 122 complaints on file, 17 report a crash and 1 a fire; across all 122 complaints, owners report 16 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11751415 · Filed July 19, 2026
Chest clip won’t pull tight and tethered to pull on lower anchor malfunctions when you pull it is difficult to get tight
ODI #11714865 · Filed February 1, 2026
Vehicle (2-owner, all svc records), involved in a head-on collision, with approximately 75% of impact/damage to the Driver’s front (see photos). The passenger front (25% of impact) airbag deployed, the DRIVERS SIDE AIRBAG did NOT deploy. The Takata airbag recall service/replacement (see invoice) was…
ODI #11706003 · Filed December 18, 2025
Honda Canada recognized the safety risks from salt damage to the frames and rear suspension of Honda Elements and recalled all years of the Element for warranty repairs, or if the damage was too severe, buy back of the vehicles. Yet they have not in the USA in rust belt states where salt damage is…

Read all 122 complaints

Owner-reported

2006 Honda Element mileage at failure

80 of the 122 complaints on file for the 2006 Honda Element give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Air Bags	Median 75,000 miles	Middle half 25,000–150,000 miles	Based on 37 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2006 Honda Element in 3 investigations. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page

Open and recently closed NHTSA defect investigations

Driver Frontal Air Bag Inflator May Explode

NHTSA #19V499000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported June 27, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 3,947 vehicles

Repair completion: 29.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign Q5A, Y58 · Owners notified August 12, 2019 · Vehicles built November 9, 2005 – June 26, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are Q5A and Y58.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Explode

NHTSA #19V501000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported June 27, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 1,657,752 vehicles

Repair completion: 47.72% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign E5D, X5C · Owners notified August 12, 2019 · Vehicles built October 19, 2005 – August 14, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Safety consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are E5D and X5C.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver Frontal Air Bag Inflator May Explode

NHTSA #19V182000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported March 6, 2019 · Honda (American Honda Motor Co.)

Potentially affected: 1,101,534 vehicles

Repair completion: 54.23% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign U40,M45,O41,G44 · Owners notified April 10, 2019 · Vehicles built October 26, 2005 – July 22, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.

Safety consequence

An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Improperly Installed Passenger Air Bag

NHTSA #18V268000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported April 26, 2018 · Honda (American Honda Motor Co.)

Potentially affected: 1,335 vehicles

Repair completion: 86.4% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign C1X, N2L, U2M · Owners notified June 22, 2018 · Vehicles built December 13, 2005 – July 24, 2006 (per NHTSA)

Defect description

Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.

Safety consequence

An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.

Manufacturer remedy

Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #17V029000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported January 10, 2017 · Honda (American Honda Motor Co.)

Potentially affected: 308,884 vehicles

Repair completion: 71.85% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign KD9, KE0 · Owners notified February 27, 2017 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2011 Honda Element vehicles, 2005-2012 Acura RL vehicles, 2006-2012 Honda Ridgeline vehicles, 2007-2008 Honda Fit vehicles and 2005-2008 Honda Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2009 Acura RL and Honda Element vehicles, 2007-2008 Honda Fit vehicles, 2005-2008 Honda Pilot vehicles and 2006-2009 Honda Ridgeline vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone A" or "Zone B" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2008 Acura RL, Honda Element and Honda Pilot vehicles, 2007-2008 Honda Fit vehicles and 2006-2008 Honda Ridgeline vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall bagan March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KD9 and KE0.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V344000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 23, 2016 · Honda (American Honda Motor Co.)

Potentially affected: 1,790,894 vehicles

Repair completion: 57.83% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign KA0, KA1, KA2, KA3 · Owners notified June 29, 2016 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda Element, and Honda Pilot vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Safety consequence

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KA0, KA1, KA2, and KA3.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Driver's Frontal Air Bag May Rupture

NHTSA #15V320000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 28, 2015 · Honda (American Honda Motor Co.)

Potentially affected: 6,281,043 vehicles

Repair completion: 79.01% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Honda campaign JQ9 & JR0-JR8 · Owners notified July 1, 2015 · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

Defect description

Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138. Owners may contact Acura customer service at 1-800-382-2238, select option 4. Note: Vehicles that have had their driver frontal air bag replaced previously as part of a recall remedy prior to September 12, 2014 need to have their air bag replaced under this recall as well. Vehicles that, on or after September 12, 2014, received a remedy for a prior driver frontal air bag inflator recall already received an inflator of a different design, and therefore are not included in this recall and do not require additional servicing. Note: This recall fully supersedes recalls 08V-593, 09V-259, 10V-041, 11V-260, 14V-351 and 15V-153. Honda's numbers for this recall are JQ9, JR0, JR1, JR2, JR3, JR4, JR5, JR6, JR7, and JR8.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

AUTOMATIC TRANSMISSION CONTROL MODULE SOFTWARE

NHTSA #11V395000 · Power Train — Automatic Transmission — Control Module (TCM/PCM/TECM) · NHTSA notice

Reported August 4, 2011 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 1,512,107 vehicles

Honda campaign R89 · Owners notified August 27, 2011 · Vehicles built December 14, 2004 – September 26, 2008 (per NHTSA)

Defect description

HONDA IS RECALLING CERTAIN MODEL YEAR 2005-2010 ACCORD, 2007-2010 CR-V, AND 2005-2008 ELEMENT PASSENGER CARS MANUFACTURED FROM JULY 1, 2004, THROUGH SEPTEMBER 3, 2010. THE OUTER RACE OF THE SECONDARY SHAFT BEARING MAY BE BROKEN DURING CERTAIN DRIVING STYLES. A BROKEN OUTER RACE MAY CAUSE ABNORMAL NOISE, THE MALFUNCTION INDICATOR LIGHT TO TURN ON, AND ALLOW CONTACT BETWEEN THE TRANSMISSION IDLE GEAR AND AN ELECTRONIC SENSOR HOUSING WITHIN THE TRANSMISSION.

Safety consequence

THIS COULD RESULT IN A SHORT CIRCUIT CAUSING THE ENGINE TO STALL. ADDITIONALLY, BROKEN PIECES OF THE OUTER RACE OR BALL BEARING FROM THE SECONDARY SHAFT MAY BECOME LODGED IN THE PARKING PAWL RESULTING IN THE VEHICLE ROLLING AFTER THE DRIVER HAS PLACED THE GEAR SELECTOR IN THE PARK POSITION. ENGINE STALL AND UNEXPECTED VEHICLE MOVEMENT INCREASES THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS WITHIN THE PATH OF A ROLLING VEHICLE.

Manufacturer remedy

HONDA WILL NOTIFY OWNERS AND DEALERS WILL UPDATE THE AUTOMATIC TRANSMISSION CONTROL MODULE SOFTWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT HONDA AUTOMOBILE CUSTOMER SERVICE AT 1-800-999-1009.

Notes

HONDA'S RECALL CAMPAIGN NUMBER IS R89.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

OWNER'S MANUAL HOTLINE INFORMATION INCORRECT

NHTSA #06V270000 · Equipment — Other — Owners/Service/Other Manual · NHTSA notice

Reported July 26, 2006 · HONDA (AMERICAN HONDA MOTOR CO.)

Potentially affected: 1,190,000 vehicles

Owners notified August 2, 2006 · Vehicles built September 1, 2005 – May 31, 2006 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES AND MOTORCYCLES, THE OWNER'S MANUALS CONTAIN INCORRECT CONTACT INFORMATION FOR THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S (NHTSA) VEHICLE SAFETY HOTLINE.

Safety consequence

THE LANGUAGE IN THE OWNER'S MANUALS IS NOT IN ACCORDANCE WITH THE CURRENT MANDATORY REQUIREMENTS.

Manufacturer remedy

HONDA WILL SEND A POSTCARD TO DEALERS AND OWNERS WITH THE CORRECT NHTSA VEHICLE SAFETY HOTLINE INFORMATION AND WITH INSTRUCTIONS TO INSERT THE CARD INTO THE "REPORTING SAFETY DEFECTS" SECTION OF THE OWNER'S MANUAL. THE RECALL BEGAN ON AUGUST 2, 2006. OWNERS MAY CONTACT HONDA AT 1-800-999-1009, ACURA AT 1-800-382-2238 OR HONDA MOTORCYCLES AT 1-866-784-1870.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

2006 Honda Element 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 5, Passenger: 5

Side Crash

Not Rated

Driver: 5, Passenger: 5

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

3 investigations

122 owner complaints have been filed with NHTSA for the 2006 Honda Element.

Chest Clip, Buckle, Harness; Tether, Lower Anchor (on car seat or vehicle)

ODI #11751415

Incident: July 19, 2026 · Filed: July 19, 2026

Chest clip won’t pull tight and tethered to pull on lower anchor malfunctions when you pull it is difficult to get tight

Air Bags

ODI #11714865

Crash 1 injury

Incident: December 12, 2025 · Filed: February 1, 2026

Vehicle (2-owner, all svc records), involved in a head-on collision, with approximately 75% of impact/damage to the Driver’s front (see photos). The passenger front (25% of impact) airbag deployed, the DRIVERS SIDE AIRBAG did NOT deploy. The Takata airbag recall service/replacement (see invoice) was performed by a local Honda dealership on 01/08/2018. (Factory recall: 16-047; Kit Inflator: 06999). The vehicle is in my (owner’s) private possession since the time of the incident, I have deliberately not yet had it serviced or inspected for damage/repair estimates in any way, as my priority is to FIRST go through proper, qualified channels to have it properly inspected and diagnosed in regards to the AIRBAG FAILURE.

Suspension

ODI #11706003

Incident: December 17, 2025 · Filed: December 18, 2025

Honda Canada recognized the safety risks from salt damage to the frames and rear suspension of Honda Elements and recalled all years of the Element for warranty repairs, or if the damage was too severe, buy back of the vehicles. Yet they have not in the USA in rust belt states where salt damage is prevalent. As you will note from the attached photos, severe injury or death could occur in a major collision, which falls into the scope of your agency. All Elements in areas where corrosive salty and liquid brine is used are at risk, posing a significant safety hazard. Contacting local Honda dealers confirm the absence of a recall for this issue which puts motorists in this country at risk.

Suspension

ODI #11704944

Incident: December 2, 2025 · Filed: December 14, 2025

left rear rear trailing arm rusted out. had car checked due to rough ride & was informed said part so rusted it was dangerous to drive. damage so severe repair not feasible. appears this is a problem with elements & some crvs. canada apparently has a recall for this, & US should, too.

Suspension; Unknown or Other

ODI #11694785

Incident: September 1, 2025 · Filed: October 21, 2025

The trailing arm mounts are severely rotted due to rust and my mechanic has claimed that it is unsafe to drive. The element has been recalled in Canada for this same issue. It is a huge safety concern for a vehicle that is otherwise in great condition.

Suspension

ODI #11691611

Incident: January 14, 2025 · Filed: October 6, 2025

Rusting rear suspension is safety issue. Elements were already recalled in Canada but not yet in USA since not enough complaints were issued. The Element is based on the CRV which already does have a recall in USA for this issue

Suspension

ODI #11674062

Incident: July 16, 2025 · Filed: July 16, 2025

I live in Minnesota and my Elements rear trailing arms are badly rusted. There is a recall for the same issue in Canada but not in the US. This is my 2006 Honda Element with 96k miles. I would love to be able to get another at least 100k miles if not lots more. These cars can go to 400k if maintained well.

Air Bags

ODI #11650488

Incident: March 17, 2025 · Filed: March 25, 2025

The contact owns a 2006 Honda Element. The contact stated while driving 70 MPH, the passenger's side door air bag deployed. There were no warning lights illuminated. The contact and her mother heard a loud explosion, and the passenger's side door air bag deployed. The vehicle was taken to the dealer where the vehicle was diagnosed. There was no impact GTC system scanned -1 completed troubleshooting found no damage while SRS and air bag unit need to be replaced. The vehicle had previously been repaired, a year and a half prior to the failure under an unknown recall associated with the air bags. The local dealer was contacted; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 155,500.

Power Train; Structure; Unknown or Other

ODI #11632315

Incident: December 24, 2024 · Filed: December 25, 2024

The check engine light indicated a "gas cap" code, and the "side airbag off" light was illuminated. Upon diagnosis, the technician identified significant rust and cracked transmission components, resulting in fluid leakage. The service department assessed the vehicle as unsafe for operation, waived the diagnostic fees, and replenished the transmission fluid to prevent the risk of being stranded due to a lack of fluid on the return trip. Honda Service Department took the attached photos and documented the vehicle's safety violations.

Unknown or Other

ODI #11583821

Incident: April 17, 2024 · Filed: April 18, 2024

I got into my Element. I closed the driver side door. I heard a loud pop and heard the back right corner window shatter and break. It’s the window in the cargo area.Waiting for the insurance adjuster to look at it.

Other Honda Element model years

Check your 2006 Honda Element VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Honda Element at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Honda VIN