NHTSA vehicle safety data

2002 Four Winds Hurricane Recalls & Complaints

The 2002 Four Winds Hurricane has 2 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Four Winds dealer.

NHTSA recall and complaint data for the 2002 Four Winds Hurricane. Recall data is refreshed daily from NHTSA.

2002 Four Winds Hurricane owner complaints

Owners have filed 2 complaints with NHTSA about the 2002 Four Winds Hurricane, describing incidents dated September 17, 2003 to April 28, 2013.

Most-cited components

Equipment 1 complaint
Service Brakes 1 complaint

Of the 2 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #10544571 · Filed September 20, 2013
AT ABOUT 16,000 MILES THE BRAKE PEDAL BEGAN STICKING DOWN AND HAD TO BE PULLED BACK WITH MY FOOT RESULTING IN EXCESSIVE BRAKE PEDAL TRAVEL. AFTER HAVING TWO LEAKING PRESSURE SWITCHES REPLACED, THREE MASTER CYLINDERS INSTALLED AND THE BRAKES COMPLETELY REBUILT TWICE. THE PROBLEM NOW AT 134,000 MILES…
ODI #10511005 · Filed May 7, 2013
MICROWAVE, SAMSUNG MR5493G, BEGAN OPERATION BY ITSELF AND STARTED A FIRE. THE MICROWAVE IS DAMAGED BEYOND REPAIR. THE COACH FILLED WITH SMOKE. I HAVE CONTACTED SAMSUNG ABOUT NHTSA CAMPAIGN NUMBER 03E044000. IT TOOK SEVERAL CALLS TO GET THEM TO AGREE TO REPLACE THE UNIT. THEY OFFERED $200. TRANS…

Read all 2 complaints

FOUR WINDS/SAMSUNG/MICROWAVE

NHTSA #03V449000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported November 4, 2003 · FOUR WINDS INTERNATIONAL

Potentially affected: 12,918 vehicles

Vehicles built June 19, 1999 – June 30, 2002 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FOUR WINDS AT 1-219-266-1111.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FOUR WINDS/BRAKE SYSTEM WARNING INDICATOR

NHTSA #03V069000 · Service Brakes, Hydraulic — Brake Fluid Low Warning — Lamp · NHTSA notice

Reported March 5, 2003 · FOUR WINDS INTERNATIONAL

Potentially affected: 3,482 vehicles

Owners notified May 13, 2003 · Vehicles built September 30, 1999 – January 16, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Safety consequence

IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Manufacturer remedy

DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION BEGAN MAY 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FOUR WINDS AT 1-219-266-1111.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2002 Four Winds Hurricane. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

2 owner complaints have been filed with NHTSA for the 2002 Four Winds Hurricane.

Service Brakes

ODI #10544571

Incident: September 17, 2003 · Filed: September 20, 2013

AT ABOUT 16,000 MILES THE BRAKE PEDAL BEGAN STICKING DOWN AND HAD TO BE PULLED BACK WITH MY FOOT RESULTING IN EXCESSIVE BRAKE PEDAL TRAVEL. AFTER HAVING TWO LEAKING PRESSURE SWITCHES REPLACED, THREE MASTER CYLINDERS INSTALLED AND THE BRAKES COMPLETELY REBUILT TWICE. THE PROBLEM NOW AT 134,000 MILES WAS FOUND TO BE THE ABS MODULE AND VALVE KEEPING EXCESSIVE PRESSURE IN THE SYSTEM AND NOT ALLOWING THE PEDAL TO RETURN PROPERLY THUS CAUSING EXCESSIVE HEAT BUILDUP REQUIRING REPLACEMENT OF ROTORS, CALIPERS AND PADS ON ALL FOUR WHEELS TWICE. *TR

Equipment

ODI #10511005

Fire

Incident: April 28, 2013 · Filed: May 7, 2013

MICROWAVE, SAMSUNG MR5493G, BEGAN OPERATION BY ITSELF AND STARTED A FIRE. THE MICROWAVE IS DAMAGED BEYOND REPAIR. THE COACH FILLED WITH SMOKE. I HAVE CONTACTED SAMSUNG ABOUT NHTSA CAMPAIGN NUMBER 03E044000. IT TOOK SEVERAL CALLS TO GET THEM TO AGREE TO REPLACE THE UNIT. THEY OFFERED $200. TRANS 4119069438. THE COACH WAS SMOKE DAMAGED. I AM GETTING AN ESTIMATE TO REMOVE THE SMOKE DAMAGE. SAMSUNG AGREED TO PAY FOR THE SMOKE DAMAGE, TRANS 5105693753. I WAS CALLED, A VOICE MAIL LEFT AND SENT AN -EMAIL WITH INSTRUCTIONS ON HOW TO OBTAIN THE $200. I WAS THEN CALLED THE NEXT DAY AS IF THEY NEEDED TO GET A HOLD OF ME URGENTLY. ANOTHER VOICE MAIL WAS LEFT. I WAS TOLD I HAD 3 DAYS TO SEND IN THE PAPERWORK SENT IN THE E-MAIL OR LOSE THE OPPORTUNITY TO HAVE THE MICROWAVE RECALLED. THE E-MAIL SAID I HAD 2 WEEKS. I NEED TO WAIT FOR THE SMOKE DAMAGE ESTIMATE, WHICH SHOULD BE AT THE 3 DAY MARK. I FEEL SAMSUNG IS TRYING TO AVOID PAYING FOR ANY DAMAGES OR RECALL THIS MICROWAVE. I FELT I NEEDED TO REPORT THE INCIDENT AND SAMSUNG'S POOR HANDLING OF THIS RECALL. I WOULD LIKE TO KNOW WHAT SAMSUNG'S RESPONSIBILITY IN THIS RECALL IS. I HAVE OWNED THIS VEHICLE FOR 3 YEARS AND I WAS NEVER NOTIFIED OF THE RECALL. *TR

Other Four Winds Hurricane model years

Check your 2002 Four Winds Hurricane VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Four Winds Hurricane at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Four Winds VIN