NHTSA vehicle safety data

2002 Dodge Intrepid Recalls, Ratings & Complaints

The 2002 Dodge Intrepid has 3 NHTSA recall campaigns and 329 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Dodge dealer.

NHTSA recall and complaint data for the 2002 Dodge Intrepid, plus NCAP crash-test ratings. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2002 Dodge Intrepid owner complaints

Owners have filed 329 complaints with NHTSA about the 2002 Dodge Intrepid, describing incidents dated December 1, 2001 to February 15, 2022.

Most-cited components

Engine 212 complaints
Power Train 60 complaints
Service Brakes 16 complaints
Electrical System 15 complaints
Steering 15 complaints
Air Bags 10 complaints

Of the 329 complaints on file, 11 report a crash and 9 a fire; across all 329 complaints, owners report 9 injuries and 1 death (owner-reported, not verified by NHTSA).

Newest complaints

ODI #11458243 · Filed March 24, 2022
The contact owns a 2002 Dodge Intrepid. The contact stated while driving approximately 25 MPH, the seat back fell backwards onto the rear driver's side seat. The contact grabbed the steering wheel and held himself up and safely stopped the vehicle. The contact braced the seat upright and drove the…
ODI #11324590 · Filed May 14, 2020
THE TRANSMISSION SHIFTER WILL ONLY GO INTO PARK EVERY ONCE IN A WHILE, ESPECIALLY WHEN ITS WARMED UP. *TR
ODI #11003653 · Filed July 7, 2017
AN OIL PLUG FRONT LEFT OF ENGINE BLOCK BLEW OUT PUMPING OIL ONTO CATALYTIC CONVERTER. OPEN FLAMES MELTED WHEEL WELL, BACK BUMPER, AND FUEL HOSES OFF OF GAS TANK. FIRE WENT OUT WENT ALL THE OIL WAS PUMPED OUT OF ENGINE AND CAR STOPPED MOVING. I CONTACTED CHRYSLER SAFETY, THEY REFERRED ME TO DODGE…

Read all 329 complaints

Owner-reported

2002 Dodge Intrepid mileage at failure

255 of the 329 complaints on file for the 2002 Dodge Intrepid give the vehicle's mileage when the problem happened.

Mileage at failure by component, from owners' complaints to NHTSA
Component	Median	Middle half	Based on
Engine	Median 80,000 miles	Middle half 60,000–100,000 miles	Based on 181 complaints
Power Train	Median 65,000 miles	Middle half 50,000–95,000 miles	Based on 51 complaints

A component's median is its 50th percentile, and its middle half runs from its 25th to its 75th percentile.

Owners give the mileage themselves, often as a round number, and NHTSA doesn't check it. A complaint that names several components counts under each one, and mileages that can't be right, such as 999,999, or 50 miles on a five-year-old car, are left out.

These figures describe the complaints owners filed. They don't predict when a particular vehicle will have a problem, and vehicles that never had one aren't counted.

Complaints received before December 15, 2002 rarely give a mileage, so they aren't counted here.

Mileage from NHTSA's complaints file of October 31, 2026. How these figures are worked out

NHTSA defect investigations

NHTSA's investigations file lists the 2002 Dodge Intrepid in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.

Preliminary Evaluation PE03-010: THROTTLE CONTROL FAILURE
Closed September 2, 2003

Open and recently closed NHTSA defect investigations

FMVSS 108/REPLACEMENT HEADLAMPS/AMBER REFLECTOR

NHTSA #09E025000 · Exterior Lighting — Headlights · NHTSA notice

Reported May 11, 2009 · DOPE, INC.

Potentially affected: 42,540 vehicles

Owners notified July 28, 2009

Defect description

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY DOPE, INC.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

FMVSS 108/AFTERMARKET COMBINATION LAMPS

NHTSA #09E012000 · Exterior Lighting · NHTSA notice

Reported April 7, 2009 · SABERSPORT

Potentially affected: 16,270 vehicles

Owners notified May 11, 2009

Defect description

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Safety consequence

DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Manufacturer remedy

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Notes

THIS RECALL ONLY PERTAINS TO AFTERMARKET REPLACEMENT EQUIPMENT AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES PRODUCED BY THE VEHICLE MANUFACTURER.IN ORDER TO DETERMINE IF YOUR AFTERMARKET LAMP ASSEMBLY IS AFFECTED BY THIS NONCOMPLIANCE, PLEASE REVIEW THE LIST OF MODEL NUMBERS PROVIDED TO US BY SABERSPORT.THE LIST CAN BE FOUND UNDER "DOCUMENT SEARCH" LOCATED AT THE BOTTOM OF YOUR SCREEN.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

DAIMLERCHRYSLER/SEAT BACK RECLINING BOLT

NHTSA #03V035000 · Seats — Front Assembly — Recliner · NHTSA notice

Reported February 5, 2003 · DAIMLERCHRYSLER CORPORATION

Potentially affected: 1,066,000 vehicles

Manufacturer campaign C04 · Owners notified April 23, 2003 · Vehicles built September 1, 1997 – April 27, 2002 (per NHTSA)

Defect description

ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.

Safety consequence

IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Notes

DAIMLERCHRYSLER RECALL NO. C04. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2002 Dodge Intrepid 4-DR.

—

out of 5

Overall Safety Rating

Not Rated

Frontal Crash

Not Rated

Driver: 4, Passenger: 4

Side Crash

Not Rated

Driver: 4, Passenger: 3

Side Pole

Not Rated

Rollover

Not Rated

Safety Technology

1 investigation

329 owner complaints have been filed with NHTSA for the 2002 Dodge Intrepid.

Seats

ODI #11458243

Incident: February 15, 2022 · Filed: March 24, 2022

The contact owns a 2002 Dodge Intrepid. The contact stated while driving approximately 25 MPH, the seat back fell backwards onto the rear driver's side seat. The contact grabbed the steering wheel and held himself up and safely stopped the vehicle. The contact braced the seat upright and drove the vehicle to his residence. The contact had not taken the vehicle to a dealer to be diagnosed or repaired. The contact researched and referenced NHTSA Campaign Number: 03V035000 (Seats) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 84,000.

Power Train

ODI #11324590

Incident: February 17, 2020 · Filed: May 14, 2020

THE TRANSMISSION SHIFTER WILL ONLY GO INTO PARK EVERY ONCE IN A WHILE, ESPECIALLY WHEN ITS WARMED UP. *TR

Power Train; Engine; Fuel/Propulsion System

ODI #11003653

Fire

Incident: June 27, 2017 · Filed: July 7, 2017

AN OIL PLUG FRONT LEFT OF ENGINE BLOCK BLEW OUT PUMPING OIL ONTO CATALYTIC CONVERTER. OPEN FLAMES MELTED WHEEL WELL, BACK BUMPER, AND FUEL HOSES OFF OF GAS TANK. FIRE WENT OUT WENT ALL THE OIL WAS PUMPED OUT OF ENGINE AND CAR STOPPED MOVING. I CONTACTED CHRYSLER SAFETY, THEY REFERRED ME TO DODGE CUSTOMER CARE; THEY INITIALLY CREATED A CASE #31892226 BUT THEN SENT A LETTER SAYING THEY WERE NOT RESPONSIBLE BECAUSE THE CAR WAS OUT OF A THREE-YEAR WARRANTY PERIOD AND ALSO UNSPECIFIED ENVIRONMENTAL FACTORS. ALTHOUGH MY WIFE AND SON WERE ALMOST IMMOLATED, IT WASN'T IMPORTANT ENOUGH FOR THEM TO CHECK INTO. THE CAR REMAINS PARKED AT A LOCAL GARAGE AWAITING INVESTIGATION.

Engine; Fuel/Propulsion System

ODI #10873686

Incident: June 8, 2016 · Filed: June 10, 2016

TL* THE CONTACT OWNS A 2002 DODGE INTREPID. THE CONTACT STATED THAT FUEL FUMES WERE EMITTING IN AND AROUND THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS LEAKING FROM THE TOP OF THE ENGINE AND THE CHECK WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 145,000.

Wheels

ODI #10786865

Incident: October 28, 2015 · Filed: October 28, 2015

TIRES CONSISTENTLY LOSE AIR PRESSURE AND MUST BE RE-INFLATED ANYWHERE FROM 5 TO 14 DAYS APART. TAKEN TO TIRE DEALER WHO INSPECTED THE WHEELS AND TIRES ON VARIOUS OCCASIONS OVER THE LAST THREE YEARS AND TOLD THAT THE TIRES ARE FINE, AND THE LOST AIR PRESSURE IS DUE TO THE WHEELS.

Air Bags

ODI #10766453

Incident: September 7, 2015 · Filed: September 21, 2015

TL* THE CONTACT OWNS A 2002 DODGE INTREPID. WHILE THE VEHICLE WAS PARKED, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE HORN AND CRUISE CONTROL FEATURE WERE ACTIVATED, BUT FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CLOCK SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 146,000. UPDATED 02/23/16*LJ THE CONSUMER CONTACTED THE DEALER. HOWEVER THEY REFUSED TO DO ANYTHING ABOUT THE AIR BAG PROBLEM. UPDATED 02/23/16.*JB

Electrical System

ODI #10761152

Fire

Incident: August 27, 2015 · Filed: September 3, 2015

WAS DRIVING SMELLED HOT WHEN GOT HOME 3 MILES LATTER OPENED HOOD COOLING FAN WAS SMOKING THEN CAUGHT ON FIRE

Air Bags

ODI #10660287

Crash 1 injury

Incident: November 21, 2014 · Filed: November 22, 2014

THE CAR HIT A PATCH OF BLACK ICE AND CAR SLID INTO ANOTHER VEHICLE GOING 55 MPH ON THE HIGHWAY. DRIVER WAS WEARING A SEATBELT AT TIME OF ACCIDENT AND THE AIRBAG NEVER DEPLOYED. DRIVER HAD FACIAL INJURIES AND ELBOW WENT THROUGH WINDSHIELD. VERY FORTUNATE THAT WAS ALL. *TR

Seats

ODI #10653012

Incident: October 27, 2014 · Filed: November 6, 2014

TL* THE CONTACT OWNS A 2002 DODGE INTREPID. WHILE DRIVING APPROXIMATELY 35 MPH, THE DRIVER SEAT RECLINED INDEPENDENTLY AND FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

Electrical System

ODI #10626647

Incident: January 10, 2011 · Filed: August 20, 2014

IGNITION SWITCH FAILURE. AFTER TURNING OFF CAR, SWITCH SLIPS INTO ACCESSORY POSITION AND DRAINS BATTERY. CAR DOES NOT START WHEN I RETURN TO THE CAR TO GO SOMEWHERE. I NEED TO PAY FOR A JUMP OR NEW BATTERY, OR TOW TO MY MECHANIC. THEN I HAVE TO KEEP REPLACING THE IGNITION SWITCH. THE ORIGINAL IGNITION SWITCH LASTED UNTIL 2011. THE AFTER MARKET IGNITION SWITCHES FAIL WITHIN ABOUT A YEAR. SOMETIMES WITHIN A FEW MONTHS. SINCE JAN. 2011, I HAVE HAD TO REPLACE THE IGNITION SWITCH ON 1/10/11 COST $147.50, 2/16/2012, COST $220.39, ALTERNATOR ASSEMBLY, COST $588.28 (MECHANIC THOUGHT IT COULDN'T BE THE SWITCH AGAIN), STARTER ASSEMBLY AGAIN 2/21/14, COST $384.23; RECOMMENDED I REPLACE THE RADIO SINCE THE ELECTRICAL SYSTEM SHORTED OUT 3/14/2014, COST $45:IGNITION SWITCH AGAIN ON 8/01/14, COST $110.56. ALSO THIS CAR KEEPS HAVING THE LEFT REAR TAILLIGHTS FAIL. THEY TELL ME THIS IS ALL PART OF THE ELECTRICAL SYSTEM SHORT WHICH THEY GUESS IS CAUSING ALL OF THE ABOVE PROBLEMS. BUT ALL THESE PROBLEMS DIDN'T EXIST UNTIL I MADE THE FIRST REPLACEMENT OF THE ORIGINAL IGNITION SWITCH. I BELIEVE THAT THE AFTERMARKET WAS FULL OF FAULTY GM IGNITION SWITCHES AND THERE WAS NO WAY FOR MY MECHANIC TO TELL IF WE WERE GETTING BAD GM DESIGNED SWITCHES. LUCKILY FOR ME AND MY PASSENGERS MY CAR DIDN'T FAIL WHILE I WAS DRIVING. IT ALWAYS HAPPENED WHEN THE CAR WAS PARKED. BUT HAVING 95 YEAR OLD PASSENGERS, ON HOT FLORIDA DAYS, GET INTO A CAR THAT WON'T START, CANNOT BE COOLED DOWN, CANNOT EVEN ROLL DOWN THE WINDOWS SINCE THEY ARE ELECTRIC , THESE CONDITIONS COULD HAVE KILLED MY ELDERLY FRAGILE PASSENGERS. THERE SHOULD BE SOME WAY OF INSURING THAT ALL THOSE BAD SWITCHES ARE REMOVED FROM THE AFTERMARKET. *TR

Other Dodge Intrepid model years

Check your 2002 Dodge Intrepid VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Dodge Intrepid at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Dodge VIN