NHTSA vehicle safety data

2007 Fleetwood Terra Recalls & Complaints

The 2007 Fleetwood Terra has 3 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Fleetwood dealer.

NHTSA recall and complaint data for the 2007 Fleetwood Terra. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 Fleetwood Terra owner complaints

Owners have filed 3 complaints with NHTSA about the 2007 Fleetwood Terra, describing incidents dated July 3, 2007 to July 29, 2008.

Most-cited components

Engine 2 complaints
Electrical System 1 complaint
Equipment 1 complaint
Fuel/Propulsion System 1 complaint
Latches/Locks/Linkages 1 complaint
Structure 1 complaint

Newest complaints

ODI #10522657 · Filed July 1, 2013
2008 >101F STOPPED, LET ENGINE RUNNING FOR ABOUT 10MIN ENGINE TURNED OFF BY ITSELF. TRIED TO RESTART BUT, NO STARTER ENGAGEMENT, HAD TO TURN OF THE IGN. SWITCHED AND THEN THE ENGINE RESTARTED, CONTINUE TO DRIVE FOR A FEW MILES AND ENGINE TURNED OFF AGAIN THIS TIME IN THE MIDDLE OF THE ROAD. TRIED TO…
ODI #10239921 · Filed August 27, 2008
TL*THE CONTACT OWNS A 2007 FLEETWOOD TERRY LX31M. WHEN THE CONTACT ATTEMPTED TO CLOSE THE STORAGE DOOR ON THE DRIVER'S SIDE, THE LATCH WOULD NOT CONNECT. SHE COULD NOT CLOSE THE DOOR. THE CONTACT ALSO NOTICED THAT THE DOORS DID NOT FIT PROPERLY ON THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND…
ODI #10199884 · Filed August 17, 2007
THANK YOU FOR YOUR TIMELY INVESTIGATION INTO THE UNSAFE CONDITIONS OF THE 2007 FLEETWOOD TERRA LX MOTORHOME I CURRENTLY OWN. FIRST IS THE DIRECT POSITIONING OF THE EXHAUST PIPE UNDER THE FUEL FILL. FLEETWOOD OWNER RELATIONS IN NO WAY SEES THIS AS A POTENTIAL SAFETY HAZARD AND REFUSES TO ADDRESS THIS…

Read all 3 complaints

STEERING DRAG LINK/PITMAN ARM CONNECTION

NHTSA #08V442000 · Steering — Gear Box — Shaft Pitman · NHTSA notice

Reported August 28, 2008 · WORKHORSE CUSTOM CHASSIS

Potentially affected: 5,606 vehicles

Manufacturer campaign 20801-C · Owners notified September 19, 2008 · Vehicles built August 25, 2005 – March 20, 2007 (per NHTSA)

Defect description

WORKHORSE IS RECALLING 5,606 MY 2006-2008 W42 COMMERCIAL CHASSIS AND W18 RECREATIONAL VEHICLE CHASSIS. THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM MAY HAVE BEEN IMPROPERLY TORQUED DURING ASSEMBLY. THE IMPROPER TORQUE MAY HAVE DAMAGED THE CASTLE NUT AND COMPROMISED THE INTEGRITY OF THE CONNECTION.

Safety consequence

IF THE DRAG LINK WERE TO SEPARATE FROM THE PITMAN ARM, THE DRIVER WOULD NOT HAVE DIRECTIONAL CONTROL OF THE VEHICLE POSSIBLY CAUSING A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE AND PROPERLY TIGHTEN THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM. THE RECALL BEGAN ON SEPTEMBER 19, 2008. OWNERS MAY CONTACT WORKHORSE AT 1-877-946-7731 OR AT HTTP://WWW.NAVISTAR.COM.

Notes

WORKHORSE RECALL NO. 20801-C.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #08V320000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 15, 2008 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 70,101 vehicles

Owners notified October 24, 2008 · Vehicles built April 1, 2003 – November 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL RAIL PULSE DAMPER RETAINER CLIP/WORKHORSE

NHTSA #06V388000 · Engine and Engine Cooling · NHTSA notice

Reported October 4, 2006 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 7,858 vehicles

Owners notified September 1, 2006 · Vehicles built January 2, 2004 – July 7, 2006 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.

Safety consequence

IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.

Manufacturer remedy

WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2007 Fleetwood Terra. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

3 owner complaints have been filed with NHTSA for the 2007 Fleetwood Terra.

Electrical System; Engine

ODI #10522657

Incident: July 7, 2008 · Filed: July 1, 2013

2008 >101F STOPPED, LET ENGINE RUNNING FOR ABOUT 10MIN ENGINE TURNED OFF BY ITSELF. TRIED TO RESTART BUT, NO STARTER ENGAGEMENT, HAD TO TURN OF THE IGN. SWITCHED AND THEN THE ENGINE RESTARTED, CONTINUE TO DRIVE FOR A FEW MILES AND ENGINE TURNED OFF AGAIN THIS TIME IN THE MIDDLE OF THE ROAD. TRIED TO START IN NEUTRAL BUT, HAD TO PUT THE TRANSITION INTO PARK AND TURN OFF THE IGN. SWITCH AND THE ENGINE WOULD RESTARTED. CONTINUING 2 OR 3 MORE TIMES TILL THE VEHICLE WAS OPERATING AT SPEEDS >25MPH (~300MILES). TOOK THE VEHICLE IN FOR REPAIR A COUPLE OF ADJUSTMENTS MADE. NEXT USAGES THE EXTERNAL TEMP WAS MUCH LOWER 80 TO 85F AND WE HAD NO PROBLEMS. 2013 >105F STOPPED LEFT ENGINE RUNNING AND THE ENGINE TURNED OFF AGAIN ALL BY ITSELF. TRIED TO RESTART BUT, NO STARTER ENGAGEMENT SO, HAD TO TURN OF THE IGN. SWITCH AND THEN THE ENGINE RESTARTED, CONTINUED TO DRIVE TO CAMP SITE AND ENGINE CONTINUED TO DIE BY ITSELF (NOTE: ALARM POSTED NO J1850 ACTIVITY) UNTIL WE HAD TO WAIT >30MINS TILL THE ENGINE WOULD RESTART. THIS WAS ALL WHILE BLOCKING THE PATH WAY IN THE CAMP GROUNDS. BIGGEST FEAR IS THIS OCCURRING ON HIGHWAYS AS STEERING/BREAKS ARE QUESTIONABLE THIS CONDITION. SEARCHED THE WEB FOR RECALLS, NO J1850 NO CLEAR ACTIONS. I DID LOOK INTO THE J1850 PROTOCOL BY D. JOHN OLIVER INTEL CORPORATION AND FOUND THAT IC CHIPS USED HAVE A MAX TEMPERATURE OF 125C OR 257F. OPERATING TEMP OF THE ENGINE IS ~200F, EXHAUST MANIFOLD TEMPS >400F, VEHICLE IN AN IDLE CONDITION I.E. NO AIR FLOW ACROSS THE VEHICLE ECM (THE ECM IS MOUNTED ABOVE ENGINE/RADIATOR WHERE ALL THE HEAT FROM THE ENGINE COMPARTMENT EXITS IN AN IDLE CONDITION) IT IS VERY POSSIBLE THAT THE CHIPS ARE OVERHEATING AND UPON THE OVERHEATING CONDITION THE ECM NEEDS TO BE RESET I.E. HAVING TO TURN OFF THE IGNITION TO GENERATE A WAKE UP CONDITION... CHIPS (AU5780, AU5780A & 7510) NOT TESTED FOR TEMP. CONTINUING TO TEST NOW! *TR

Structure; Latches/Locks/Linkages

ODI #10239921

Incident: July 29, 2008 · Filed: August 27, 2008

TL*THE CONTACT OWNS A 2007 FLEETWOOD TERRY LX31M. WHEN THE CONTACT ATTEMPTED TO CLOSE THE STORAGE DOOR ON THE DRIVER'S SIDE, THE LATCH WOULD NOT CONNECT. SHE COULD NOT CLOSE THE DOOR. THE CONTACT ALSO NOTICED THAT THE DOORS DID NOT FIT PROPERLY ON THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE DOORS NEEDED TO BE ADJUSTED. SHE DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 6,027. UPDATED 09/24/08. *LJ THE STEPS EXTENDED WHEN THEY SHOULDN'T HAVE. UPDATED 09/26/08. 8JB

Engine and Engine Cooling; Fuel System, Gasoline; Equipment

ODI #10199884

Incident: July 3, 2007 · Filed: August 17, 2007

THANK YOU FOR YOUR TIMELY INVESTIGATION INTO THE UNSAFE CONDITIONS OF THE 2007 FLEETWOOD TERRA LX MOTORHOME I CURRENTLY OWN. FIRST IS THE DIRECT POSITIONING OF THE EXHAUST PIPE UNDER THE FUEL FILL. FLEETWOOD OWNER RELATIONS IN NO WAY SEES THIS AS A POTENTIAL SAFETY HAZARD AND REFUSES TO ADDRESS THIS DANGEROUS ENGINEERING DEFECT. HOWEVER, THIS SAME EXACT MODEL, 6 MONTH LATER IS NOW BEING PRODUCED WITH THE EXHAUST EXITING CORRECTLY FROM THE OPPOSITE SIDE. SECONDLY, DUE TO A DIFFERENT MANUFACTURING DEFECT, FLEETWOOD HAD TO 'MODIFY' THE FUEL FILLER NECK AND VENT LINE BECAUSE IT WOULD NOT TAKE FUEL. IMAGINE MY SURPRISE WHEN I SAW THEIR REPAIR WAS HELD TOGETHER BY ZIP TIES AND THIN METAL STRAPS. THIS IS SECURED IN NO WAY LIKE THE ORIGINAL CONFIGURATION. GIVEN THE FATIGUE PRONE MATERIALS USED IN THE MANUFACTURER'S REPAIR, I NOW QUESTION THE SAFETY OF THE FUEL DELIVERY SYSTEM. WHEN THIS REPAIR FAILS, POSSIBLY WHILE BEING DRIVEN, FUEL WILL BE THROWN EVERYWHERE UNDER THE COACH FOR MILES. DID I MENTION THIS PATCH WORK REPAIR IS DIRECTLY OVER THE EXHAUST PIPE? PLEASE ENSURE THESE UNSAFE CONDITIONS ARE ADDRESSED BY FLEETWOOD BEFORE SOMEONE IS INJURED OR KILLED. *TR

Other Fleetwood Terra model years

Check your 2007 Fleetwood Terra VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fleetwood Terra at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Fleetwood VIN