NHTSA vehicle safety data

2003 Fleetwood Southwind Recalls & Complaints

The 2003 Fleetwood Southwind has 8 NHTSA recall campaigns and 24 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Fleetwood dealer.

NHTSA recall and complaint data for the 2003 Fleetwood Southwind. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2003 Fleetwood Southwind owner complaints

Owners have filed 24 complaints with NHTSA about the 2003 Fleetwood Southwind, describing incidents dated March 1, 2005 to October 19, 2018.

Most-cited components

Service Brakes 16 complaints
Equipment 2 complaints
Electrical System 1 complaint
Engine 1 complaint
Fuel/Propulsion System 1 complaint
Suspension 1 complaint

Of the 24 complaints on file, 1 reports a fire (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11141924 · Filed October 22, 2018
3 TIMES NOW WHILE DRIVING MY BRAKES HAVE FAILED. BRAKES HAVE GOTTEN HOT AND OVERHEATED. CAN SMELL A BURNING SMELL. ABS LIGHTS COME ON. BRAKE PEDAL GOES TO THE FLOOR AND WILL NOT STOP. ONLY WAY TO STOP IS TO SHIFT VEHICLE TO LOW GEAR AND APPLY EMERGENCY BRAKE WHICH HAS TAKEN AN EXTREMELY LONG TIME…
ODI #11011396 · Filed July 28, 2017
WHAT DOES "THE VIN YOU ENTERED CANNOT BE PROCESSED AT THIS TIME. IF THE VIN WAS ENTERED CORRECTLY, PLEASE CONTACT YOUR VEHICLE MANUFACTURER FOR MORE INFORMATION. " MEAN WHEN I CANNOT FIND THE TRUE MANUFACTURER?
ODI #10907560 · Filed September 19, 2016
TL* THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND. WHILE DRIVING 25 MPH, THE BRAKE PEDAL FELT SPONGY WHEN DEPRESSED. APPROXIMATELY ONE MILE LATER, THE ABS INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 28,000. THE VIN…

Read all 24 complaints

NHTSA defect investigations

NHTSA's investigations file lists the 2003 Fleetwood Southwind in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE06-005: INADVERTENT SLIDE-OUT EXTENSION MOVEMENT
Closed May 2, 2006

Open and recently closed NHTSA defect investigations

REFRIGERATOR FIRE/NORCOLD

NHTSA #09V312000 · Equipment · NHTSA notice

Reported July 28, 2009 · FLEETWOOD RV, INC.

Potentially affected: 6,684 vehicles

Owners notified June 26, 2009 · Vehicles built June 22, 2001 – January 22, 2003 (per NHTSA)

Defect description

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 MOTORHOMES MANUFACTURED BETWEEN JULY 24, 2004 AND MARCH 11, 2005, EQUIPPED WITH NORCOLD MODEL 1200LR, 1200LRIM, AND 1201LRIM REFRIGERATORS WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Safety consequence

IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Manufacturer remedy

FLEETWOOD RV WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2009. OWNERS MAY CONTACT FLEETWOOD RV AT 1-800-509-3418 OR NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

OVERHEATED BRAKE CALIPERS/BOSCH/WORKHORSE

NHTSA #09V198000 · Service Brakes, Air · NHTSA notice

Reported June 2, 2009 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 509 vehicles

Owners notified May 1, 2009 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Safety consequence

THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.

Notes

REFRIGERATOR/DOMETIC

NHTSA #08V320000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported July 15, 2008 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 70,101 vehicles

Owners notified October 24, 2008 · Vehicles built April 1, 2003 – November 30, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Manufacturer remedy

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #07V120000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported March 19, 2007 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 167,096 vehicles

Owners notified May 10, 2007 · Vehicles built April 1, 1997 – July 31, 2003 (per NHTSA)

Defect description

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

INSTRUMENT CLUSTER/FMVSS 101 AND 105/WORKHORSE

NHTSA #06V115000 · Electrical System · NHTSA notice

Reported April 12, 2006 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 7,205 vehicles

Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 "CONTROLS AND DISPLAYS" AND NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

Safety consequence

AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.

Manufacturer remedy

WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN AND REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR FLEETWOOD AT 1-800-322-8216.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

FLEETWOOD/HITCH RECEIVER

NHTSA #04V352000 · Trailer Hitches · NHTSA notice

Reported July 20, 2004 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 8,969 vehicles

Fleetwood campaign 40715 · Owners notified August 23, 2004 · Vehicles built November 1, 2002 – March 23, 2004 (per NHTSA)

Defect description

CERTAIN MOTOR HOMES EQUIPPED WITH DRAW TITE HITCH RECEIVERS MAY BE MISSING ONE OR MORE WELDS BETWEEN THE HITCH RECEIVER BOX AND THE BOTTOM SUPPORT PLATE.

Safety consequence

THE WELDS COULD BREAK, ALLOWING THE HITCH RECEIVER BOX AND THE TOWED LOAD TO SEPARATE FROM THE TOWING VEHICLE, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE THE HITCH RECEIVER. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Notes

FLEETWOOD RECALL NO. 40715.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FLEETWOOD/SAMSUNG/MICROWAVE

NHTSA #03V452000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported November 4, 2003 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 60,877 vehicles

Recall influenced by NHTSA's Office of Defects Investigation

Defect description

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Safety consequence

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Manufacturer remedy

SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

FLEETWOOD/HYDRAULIC LEVELING JACK HOSES

NHTSA #03V344000 · Equipment — Mechanical — Integrated Jack/Leveler/Stabilizer · NHTSA notice

Reported September 16, 2003 · FLEETWOOD ENTERPRISES, INC.

Potentially affected: 1,100 vehicles

Fleetwood campaign 30908 · Owners notified October 3, 2003 · Vehicles built September 6, 2002 – July 22, 2003 (per NHTSA)

Defect description

ON CERTAIN MOTORHOMES BUILT ON WORKHORSE CHASSIS, THE HYDRAULIC HOSE OPERATING THE LEVELING JACK SYSTEM WAS ROUTED SO IT PLACES THE HOSE TOO CLOSE TO THE ENGINE EXHAUST. THE HOT EXHAUST CAN CAUSE THE HYDRAULIC HOSE TO MELT OR ABRADE, RELEASING HYDRAULIC FLUID.

Safety consequence

IF THE HYDRAULIC FLUID SHOULD IGNITE BY AN EXHAUST GAS RECIRCULATING TUBE OR OTHER HEAT SOURCE, THIS COULD CAUSE A FIRE.

Manufacturer remedy

DEALERS WILL INSPECT AND REPLACE DAMAGED HOSES AND RELOCATE THE AFFECTED HYDRAULIC LINES. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Notes

FLEETWOOD RECALL NO. 30908.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

try.vin has no NCAP crash-test rating on file for the 2003 Fleetwood Southwind. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

24 owner complaints have been filed with NHTSA for the 2003 Fleetwood Southwind.

Service Brakes

ODI #11141924

Incident: October 19, 2018 · Filed: October 22, 2018

3 TIMES NOW WHILE DRIVING MY BRAKES HAVE FAILED. BRAKES HAVE GOTTEN HOT AND OVERHEATED. CAN SMELL A BURNING SMELL. ABS LIGHTS COME ON. BRAKE PEDAL GOES TO THE FLOOR AND WILL NOT STOP. ONLY WAY TO STOP IS TO SHIFT VEHICLE TO LOW GEAR AND APPLY EMERGENCY BRAKE WHICH HAS TAKEN AN EXTREMELY LONG TIME WITH NARROW MISSES. ON TIME WHILE DRIVING DOWN A WINDY ROAD. ANOTHER TIME IN STOP AND GO TRAFFIC AND JUST AFTER THE BRAKES SMELLED OF BURNING. BY THE TIME I PULLED OVER SMOKE WAS COMING OUT OF THE FRONT BRAKES. I LIFTED THE FRONT WHEELS OFF OF THE GROUND AND THE WHEELS WOULD NOT TURN. I CRACKED OPEN A BRAKE LINE AND THE FLUID WAS BOILING. I REPLACED THE FRONT BRAKES AND CALIPERS ALSO BOTH FRONT ABS SENSORS. RECENTLY FOR THE THIRD TIME I LOST BRAKES AFTER TRAFFIC, A BURNING SMELL OCCURRED AND BRAKES WENT TO THE FLOOR AGAIN THIS TIME COMING FRONT THE REAR BRAKES. ALSO THE ABS LIGHT CAME ON. PLEASE HELP. ALSO THE BRAKE MASTER CYLINDER HAS BEEN REPLACED.

Unknown or Other

ODI #11011396

Incident: July 28, 2017 · Filed: July 28, 2017

WHAT DOES "THE VIN YOU ENTERED CANNOT BE PROCESSED AT THIS TIME. IF THE VIN WAS ENTERED CORRECTLY, PLEASE CONTACT YOUR VEHICLE MANUFACTURER FOR MORE INFORMATION. " MEAN WHEN I CANNOT FIND THE TRUE MANUFACTURER?

Service Brakes, Hydraulic

ODI #10907560

Incident: September 12, 2016 · Filed: September 19, 2016

TL* THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND. WHILE DRIVING 25 MPH, THE BRAKE PEDAL FELT SPONGY WHEN DEPRESSED. APPROXIMATELY ONE MILE LATER, THE ABS INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 28,000. THE VIN WAS NOT AVAILABLE. UPDATED 12/13/16*LJ THE CONSUMER LEARNED A RECALL WAS ISSUED ON THE BRAKES. THE ROTORS, CALIPERS SENSORS AND PADS WERE REPLACED. UPDATED 12/19/16.*JB

Fuel/Propulsion System

ODI #10892552

Incident: July 27, 2016 · Filed: August 2, 2016

GENERATOR FUEL LINE FROM MAIN TANK TO GENERATOR RUPTURED WHILE VEHICLE WAS IN MOTION ON AN INTERSTATE HIGHWAY.

Service Brakes, Air

ODI #10683210

Incident: February 13, 2015 · Filed: February 13, 2015

RECALL 09V198000 BOUGHT USED 2003 SOUTHWIND MOTORHOME AND ATTEMPTED AT SEVERAL WORKHORSE SERVICE CENTERS TO GET THE BRAKE RECALL PERFORMED. WAS TOLD BY ALL THAT WORKHORSE HAS NO CALIPERS TO SHIP AND NO PLANS TO ORDER ANY MORE. HOW CAN THIS BE ALLOWED TO HAPPEN WHEN THERE ARE STILL VEHICLES THAT NEED THE WORK PERFORMED? *TR

Service Brakes, Hydraulic

ODI #10368213

Incident: November 9, 2009 · Filed: November 29, 2010

TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND 36B. THE CONTACT STATED THAT THE ABS FAILED WITHOUT WARNING; THE CALIPERS STUCK AND THE ABS NO LONGER FUNCTIONED AFTER HAVING THEM REPLACED. THE DEALER STATED THAT THE ABS WAS SET TO NOT WORK. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 14,000 AND THE CURRENT MILEAGE WAS 16,948.

Service Brakes, Hydraulic

ODI #10344921

Incident: February 10, 2010 · Filed: July 23, 2010

TL*THE CONTACT OWNS 2003 FLEETWOOD SOUTHWIND MOTORHOME ON A WORK HORSE CHASSIS. THE CONTACT STATED THAT WHEN THE BRAKES WERE APPLIED THEY FAILED. THE CONTACT PULLED OVER AND INSPECTED THE BRAKES AND THEN CONTINUED TO DRIVE. WHEN THE CONTACT REACHED HIS DESTINATION HE NOTICED THAT THE BRAKES WERE EXTREMELY HOT. THE CONTACT CALLED THE MANUFACTURER REGARDING THE BRAKES AND CALIPERS AND STATED THAT THE REPLACEMENT BRAKES WERE ON BACK ORDER. THE CONTACT PURCHASED AFTER MARKET BRAKES TO REPLACE THE CURRENT BRAKES ON THE VEHICLE. AFTER REPLACING THE BRAKES AND CALIPERS THE CALIPERS BEGAN TO LEAK. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS REFERRED BY THE MANUFACTURER. THE DEALER REPLACED THE ROTORS, CALIPERS, AND THE BRAKE PADS. THE FAILURE HAD NOT RECURRED. THE CONTACT STATED THAT WORKHORSE DID COMPENSATE HIM FOR THE REPAIRS. THE FAILURE MILEAGE WAS 26,000.

Service Brakes, Hydraulic

ODI #10334963

Incident: February 5, 2007 · Filed: June 7, 2010

TL* THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND RV. WHILE THE CONTACT WAS DRIVING AT APPROXIMATELY BETWEEN 50-55 MPH, THERE WAS A BURNING SMELL INSIDE OF THE VEHICLE. THE BRAKE PEDAL WAS APPLIED WITH NO POWER RESPONSE. SUDDENLY, THE EMERGENCY BRAKE WAS ENGAGED AND THE VEHICLE WAS ABLE TO SLOW DOWN. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF. THE VEHICLE RESUMED OPERATION NORMALLY. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALERSHIP THREE TIMES FOR THE IDENTICAL FAILURES WITH NO REPAIRS. THE FAILURE WAS CONTRIBUTED TO THE REAR BRAKE CALIPERS. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 29,000. UPDATED 09/01/10. *LJ UPDATED 09/14/10

Service Brakes, Hydraulic

ODI #10329276

Fire

Incident: April 30, 2010 · Filed: May 7, 2010

TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND MOTOR HOME. WHILE DRIVING 35 MPH, WHEN THE CONTACT APPLIED THE BRAKES, THE PEDAL EXTENDED TO THE FLOORBOARD AND THE VEHICLE BEGAN PULLING TO THE RIGHT. WHEN THE FAILURE OCCURRED THERE WAS ALSO A BURNING SMELL. AFTER EXAMINING THE VEHICLE, THE CONTACT SAW BRAKE FLUID UNDERNEATH THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE REAR BRAKE CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 16,000.

Service Brakes, Hydraulic

ODI #10319996

Incident: February 8, 2010 · Filed: March 15, 2010

FRONT END HAD BEGUN TO MILDLY VIBRATE WHEN BRAKES WERE APPLIED. ON CURSORY INSPECTION COULD TELL THAT AT LEAST ONE OF THE FRONT ROTORS WAS CRACKED CLEAR THROUGH. CALLED WORKHORSE, WAS DIRECTED TO CLOSEST REPAIR SHOP. FOUND BOTH FRONT ROTORS WITH MULTIPLE CRACKS, SOME CLEAR THROUGH ON BOTH FRONT. BRAKE PADS ONLY 1/3 GONE, NO EVIDENT GLAZE OR HEAT SIGNS APPARENT (PICTURES AVAILABLE ON REQUEST) ON THE PADS. CALIPERS WERE FUNCTIONING PROPERLY. ROTORS WERE REPLACED AND THE BRAKE PADS WERE REPLACED AS SAFETY PRECAUTION. I KNOW ABOUT THE SAFETY RECALL FOR THE CALIPERS WHICH GUIDES ME TO BELIEVE THAT SOME HOW THEY ARE RELATED DIRECTLY TO MY ROTOR FAILURES. THERE ARE NO SIGNS OF EXCESSIVE HEAT THAT WOULD BE DUE TO CONTINUOUS HARD BRAKING OR RIDING THE BRAKES. I AM A VERY EXPERIENCED DRIVER (50 YEARS) AND I KNOW HOW TO AVOID OVERHEATING THE BRAKES, PRIMARILY TO KEEP THEM FUNCTIONING WHEN YOU NEED THEM. THESE REPAIRS (AT 34,000) COST $954, I SENT REQUEST FOR REIMBURSEMENT TO WORKHORSE WHICH WAS PROMPTLY DENIED. SO NOW I AM FILING AN OFFICIAL COMPLAINT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Other Fleetwood Southwind model years

Check your 2003 Fleetwood Southwind VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Fleetwood Southwind at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Fleetwood VIN