NHTSA vehicle safety data

2007 Dodge Ram 3500 Recalls & Complaints

The 2007 Dodge Ram 3500 has 14 NHTSA recall campaigns and 210 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Dodge dealer.

NHTSA recall and complaint data for the 2007 Dodge Ram 3500. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2007 Dodge Ram 3500 owner complaints

Owners have filed 210 complaints with NHTSA about the 2007 Dodge Ram 3500, describing incidents dated February 9, 2007 to July 26, 2026.

Most-cited components

Steering 88 complaints
Air Bags 36 complaints
Engine 33 complaints
Suspension 31 complaints
Electrical System 24 complaints
Power Train 14 complaints

Of the 210 complaints on file, 14 report a crash and 14 a fire; across all 210 complaints, owners report 9 injuries (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11753921 · Filed July 31, 2026
The sound proofing insulation on the firewall caught fire. There was a recall for sagging insulation catching fire on the EGR heat exchanger for this problem, and mine caught fire anyway. I called 911 and the Corbin KY fire department responded to the seen to confirm the fire was out.
ODI #11750160 · Filed July 13, 2026
Steering yes it is available for inspection upon request The steering becomes so out the vibration becomes so violent that you can NOT HOLD THE WHEEL you have to pull over anyone driving could be in danger including vehicles around you with how violent the steering wheel vibrates When taken for…
ODI #11680308 · Filed August 13, 2025
I bought my 2007.5 Dodge Ram 3500 6.7L cummins in 2020 and had Commercial Tire install 4 Brand new Cooper Discoverer AT3 XLT and all was great until it wasn't. We mainly drive our pickup local to where we live and the highway speeds are 55mph. In 2025 April I had the front end completely rebuilt and…

Read all 210 complaints

Owner-reported

2007 Dodge Ram 3500 mileage at failure

150 of the 210 complaints on file for the 2007 Dodge Ram 3500 give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Steering	Median 95,000 miles	Middle half 65,000–120,000 miles	Based on 63 complaints
Suspension	Median 75,000 miles	Middle half 30,000–130,000 miles	Based on 30 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2007 Dodge Ram 3500 in 4 investigations. Audit Queries and Equipment Queries are administrative investigations: they look at whether companies complied with federal vehicle safety requirements, such as reporting, recall and certification rules, not at a possible vehicle defect. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Engineering Analysis EA21-002: Desiccated Air Bag Inflator Rupture
Open since September 17, 2021
Engineering Analysis EA15-001: Air Bag Inflator Rupture
Open since February 24, 2015
- Recall 14V-668
- Recall 15V-284
- Recall 15V-285
- Recall 15V-286
- Recall 15V-287
- Recall 15V-312
- and 188 more on the investigation page
Audit Query AQ14-003: Chrysler's execution of 13V-528 & 529
Closed May 16, 2016
Preliminary Evaluation PE14-016: Air Bag Inflator Rupture
Closed March 2, 2015
- Recall 13V-172
- Recall 14V-428
- Recall 14V-700
- Recall 14V-763
- Recall 14V-770
- Recall 14V-787
- and 3 more on the investigation page

Open and recently closed NHTSA defect investigations

Do Not Drive - Passenger Frontal Air Bag Inflator May Rupture

NHTSA #16V352000 · Air Bags — Frontal — Passenger Side — Inflator Module · NHTSA notice

Reported May 24, 2016 · Chrysler (FCA US LLC)

Potentially affected: 4,648,270 vehicles

Repair completion: 43.53% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign S43 · Owners notified March 27, 2017 · Vehicles built January 1, 2005 – October 1, 2009 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Dodge dealer immediately.

Defect description

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Safety consequence

These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Do Not Drive - Driver Side Frontal Air Bag May Rupture

NHTSA #15V313000 · Air Bags — Frontal — Driver Side — Inflator Module · NHTSA notice

Reported May 26, 2015 · Chrysler (FCA US LLC)

Potentially affected: 4,077,169 vehicles

Repair completion: 47.11% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign R25 · Owners notified June 8, 2015 · Vehicles built January 1, 2005 – December 31, 2009 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Recall group: Takata airbag inflators

DO NOT DRIVE — this recall carries a "do not drive" advisory. Contact a Dodge dealer immediately.

Defect description

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Safety consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Manufacturer remedy

Owners are advised not to drive their vehicle until the recall repair is complete. Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Clutch Ignition Interlock Switch

NHTSA #14V795000 · Electrical System — Ignition — Switch · NHTSA notice

Reported December 16, 2014 · Chrysler Group LLC

Potentially affected: 54,164 vehicles

Repair completion: 31.67% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign P80 · Owners notified March 27, 2015 · Vehicles built July 1, 2005 – July 31, 2006 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

Chrysler Group LLC (Chrysler) is recalling certain model year 2006-2007 Dodge Ram 1500, 2500, 3500, Dakota, and 2006 Mitsubishi Raider vehicles manufactured July 1, 2005, to July 31, 2006 with manual transmissions. The return springs in the clutch ignition interlock switch may break.

Safety consequence

Broken springs can result in a no-start condition, or cause unintended movement when the ignition is cranked, increasing the risk of a vehicle crash.

Manufacturer remedy

Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on March 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P80.

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Failure of the Left Tie Rod Assembly

NHTSA #13V528000 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported November 6, 2013 · Chrysler Group LLC

Potentially affected: 706,664 vehicles

Repair completion: 31.96% (latest rate the manufacturer reported to NHTSA; dataset updated November 3, 2026)

Manufacturer campaign N62 · Owners notified January 17, 2014 · Vehicles built February 12, 2002 – February 13, 2008 (per NHTSA)

Defect description

Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.

Safety consequence

A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.

Manufacturer remedy

Chrysler notified owners and launched its recall campaign in January 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N62.

Notes

This recall supersedes Chrysler tie rod recall 11V350. Vehicles that were previously remedied under recall 11V350 are also affected by this campaign. Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

OUTER TIE ROD FAILURE

NHTSA #11V350000 · Steering — Linkages — Tie Rod Assembly · NHTSA notice

Reported July 6, 2011 · CHRYSLER GROUP LLC

Potentially affected: 242,780 vehicles

Manufacturer campaign L16 · Owners notified October 3, 2011 · Recall influenced by NHTSA's Office of Defects Investigation

Defect description

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 2500/3500 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; MODEL YEAR 2008-2011 DODGE RAM 3500 CAB CHASSIS 4X2, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; AND MODEL YEAR 2008 DODGE RAM 1500 MEGA CAB 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH AUGUST 15, 2008, BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE. THIS CONDITION TENDS TO OCCUR DURING LOW SPEED PARKING LOT TYPE MANEUVERS WHEN THE CUSTOMER IS MAKING A TIGHT TURN. ADDITIONALLY, MODEL YEAR 2003-2008 DODGE RAM 2500/3500 VEHICLES MAY HAVE RECEIVED THE AFFECTED TIE ROD ASSEMBLY AS A REPLACEMENT PART DURING NORMAL SERVICE.

Safety consequence

THIS CONDITION COULD RESULT IN THE POTENTIAL LOSS OF DIRECTIONAL STABILITY IN THE LEFT HAND FRONT WHEEL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL INSPECT THE TIE ROD ENDS FOR RELATIVE ORIENTATION AND REPLACE THE LEFT OUTER TIE ROD AS REQUIRED AND PERFORM A FRONT END TOE ALIGNMENT AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 3, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes

CHRYSLER SAFETY RECALL NO. L16.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AFTERMARKET REPLACEMENT PITMAN ARMS

NHTSA #10E013000 · Steering — Gear Box — Shaft Pitman · NHTSA notice

Reported May 3, 2010 · FABTECH MOTORSPORTS

Potentially affected: 1,500 vehicles

Owners notified May 24, 2010

Defect description

FABTECH IS RECALLING CERTAIN AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS93001 AND FT44039, INSTALLED FOR USE ON CERTAIN 2003 THROUGH 2008 DODGE 2500 4WD, 3500 4WD, AND 1500 4WD MEGA CAB VEHICLES. THE PITMAN ARM CAN FRACTURE AND BREAK AWAY FROM THE STEERING BOX CAUSING TOTAL LOSS OF STEERING CONTROL.

Safety consequence

STEERING LOSS COULD RESULT IN A VEHICLE CRASH POSSIBLY RESULTING IN PROPERTY DAMAGE, INJURY OR DEATH.

Manufacturer remedy

FABTECH WILL NOTIFY OWNERS AND AUTHORIZED INSTALLERS WILL INSPECT FOR DEFECTIVE PITMAN ARM AND REPLACE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 24, 2010. OWNERS MAY CONTACT FABTECH AT 1-877-432-2832.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET FABTECH REPLACEMENT PITMAN ARMS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DODGE 2500, 3500, AND 1500 VEHICLES MANUFACTURED BY CHRYSLER GROUP, LLC.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

AIRV CEILING ASSEMBLIES/HEATER ELEMENT

NHTSA #09V434000 · Equipment — Appliance — Air Conditioner · NHTSA notice

Reported November 13, 2009 · ENG MOBILE SYSTEM, INC

Potentially affected: 53 vehicles

Owners notified December 31, 2009 · Vehicles built May 1, 2007 – August 31, 2009 (per NHTSA)

Defect description

E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Safety consequence

THIS DEFECT COULD RESULT IN A FIRE.

Manufacturer remedy

E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.

Notes

OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

ENGINE COMPARTMENT FIRE

NHTSA #08V641000 · Engine and Engine Cooling — Engine — Diesel · NHTSA notice

Reported December 5, 2008 · CHRYSLER LLC

Potentially affected: 108,429 vehicles

Manufacturer campaign H34 · Owners notified January 26, 2009 · Vehicles built January 1, 2007 – November 5, 2007 (per NHTSA)

Defect description

CHRYSLER IS RECALLING 108,429 MY 2007-2008 DODGE RAM 2500 AND 3500 PICKUP TRUCKS EQUIPPED WITH 6.7L DIESEL ENGINES. A SILENCER PAD CAN SAG AND CONTACT THE EXHAUST GAS RECIRCULATION (EGR) COOLER.

Safety consequence

THIS COULD RESULT IN AN ENGINE COMPARTMENT FIRE.

Manufacturer remedy

DEALERS WILL ADD A BRACKET TO SUPPORT THE ENGINE COMPARTMENT SILENCER PAD ADJACENT TO THE EGR COOLER. THE RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Notes

CHRYSLER RECALL NO. H34.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

BUMPER/HITCH

NHTSA #08V344000 · Trailer Hitches · NHTSA notice

Reported July 28, 2008 · KNAPHEIDE MANUFACTURING COMPANY

Potentially affected: 108 vehicles

Owners notified August 15, 2008 · Vehicles built October 23, 2006 – July 15, 2008 (per NHTSA)

Defect description

KNAPHEIDE IS RECALLING 108 MY 2006-2008 PRO SERIES TRUCK BEDS EQUIPPED WITH AN ICC BUMPER WHICH INCLUDED A PROVISION FOR A BALL HITCH. THERE MAY BE AN INSUFFICIENT WELD ATTACHING THE HITCH CHANNEL TO THE SUPPORTING STRUCTURE.

Safety consequence

THIS COULD RESULT IN BENDING OF THE HITCH CHANNEL OR THE HITCH COULD BE PULLED OFF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

KNAPHEIDE WILL OFFER TWO REMEDIES TO ITS CUSTOMERS: (1) FOR THOSE CUSTOMERS WHO DO NOT USE THE HITCH, THE HITCH WILL BE REMOVED FROM THE TRUCK BED AND REPLACED WITH AN ICC BUMPER; OR (2) FOR THOSE CUSTOMERS WHO NEED A HITCH, A RECEIVER HITCH ASSEMBLY WILL BE ADDED TO THE EXISTING HITCH ASSEMBLY AND ALL SUSPECT WELD JOINTS WILL BE RE WELDED. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT KNAPHEIDE AT 1-877-473-5763.

Notes

CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

CURVED TEMPERED AUTOMOTIVE REPLACEMENT GLASS

NHTSA #07E104000 · Visibility — Glass, Side/Rear · NHTSA notice

Reported December 11, 2007 · SAFELITE FULFILLMENT, INC.

Potentially affected: 1,657 vehicles

Owners notified January 15, 2008

Defect description

CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."

Safety consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.

Manufacturer remedy

SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.

Notes

THIS RECALL ONLY PERTAINS TO CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS, LTD. (DOT-430) AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON THE VEHICLES LISTED ABOVE. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

FUEL TANK STRAPS

NHTSA #07V472000 · Fuel System, Gasoline — Storage — Tank Assembly · NHTSA notice

Reported October 9, 2007 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 548 vehicles

Manufacturer campaign G34 · Owners notified November 12, 2007 · Vehicles built February 24, 2006 – June 28, 2007 (per NHTSA)

Defect description

ON CERTAIN CAB/CHASSIS PICKUP TRUCKS EQUIPPED WITH AN OPTIONAL 23 GALLON FUEL TANK, THE FUEL TANK STRAPS WERE IMPROPERLY MANUFACTURED AND COULD SEPARATE. THIS CAN CAUSE THE FUEL TANK TO LOOSEN AND LEAK FUEL.

Safety consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERBODY FIRE.

Manufacturer remedy

DEALERS WILL REPLACE THE FUEL TANK RETENTION STRAPS AND FASTENERS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 12, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. G34.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REPLACEMENT PITMAN ARM FAILURE

NHTSA #07E009000 · Suspension · NHTSA notice

Reported February 1, 2007 · L.K.I. ENTERPRISES, INC.

Potentially affected: 3,350 vehicles

Manufacturer campaign 07-01PIT · Owners notified March 12, 2007

Defect description

CERTAIN LKI ENTERPRISES, INC., BRAND NAME SUPERLIFT SUSPENSION, PITMAN ARMS SOLD AS REPLACEMENT EQUIPMENT FOR 2003-2007 DODGE RAM 2500 AND 3500 4X4 LIGHT TRUCKS. DUE TO INADEQUATE HEAT TREATMENT DURING PRODUCTION, THE AFFECTED PITMAN ARMS MAY DEVELOP CRACKS IN THE UPPER SPLINED ATTACHMENT ATTACHMENT TO THE STEERING OUTPUT SHAFT. MOVEMENT BETWEEN THE PITMAN ARM AND THE OUTPUT SHAFT MAY DEFORM SPLINES, RESULTING IN PREMATURE WEAR AND FATIGUE FAILURE OF THE AFFECTED PITMAN ARM.

Safety consequence

PITMAN ARM WEAR OR FAILURE MAY LEAD TO LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Manufacturer remedy

LKI WILL NOTIFY OWNERS AND REPLACE THE PITMAN ARM, IF NECESSARY. THE RECALL BEGAN ON MARCH 12, 2007. OWNERS MAY CONTACT LKI AT 1-800-551-4955.

Notes

LKI RECALL NO. 07-01PIT.THIS RECALL ONLY PERTAINS TO REPLACEMENT LKI, SUPERLIFT SUSPENSION KITS,AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON DODGE RAM 4X4 LIGHT TRUCKS MANUFACTURED BY DAIMLERCHRYSLER.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

REAR VIEW MIRRORS/FMVSS 111

NHTSA #06V380000 · Visibility — Rearview Mirrors/Devices · NHTSA notice

Reported October 10, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 309 vehicles

Manufacturer campaign F46 · Owners notified October 10, 2006 · Vehicles built December 23, 2005 – September 8, 2006 (per NHTSA)

Defect description

CERTAIN TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 111, "REAR VIEW MIRRORS". THE RIGHT OUTSIDE REAR VIEW MIRROR GLASS HAS A CURVED (CONVEX) MIRROR GLASS INSTALLED INSTEAD OF FLAT GLASS. CURVED GLASS CREATES A WIDER VIEW, BUT DISPLAYS IMAGES FURTHER AWAY THAN THEY ACTUALLY ARE.

Safety consequence

DRIVERS OF LARGE VEHICLES MAY HAVE DIFFICULTY JUDGING DISTANCE RELATIONSHIPS, WHICH COULD CAUSE A CRASH WITHOUT PRIOR WARNING.

Manufacturer remedy

DEALERS WILL REPLACE THE RIGHT OUTSIDE CONVEX MIRROR GLASS WITH A FLAT MIRROR GLASS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 10, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F46.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

POWERTRAIN CONTROL MODULE

NHTSA #06V341000 · Power Train — Automatic Transmission · NHTSA notice

Reported September 7, 2006 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 4,770 vehicles

Manufacturer campaign F43 · Owners notified October 2, 2006 · Vehicles built July 1, 2006 – August 11, 2006 (per NHTSA)

Defect description

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE SOFTWARE PROGRAMMED INTO THE POWERTRAIN CONTROL MODULE CAN CAUSE A MOMENTARY LOCK UP OF THE DRIVE WHEELS IF THE VEHICLE IS TRAVELING OVER 40 MPH AND THE OPERATOR SHIFTS FROM DRIVE TO NEUTRAL AND BACK TO DRIVE.

Safety consequence

IF THE DRIVE WHEELS LOCKED UP, LOSS OF VEHICLE CONTROL COULD OCCUR INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. F43. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

try.vin has no NCAP crash-test rating on file for the 2007 Dodge Ram 3500. NHTSA rates some vehicles by body style — pickups by cab, vans by roof height — so check nhtsa.gov/ratings.

210 owner complaints have been filed with NHTSA for the 2007 Dodge Ram 3500.

Unknown or Other

ODI #11753921

Fire

Incident: July 26, 2026 · Filed: July 31, 2026

The sound proofing insulation on the firewall caught fire. There was a recall for sagging insulation catching fire on the EGR heat exchanger for this problem, and mine caught fire anyway. I called 911 and the Corbin KY fire department responded to the seen to confirm the fire was out.

Steering

ODI #11750160

Incident: July 5, 2026 · Filed: July 13, 2026

Steering yes it is available for inspection upon request The steering becomes so out the vibration becomes so violent that you can NOT HOLD THE WHEEL you have to pull over anyone driving could be in danger including vehicles around you with how violent the steering wheel vibrates When taken for alignment was told there definitely was a problem said could be a brake caliper hanging up so we put new calipers changed ball joints shocks control arm steering geer box shocks steering dampers trac bar front end alignment & tires balanced Vehicle has not been inspected by anyone but the mechanic that aligned it No warning lights the problem started with a shimmy so we would get it aligned and check tires went on line and found and found a letter that there was a serious problem with 1994 to 2008 Dodge Rams Steering Linkage and the system on our vehicle a Y design is not capable of handling the weight of this vehicle from a article and a letter i read from Chrysler incident has been going on for some time but date below was very serious

Tires

ODI #11680308

Incident: August 12, 2025 · Filed: August 13, 2025

I bought my 2007.5 Dodge Ram 3500 6.7L cummins in 2020 and had Commercial Tire install 4 Brand new Cooper Discoverer AT3 XLT and all was great until it wasn't. We mainly drive our pickup local to where we live and the highway speeds are 55mph. In 2025 April I had the front end completely rebuilt and rotated the tires. My son found a dirtbike that was about 3.5 hours away which included freeway driving and as soon as we hit 70mph for about 15 miles I started feeling a vibration it was fairly light at first and on our return trip it steadily got worse. We were about 15 to 20 miles from home and the vibration and bouncing feeling got so bad that we had to slow down to 40 to 45 mph because it was shaking so bad it made you dizzy. I stopped several times to look over the pickup and couldn't figure out what was causing the severe vibration/bouncing. I made it a few more miles and stopped to look over my pickup and that's when I noticed that the drivers front tire was extremely wavy and the tread are was separating. I ended up having to limp it home (at 25mph) the rest of the way on the backroads so I could keep the speed down and keep from killing me or my family or other people on the road these tires have around 15k miles on them. Now I am going to have to replace all 4 because they are unsafe. These tires are mounted on OEM wheels. Size are LT275/70R17 I run Cooper Discoverer AT3 tires on all 3 of my vehicles and now I'm very concerned about those tires as well. I'm going to have to replace the tires on my wife's vehicle as well because I don't want to risk my wife and kids getting into a accident. I hope something is done to remedy this problem because I don't have 4 thousand dollars to replace these defective tires on all my vehicles.

Engine

ODI #11639442

Fire

Incident: January 28, 2025 · Filed: January 29, 2025

Smoke started coming from the hood. I opened the hood and the engine had caught fire

Electrical System; Engine

ODI #11407492

Incident: April 5, 2021 · Filed: April 11, 2021

60 MILES FROM HOME AFTER A 2,000 MILE CAMPING TRIP THE TRUCK SUDDENLY STOPPED. TRAVELING NORTH ON HIGHWAY191 IN YELLOWSTONE PARK THE DASH LIGHTS STARTED TO FLASH AND THE TRUCK DIED. I WAS BARELY ABLE TO PULL OFF THE NARROW ROAD. EMERGENCY FLASHERS DIDN'T WORK AND THERE WAS NO CELLPHONE SERVICE, SNOW WAS FALLING AND TRUCKS BARELY ABLE TO GET AROUND US, WE FEARED FOR OUR LIVES. I OPENED UP THE HOOD AND SMELLED BURNING PLASTIC, THE TIPM WAS MELTED IN SPOTS. FINALLY A KIND MOTORIST STOPPED TO SEE IF WE NEEDED HELP, 20 MILES FURTHER DOWN THE ROAD HE WAS ABLE TO CALL A TOWING SERVICE WHICH TOOK ANOTHER SEVERAL HOURS TO GET TO US. WE WERE TOWED TO A DODGE DEALERSHIP IN BOZEMAN WHERE IT WILL BE ANOTHER2 WEEKS BEFORE THEY CAN GET IT IN.

Power Train

ODI #11228977

Incident: July 3, 2018 · Filed: July 2, 2019

TL* THE CONTACT OWNS A 2007 DODGE RAM 3500. THE CONTACT STATED THAT THE VEHICLE FAILED TO DRIVE DUE TO THE GEAR SHIFTER, BUT LATER THE VEHICLE WOULD TAKE OFF. THERE WERE NO WARNING INDICATORS ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE SHIFT FAILURE RECURRED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION COMPUTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. IN ADDITION, WHEN THE VEHICLE WAS PURCHASED WITH 172,000 MILES, THE TRANSMISSION WAS ALREADY FAILING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 176,000. THE VIN WAS NOT AVAILABLE.

Steering

ODI #11219586

Incident: June 11, 2019 · Filed: June 12, 2019

WHILE BACKING INTO PARKING PLACE, PASSENGER SIDE TIE ROD END POPPED OFF JOINT CAUSING ME TO LOOSE STEERING CONTROL AND NEARLY RESULTED IN A COLLISION.

Power Train

ODI #11207926

Incident: April 3, 2019 · Filed: May 15, 2019

MY TRUCK SHIFTED ITSELF IN 4WD LOW WHILE GOING 75 MPH DOWN THE INTERSTATE WHICH DESTROYED MY TRANSFER CASE AND TRANSMISSION AND CAUSED MY DRIVE SHAFT TO COME LOOSE WHICH I FEEL IS A VERY DANGEROUS DEFECT AS IT COULD HAVE ROLLED MY TRUCK. I HAVE FOUND OTHERS THAT HAVE HAD THIS HAPPEN APPARENTLY BECAUSE OF A ELECTRONIC TRANSFER CASE MOTOR READING THE WRONG SIGNAL AND SHIFTING INTO LOW RANGE WHETHER THE TRUCK IS MOVING OR EVEN RUNNING. IT'S SOMETHING THAT SHOULDN'T HAPPEN ESPECIALLY WITH A MANUAL 4WD SHIFTER

Air Bags

ODI #11161950

Incident: December 14, 2016 · Filed: December 17, 2018

TL* THE CONTACT OWNS A 2007 DODGE RAM 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V313000 (AIR BAGS). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. BREWBAKER DODGE CHRYSLER JEEP RAM OF PRATTVILLE (2209 COBBS FORD RD, PRATTVILLE, AL 36066, (334) 491-0701) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Steering

ODI #11114234

Incident: June 30, 2018 · Filed: July 27, 2018

I MADE A RIGHT TURN INTO A PARKING LOT AND THE PASSENGER TIE ROD BROKE. MY TRUCK WAS TOWED TO THE DODGE DEALER. UPDATED STEERING LINKAGE INSTALLED.

Other Dodge Ram 3500 model years

Check your 2007 Dodge Ram 3500 VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Dodge Ram 3500 at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Dodge VIN