2017 Ford Fusion Hybrid Recalls & Complaints

Incident: October 2, 2026 · Filed: October 2, 2026

Component: Power Steering Module Rack and Pinion assembly The wheel locked up as described below in the middle of me taking a left turn, with the errors popping up as described. The problem has been diagnosed by the local Ford dealership. Three warning lamps that are intermittently on when I start the vehicle, though are not always there: Steering Assist Fault Service Required Service AdvanceTrac Hill Start Assist Not Available. While these are up, the steering wheel will not turn without incredible effort, requiring a massive amount of force to turn the steering wheel, which results in very little change in the direction the car is moving.

Incident: September 1, 2026 · Filed: September 4, 2026

Backup camera lens is defective and has UV damage / hazing. Makes reversing extremely difficult and dangerous as the lens is not giving a good image output to the infotainment screen to the point it is difficult to identify anything (cars, pedestrians, etc). Ford has a known recall on the fusions for 2013-2016, and have excluded 2017-2020 model years even though hardware is the same. I have ordered and am replacing the backup camera myself. Seems to be a common/known issue. Hoping to log a complaint and have Ford reimburse me for the trouble.

Incident: August 25, 2026 · Filed: August 28, 2026

The rack and pinion has failed twice within 2 and a half years. The steering has completely gone out twice while driving, causing extremely unsafe circumstances that could put multiple people in danger. After doing some research this is a common issue with Ford Fusions which is putting a lot of people in danger since it is a loss of steering issue. My wheel completely locked up while driving on the highway, how is this part not recalled yet? There are two separate safety recalls dealing with steering issues but the rack and pinion is not specifically mentioned so it is not covered under recall. This is extremely unsafe. Please look into this. Thank you.

Incident: May 9, 2025 · Filed: May 15, 2025

While driving roughly 5mph leaving from being parked for over 1.5 hours the hybrid battery caught/ control module caught on fire. Causing part of the truck carpet to catch fire. Since there was someone in the backseat that quickly felt the heat they turned the car off and stopped. The fire was put out. We end having it towed to the ford dealership that could not identify the reason it caught on fire. This is a known issue but the recall only affected 2 days of production.

Incident: December 17, 2017 · Filed: March 17, 2025

The contact owns a 2017 Ford Fusion. The contact stated while using the key fob to start the vehicle, the heat on the front driver's seat and steering wheel failed to operate as intended. The contact manually depressed the button to turn on the heat. There was no warning light illuminated. The dealer was contacted and diagnosed that the instrument cluster and APIM needed to be replaced. The vehicle was repaired. The contact stated that the failure persisted. The vehicle was taken to a second dealer, White Bear Lincoln, Inc. (3425 Hwy 61 N, St Paul, MN 55110) who diagnosed that the instrument cluster and APIM needed to be replaced. The vehicle was repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The contact was informed that the warranty had expired and was referred to the NHTSA Hotline to report the failure. The failure mileage was 11,768.

Incident: August 27, 2024 · Filed: August 29, 2024

The contact owns a 2017 Ford Fusion Hybrid. The contact stated while making a left turn, the steering wheel made a complete 360-degree turn; however, the vehicle failed to respond as needed. Additionally, the horn and the buttons on the steering wheel became inoperable. The contact pushed up on the steering wheel, applying a lot of pressure, to steer the vehicle while turning. Additionally, when the vehicle was started, the air bag warning light illuminated. The vehicle was not diagnosed or repaired. The contact believed that the failures were associated with NHTSA Campaign Number: 18V167000 (Steering). The manufacturer was notified of the failure. The failure mileage was approximately 21,600.

Incident: June 4, 2024 · Filed: July 3, 2024

The contact owns a 2017 Ford Fusion Hybrid. The contact stated that while driving 40 MPH, the vehicle shut off unexpectedly. The message that the engine was overheating was displayed. The check engine warning light was illuminated. The RED Triangle Symbol (Master Warning Light) was illuminated. The vehicle was towed to an independent mechanic, who determined that the transmission was leaking and that the hybrid system, battery, and engine needed to be replaced. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was informed there were no open recalls on the VIN related to the failure. The contact was then referred to the NHTSA Hotline to report the failure. The approximate failure mileage was 180,000.

Incident: March 8, 2024 · Filed: April 1, 2024

Airbags failed to deploy at 30-40 mph head on collision. Vehicle had an airbag light come up, was inspected by Ford and the RCM module was replaced as directed by manual. Airbags were also inspected at the time. Lights were cleared after the replacement. Was the car not reading the speed at the time of the accident? My wife and 2 toddlers were in the vehicle at the time of the accident. I have a wrist injury and whiplash. Injuries could have been worse if it was a vehicle of twice the size or a semi.

Incident: February 19, 2024 · Filed: March 7, 2024

The contact owns a 2017 Ford Fusion Hybrid. The contact stated while driving at an undisclosed speed, the contact heard a loud grinding sound coming from the vehicle. The vehicle was taken to the dealer where it was diagnosed with a failed transmission bearing and that the transmission needed to be replaced. The vehicle was not repaired. The contact was informed about TSB: 22-2396 however, the contact was informed that the vehicle could not be repaired under the TSB. The manufacturer was made aware of the failure and the contact was advised to report the failure to the NHTSA Hotline. The failure mileage was approximately 104,000.

Incident: February 6, 2024 · Filed: March 6, 2024

The contact owns a 2017 Ford Fusion Hybrid. The contact stated that the steering wheel had fractured. The contact stated that due to the failure, the steering wheel had an abnormal up and down movement. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.