NHTSA vehicle safety data
1999 Damon Daybreak Recalls & Complaints
The 1999 Damon Daybreak has 3 NHTSA recall campaigns and 3 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Damon dealer.
NHTSA recall and complaint data for the 1999 Damon Daybreak. Recall data is refreshed daily from NHTSA.
1999 Damon Daybreak owner complaints
Owners have filed 3 complaints with NHTSA about the 1999 Damon Daybreak, describing incidents dated December 2, 1999 to May 1, 2001.
Most-cited components
- Equipment 1 complaint
- Fuel/Propulsion System 1 complaint
- Suspension 1 complaint
Newest complaints
ODI #894465 · Filed
CONSUMER WAS PUTTING WHEEL COVER ON TIRES. WHEN HE PULLED HIS FINGERS BACK FROM THE TIRES WIRES WERE STICKING FROM VEHICLE. STEEL SPRING WAS STICKING FROM TIRES. MANUFACTURER WAS AWARE OF PROBLEM.*AK CONSUMER RECIVED A PRINT OUT THAT SHOWS THE FRONT TIRE HAD 1 DEGREE TILT IN AND THE RIGHT FRONT TIRE…
ODI #853593 · Filed
CONSUMER SAYS THAT VEHICLE COMES WITH FORD CHASSY. WHEN DRIVING IN RAIN CARBURATOR FILLS UP WITH WATER, AND THE ENGINE STALLS IN THE MIDDLE OF THE ROAD. THIS CAN CAUSE A BAD COLLISION ON THE INTERSTATE IN THE RAIN. DEALER TOLD CONSUMER TO PUT DUCK TAPE ON THE AIR CLEANER, THAT DIDN'TNOT HELP AT ALL…
ODI #847556 · Filed
THE SPARE TIRE COVER SEPARATED FROM THE VEHICLE WHILE DRIVING. THE DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK
NHTSA defect investigations
NHTSA's investigations file lists the 1999 Damon Daybreak in 1 investigation. A listed model year means only that an investigation names it; it says nothing about any particular vehicle. An open investigation is not a finding that a safety defect exists, and NHTSA can close one without a recall.
- Service Query SQ99-013: OMITTED EXHAUST HANGER
Opened May 19, 1999; no closing date on file
REFRIGERATOR/DOMETIC
NHTSA #07V130000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice
Reported March 20, 2007 · DAMON CORPORATION
Potentially affected: 25,128 vehicles
Owners notified June 26, 2007 · Vehicles built April 1, 1997 – April 30, 2004 (per NHTSA)
Defect description
CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Safety consequence
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Manufacturer remedy
DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT 1-800-860-3812.
Notes
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
DAMON/NORCOLD/REFRIGERATOR COOLING UNIT FIRE
NHTSA #01V091002 · Equipment — Recreational Vehicle/Trailer · NHTSA notice
Reported March 20, 2001 · DAMON CORPORATION
Potentially affected: 923 vehicles
Vehicles built May 1, 1999 – June 30, 2000 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
VEHICLE DESCRIPTION: MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS N841, N821, N641, AND N621. THESE REFRIGERATORS CAN EXPERIENCE A COOLING SYSTEM LEAK CAUSED BY OPERATION IN THE AC ELECTRIC MODE. IF A LEAK OCCURS, THE COOLING PERFORMANCE OF THE REFRIGERATOR WILL DETERIORATE, REQUIRING IMMEDIATE REPLACEMENT OF THE COOLING UNIT.
Safety consequence
EXTENDED OPERATION OF A LEAKING COOLING UNIT IN THE AC ELECTRIC MODE CAN RESULT IN A FIRE.
Manufacturer remedy
NORCOLD WILL INSPECT AND REPLACE THE REFRIGERATOR COOLING UNITS. NORCOLD WILL CONDUCT THE OWNER NOTIFICATION. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-767-9101 OR DAMON AT 1-937-497-3080.
Notes
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
DAMON/GENERATOR MUFFLER STRAP
NHTSA #99V202000 · Equipment — Electrical · NHTSA notice
Reported July 23, 1999 · DAMON CORPORATION
Potentially affected: 1,767 vehicles
Damon campaign 98-068 · Owners notified August 15, 1999 · Vehicles built July 9, 1997 – February 18, 1999 (per NHTSA) · Recall influenced by NHTSA's Office of Defects Investigation
Defect description
VEHICLE DESCRIPTION: MOTOR HOMES. A GENERATOR MUFFLER STRAP WAS OMITTED DURING THE INSTALLATION PROCESS.
Safety consequence
THE MUFFLER AND EXHAUST TAIL PIPE CAN VIBRATE LOOSE, POSSIBLY DETACHING FROM THE UNIT.
Manufacturer remedy
DEALERS WILL INSTALL A MUFFLER STRAP.
Notes
OWNER NOTIFICATION BEGAN AUGUST 15, 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAMON AT 1-219-264-2900.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
Other Damon Daybreak model years
Check your 1999 Damon Daybreak VIN
Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Damon Daybreak at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.
Check a Damon VIN