NHTSA vehicle safety data

2006 GMC Sierra 3500 Recalls & Complaints

We couldn't confirm the NHTSA recall list for the 2006 GMC Sierra 3500 right now, so this page doesn't state a recall count — check the VIN at nhtsa.gov/recalls for current campaigns. 11 owner complaints are on file.

NHTSA recall and complaint data for the 2006 GMC Sierra 3500.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2006 GMC Sierra 3500 owner complaints

Owners have filed 11 complaints with NHTSA about the 2006 GMC Sierra 3500, describing incidents dated September 15, 2006 to January 30, 2026.

Most-cited components

Power Train 3 complaints
Steering 3 complaints
Air Bags 2 complaints
Service Brakes 2 complaints
Engine 1 complaint
Tires 1 complaint

Of the 11 complaints on file, 1 reports a crash and 1 a fire; across all 11 complaints, owners report 1 injury (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11714436 · Filed January 30, 2026
The front impact sensor, also known as a crash sensor (part # 10370150), is no longer functional. It detects rapid vehicle deceleration during a frontal collision and sends an immediate signal to the Airbag Control Unit (ACU) to deploy airbags. Located behind the front bumper or on the radiator…
ODI #10984924 · Filed May 11, 2017
TL* THE CONTACT OWNS A 2006 GMC SIERRA 3500. WHILE THE VEHICLE WAS STATIONARY, THE POWER STEERING FLUID LEAKED INTO THE BRAKING SYSTEM AND CAUSED THE BRAKES TO SEIZE. THE VEHICLE WAS REPAIRED AND ALL OF THE HOSES AFFECTED BY THE BRAKE FLUID WERE REPLACED. THE CONTACT STATED THAT THIS WAS THE THIRD…
ODI #10780533 · Filed October 7, 2015
INVOLVED IN ACCIDENT, VEHICLE DRIVEN INTO REAR OF PICK-UP AND U-HAUL TRAILER ON HIGHWAY 50 CANYON CITY,CO ,LEFT FRONT SIDE OF GMC 3500 DESTROYED ALONG WITH HOOD AREA AND THE AIRBAGS DID NOT DEPLOY. DRIVER HAD TO BE CUT OUT OF GMC3500. GMC TOTALED DRIVER SUFFERED BROKEN NECK. PHOTOS OBTAINED BUT NOT…

Read all 11 complaints

We couldn't confirm the NHTSA recall list for the 2006 GMC Sierra 3500 right now — this is not a confirmed "no recalls". Check the VIN at NHTSA.gov/recalls for the official status.

try.vin has no NCAP crash-test rating on file for the 2006 GMC Sierra 3500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

11 owner complaints have been filed with NHTSA for the 2006 GMC Sierra 3500.

Air Bags

ODI #11714436

Incident: January 30, 2026 · Filed: January 30, 2026

The front impact sensor, also known as a crash sensor (part # 10370150), is no longer functional. It detects rapid vehicle deceleration during a frontal collision and sends an immediate signal to the Airbag Control Unit (ACU) to deploy airbags. Located behind the front bumper or on the radiator support, these sensors measure impact severity to ensure airbags deploy only when necessary. This part is no longer available from GM or any other aftermarket distributor. It is a critical part for any occupants in a crash. I am just one of many people who cannot make safety corrections.

Steering; Service Brakes

ODI #10984924

Incident: May 1, 2017 · Filed: May 11, 2017

TL* THE CONTACT OWNS A 2006 GMC SIERRA 3500. WHILE THE VEHICLE WAS STATIONARY, THE POWER STEERING FLUID LEAKED INTO THE BRAKING SYSTEM AND CAUSED THE BRAKES TO SEIZE. THE VEHICLE WAS REPAIRED AND ALL OF THE HOSES AFFECTED BY THE BRAKE FLUID WERE REPLACED. THE CONTACT STATED THAT THIS WAS THE THIRD TIME THE VEHICLE WAS REPAIRED FOR THE SAME FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 161,108.

Air Bags

ODI #10780533

Crash 1 injury

Incident: August 20, 2015 · Filed: October 7, 2015

INVOLVED IN ACCIDENT, VEHICLE DRIVEN INTO REAR OF PICK-UP AND U-HAUL TRAILER ON HIGHWAY 50 CANYON CITY,CO ,LEFT FRONT SIDE OF GMC 3500 DESTROYED ALONG WITH HOOD AREA AND THE AIRBAGS DID NOT DEPLOY. DRIVER HAD TO BE CUT OUT OF GMC3500. GMC TOTALED DRIVER SUFFERED BROKEN NECK. PHOTOS OBTAINED BUT NOT ABLE TO UPLOAD.

Service Brakes

ODI #10637206

Incident: September 17, 2014 · Filed: September 18, 2014

I WENT OUT TO MY TRUCK IN THE MORNING AND MY DASH BOARD INDICATOR TOLD ME TO GET MY BRAKES CHECKED; EVERYTHING WAS FINE THE NIGHT BEFORE. I BROUGHT THE TRUCK INTO MYMECHANIC AND FOUND OUT THAT MY BRAKE LINE IS CORRODED AND BROKEN. ALSO FOUND OUT THAT THIS A RECURRING AND CONSISTENT PROBLEM WITH THE GMC SIERRAS. I HAVE MY TRUCK SERVICED BY AN AUTHORIZED SERVICE CENTER ON A REGULAR BASIS AND THIS HAS NEVER BEEN MENTIONED TO ME. THIS NEEDS TO BE A RECALL ITEM! SERIOUS SAFETY THREAT. CANNOT IMAGINE WHAT COULD HAVE HAPPENED IF THIS OCCURRED 2 DAYS LATER WHEN I WAS PULLING OUR 40 FOOT RV. SHOULDN'T GM BE RESPONSIBLE FOR THIS? MY TRUCK IS NOW IN THE SHOP GETTING THE BRAKE LINE REPLACED. *TR

Steering

ODI #10482385

Incident: September 4, 2012 · Filed: October 26, 2012

I WAS DRIVING DOWN THE ROAD WHEN THE STEERING WHEEL LOCKED INTO PLACE. I HAD TO JERK IT HARD IN ORDER TO GET IT TO RELEASED FROM THE LOCKED POSITION. THIS HAS HAPPENED TWICE ALREADY. CAN EASILY CAUSE A CRASH. NEEDS TO BE FIXED BY MANUFACTURER. *TR

Tires

ODI #10406148

Incident: June 9, 2011 · Filed: June 13, 2011

NO EVENT JUST EVERY DAY DRIVING AND A TIRE A YEAR LEAKS FROM INNER LINING TO FORM A BUBBLE ON OUTSIDE OF TIRE WHICH BLOWS OUT. A TIRE A YEAR FOR THE LAST THREE YEARS. *TR

Power Train

ODI #10349466

Incident: August 15, 2010 · Filed: August 15, 2010

TRANSMISSION COOLING LINES LEAKING. *TR

Steering

ODI #10321261

Incident: March 1, 2010 · Filed: March 21, 2010

ON MARCH 8,2010 I TOOK MY CAR THAT I BOUGHT 2 YEARS AGO TO AN OFFICIAL EMISSIONS INSPECTION STATION; THE VEHICLE FAILED. AT THIS TIME I WAS GIVEN A SET OF RECALL PAPERS 09014 SPECIAL COVERAGE ADJUSTMENT ENGINE CONTROL MODULE- EMISSION RELATED REPROGRAMMING THAT EXPLAINED WHAT THE PROBLEM WAS. IN THE MEAN TIME I TOOK THE CAR TO GM . THEY TOLD ME IT WOULD COST $125 TO DIAGNOSE THE PROBLEM BY THE TIME THEY WERE DONE I HAD A BILL FOR $280 AND TOLD IT WOULD COST OVER $1000TO FIX THE CAR SO THAT COULD PASS (THEY NEED TO REPLACE THE STEERING COLUMN TO RECEIVE COMMUNICATION I SEE THERE IS A RECALL ON THAT) I WANT TO STATE THAT I SHOWED THE WORKERS AT GM THE PAPERS SHOWING WHAT THE PROBLEM WAS BUT I WAS TOLD THAT WAS NOT THE PROBLEM AND THEY THEN TOLD ME IF I WANT IT FIXED I WOULD HAVE TO PAY FOR IT.THIS OCCURRED AFTER I SIGNED A PAPER ALLOWING THEM TO "LOOK" AT THE CAR . I NEED SOMEONE IN AUTHORITY TO HELP ME FIND OUT THIS PROBLEM SHOULD HAVE BEEN TAKEN CARE OF BY GM AND WHETHER OR NOT THE ACTION OF GM WAS FRAUDULENT. THANK YOU TOOK THE VEHICLE INSPECTION TO THE STATE OF CONNECTICUT ON 3/19/2010 AND IT PASS INSPECTION. *TR

Power Train

ODI #10296732

Incident: December 10, 2009 · Filed: December 22, 2009

TL* THE CONTACT OWNS A 2006 GMC SIERRA 3500. WHILE EXAMINING THE VEHICLE HE NOTICED FLUID LEAKING FROM UNDER THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND HE WAS ADVISED THAT THE TRANSMISSION COOLING LINES NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 44000.

Power Train

ODI #10219627

Incident: December 14, 2007 · Filed: February 28, 2008

TRANSMISSION COOLING PIPES HAVE BEEN REPLACE TWO TIMES IN LAST THAN 20 MONTHS BECAUSE OF FLUID LEAKING. *TR

Other GMC Sierra 3500 model years

Check your 2006 GMC Sierra 3500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your GMC Sierra 3500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a GMC VIN