NHTSA vehicle safety data

2011 Heartland Big Country Recalls & Complaints

The 2011 Heartland Big Country has 3 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Heartland dealer.

NHTSA recall and complaint data for the 2011 Heartland Big Country. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2011 Heartland Big Country owner complaints

Owners have filed 3 complaints with NHTSA about the 2011 Heartland Big Country, describing incidents dated September 10, 2012 to July 18, 2013.

Most-cited components

Tires 2 complaints
Wheels 1 complaint

Of the 3 complaints on file, 1 reports a crash (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10536365 · Filed August 20, 2013
WITHIN ONE HOUR OF LEAVING HOME HAD THREE SEPARATE TIRE BLOWOUTS ON RV. TIRES DID NOT APPEAR WORN, INFLATED PROPERLY, LOAD APPROPRIATE, AND STORED UNDER COVER. LESS THAN 6000 MILES ON THESE 2 YEAR OLD ORIGINAL EQUIPMENT ON HEARTLAND BIG COUNTRY RV. OCCURRED ON I-35 DALLAS CAUSING SIGNIFICANT DAMAGE…
ODI #10483242 · Filed November 3, 2012
THE AFFECTED PARTS SECTION ABOVE WOULD NOT KEEP MY AFFECTED PARTS LISTED, SO THEY WERE THE DELAMINATED TIRE, FENDER SKIRTING AND SOME WIRING. WHILE TOWING MY 2011 3250 TS BIG COUNTRY FIFTH WHEEL AT APPROXIMATELY 35 MPH MY DRIVERS SIDE FRONT TIRE TREAD ON THE CAMPER DELAMINATED. THE CAMPER WAS PULLED…
ODI #10477468 · Filed September 29, 2012
TREAD CAME OFF TIRE WILL TRAVELING ON I-515 IN HENDERSON NV. TIRE WAS PROPERLY INFLATED AS WE HAD LEFT THE SERVICING DEALERSHIP JUST 30 MINUTES PRIOR. THIS BRAND OF TIRE SEEMS TO HAVE A HIGH FAILURE RATE IF THE COMPLAINTS ON THE HEARTLAND OWNERS FORUM ARE ANY INDICATION. *TR

Read all 3 complaints

Fire Extinguisher May Be Clogged or Inoperable

NHTSA #17V750000 · Equipment · NHTSA notice

Reported November 22, 2017 · Heartland Recreational Vehicles, LLC

Potentially affected: 19,615 vehicles

Repair completion: 2.65% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Owners notified January 15, 2018 · Vehicles built January 8, 2010 – March 23, 2010 (per NHTSA)

Defect description

Heartland Recreational Vehicles, LLC (Heartland) is recalling certain 2010-2011 Elkridge, North Country, North Trail FW, 2011 Big Country, Bighorn, Caliber, Country Ridge, Cyclone, Edge, Focus, Graystone, Landmark, MPG, North Trail TT, Road Warrior, Sundance, Sundance TT, Sundance XLT FW, Sundance XLT TT, Trail Runner, 2018 Fuel TT, 2016-2018 Sundance XLT TT, and Torque TT recreational vehicles, equipped with certain Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Safety consequence

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Manufacturer remedy

Heartland will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Heartland customer service at 1-877-262-8032, or Kidde customer service toll free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Incorrect Tire Size Information/FMVSS 567

NHTSA #15V482000 · Equipment — Other — Labels · NHTSA notice

Reported July 30, 2015 · Heartland Recreational Vehicles, LLC

Potentially affected: 1,680 vehicles

Repair completion: 8.51% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Heartland campaign 99-01-23 · Owners notified September 29, 2015 · Vehicles built January 1, 2010 – July 23, 2015 (per NHTSA)

Defect description

Heartland Recreational Vehicles, LLC (Heartland) is recalling certain trailers of various models and model years. Click on "All Products Associated With This Recall" for a complete list. The tire certification labels applied to the vehicles may contain inaccurate tire sizing and/or inflation information. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."

Safety consequence

An owner or operator could rely on the inaccurate information in inflating the tires which could cause under or over inflation which, in turn, could lead to a tire failure or crash.

Manufacturer remedy

Heartland will notify owners, and dealers will send a replacement label with the correct information, free of charge. The recall began on September 29, 2015. Owners may contact Heartland customer service at 1-574-266-3988.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

AXLE ASSEMBLY/WHEEL END SEPARATION

NHTSA #10V461000 · Power Train — Axle Assembly · NHTSA notice

Reported October 8, 2010 · HEARTLAND RECREATIONAL VEHICLES, LLC

Potentially affected: 48 vehicles

Heartland campaign 99-01-03 · Owners notified October 20, 2010 · Vehicles built August 9, 2010 – September 3, 2010 (per NHTSA)

Defect description

HEARTLAND IS RECALLING CERTAIN MODEL YEAR 2011 FIFTH WHEEL TRAILERS EQUIPPED WITH DEXTER AXLES. ON SOME AXLES, CRACKS COULD APPEAR IN THE SPINDLE WELD.

Safety consequence

THESE CRACKS CAN PROPAGATE AND CAUSE THE SPINDLE TO DETACH FROM THE AXLE TUBE, RESULTING IN THE SEPARATION OF THE WHEEL END FROM THE VEHICLE, CREATING A ROAD HAZARD THAT INCREASES THE RISK OF A CRASH TO OTHER VEHICLES, AND COMPROMISES THE DRIVER'S CONTROL OF THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.

Manufacturer remedy

HEARTLAND IS WORKING WITH DEXTER AXLE AND WILL INSPECT THE AXLE SERIAL NUMBER AND REPLACE IT IF IT FALLS WITHIN THE SERIAL NUMBER RANGE. REPLACEMENT OF THE AXLE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT HEARTLAND WARRANTY SERVICE DEPARTMENT AT 1-877-262-8032 OR DEXTER AXLE AT 1-800-400-2164.

Notes

HEARTLAND SAFETY RECALL NO. 99-01-03.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

try.vin has no NCAP crash-test rating on file for the 2011 Heartland Big Country. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2011 Heartland Big Country.

Tires

ODI #10536365

Incident: July 18, 2013 · Filed: August 20, 2013

WITHIN ONE HOUR OF LEAVING HOME HAD THREE SEPARATE TIRE BLOWOUTS ON RV. TIRES DID NOT APPEAR WORN, INFLATED PROPERLY, LOAD APPROPRIATE, AND STORED UNDER COVER. LESS THAN 6000 MILES ON THESE 2 YEAR OLD ORIGINAL EQUIPMENT ON HEARTLAND BIG COUNTRY RV. OCCURRED ON I-35 DALLAS CAUSING SIGNIFICANT DAMAGE TO RV, AND RESULTING IN PURCHASE ON THE SPOT OF 4 NEW TIRES. TIRES APPEARED TOTALLY SEPERATED. *TR

Wheels

ODI #10483242

Crash

Incident: November 1, 2012 · Filed: November 3, 2012

THE AFFECTED PARTS SECTION ABOVE WOULD NOT KEEP MY AFFECTED PARTS LISTED, SO THEY WERE THE DELAMINATED TIRE, FENDER SKIRTING AND SOME WIRING. WHILE TOWING MY 2011 3250 TS BIG COUNTRY FIFTH WHEEL AT APPROXIMATELY 35 MPH MY DRIVERS SIDE FRONT TIRE TREAD ON THE CAMPER DELAMINATED. THE CAMPER WAS PULLED TO THE SIDE OF THE ROAD AND UPON INSPECTION I FOUND THE TREAD OF THE TOWMAX STR ST235/80R16 HAD DELAMINATED HALFWAY OFF OF THE TIRE CORE. AFTER CALMING DOWN AND GETTING ROADSIDE SERVICE TO PLACE THE SPARE ON THE CAMPER I CONTINUED SLOWLY TO THE NEARBY CAMPSITE. NOTE: WHILE I WAS WAITING FOR THE ROADSIDE SERVICE TO ARRIVE, ANOTHER FELLOW CAMPER STOPPED BY TO ASSIST IF HE COULD. WHILE THERE HE TOLD ME THAT THIS DELAMINATION PROBLEM WITH THESE TOWMAX TIRES HAS BEEN ONGOING FOR A LONG PERIOD OF TIME. I FOUND HIS STATEMENT THIS TO BE VERY TRUE AND DISTURBING. AFTER COMPLETING RESEARCH ON VARIOUS/MANY RV FORUMS WHERE I READ SIMILAR STORIES AND SAW PICTURES OF SIMILAR/WORSE DAMAGES AS MY OWN I AM AMAZED AND SHOCKED THAT THESE TIRES ARE ALLOWED TO BE USED ON RV'S. AND THIS DELAMINATION PROBLEM HAS BEEN GOING ON FOR YEARS, AS NOTED BY THE RV FORUM REPORT DATES. AT A MINIMUM, THERE HAS BEEN PROPERTY DAMAGED. THANK GOODNESS IN OUR CASE WE HAD JUST LEFT A RED LIGHT AND WERE ONLY GOING 35-40 MPH. THIS IS A POTENTIAL LIFE THREATENING ISSUE THAT NEEDS IMMEDIATE ACTION TAKEN BEFORE SOMEONE IS KILLED!!! I AM NOW SEARCHING FOR 4 NEW TIRES TO REPLACE THESE DEFECTIVE TIRES AND GET SOME PEACE OF MIND BACK BEFORE CONTINUING ON TO FL. THANK YOU FOR YOUR SUPPORT IN THIS MATTER AND I LOOK FORWARD TO HEARING SOME POSITIVE RESULTS IN THE CASE. *TR

Tires

ODI #10477468

Incident: September 10, 2012 · Filed: September 29, 2012

TREAD CAME OFF TIRE WILL TRAVELING ON I-515 IN HENDERSON NV. TIRE WAS PROPERLY INFLATED AS WE HAD LEFT THE SERVICING DEALERSHIP JUST 30 MINUTES PRIOR. THIS BRAND OF TIRE SEEMS TO HAVE A HIGH FAILURE RATE IF THE COMPLAINTS ON THE HEARTLAND OWNERS FORUM ARE ANY INDICATION. *TR

Other Heartland Big Country model years

Check your 2011 Heartland Big Country VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Heartland Big Country at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Heartland VIN