try.vin
Log in

NHTSA vehicle safety data

2004 Country Coach Intrigue Recalls & Complaints

The 2004 Country Coach Intrigue has 5 NHTSA recall campaigns and 2 owner complaints on file as of November 3, 2026. Recall repairs are usually free at an authorized Country Coach dealer.

NHTSA recall and complaint data for the 2004 Country Coach Intrigue. Recall data is refreshed daily from NHTSA.

Pre-purchase inspection checklist → Reliability & 5-year cost forecast →

2004 Country Coach Intrigue owner complaints

Owners have filed 2 complaints with NHTSA about the 2004 Country Coach Intrigue, describing incidents dated August 19, 2004 to February 10, 2005.

Most-cited components

  • Equipment 1 complaint
  • Steering 1 complaint

Newest complaints

  • ODI #10152160 · Filed

    RE: VEHICLE SAFETY DEFECT OWNER NOTIFICATION, 05V-373. AFFECTS VARIOUS COUNTRY COACH MOTOR HOMES. THE SUBJECT SAFETY DEFECT LISTS SEVERAL MODELS OF COUNTRY COACHES. MINE IS NOT INCLUDED IN THE LIST, HOWEVER THE SAME DEFECT HAS APPEARED IN MY MOTOR HOME, I.E. LARGE BLISTERS APPEARING ON THE HYDRAULIC…

  • ODI #10089323 · Filed

    A RECALL NOTICE WAS RECEIVED IN JULY FOR THE STEERING GEAR BOX. AFTER MAKING A CALL TO THE SERVICE CENTER AND GETTING A DATE FOR THE REPAIR AND TAKING IT IN AUGUST, IT WAS DISCOVERED THE PARTS WILL NOT BE AVAILABLE UNTIL SEPTEMBER. *JB

Read all 2 complaints

SIDE MARKER LIGHTS/FMVSS 108

NHTSA #08V119000 · Exterior Lighting · NHTSA notice

Reported March 13, 2008 · COUNTRY COACH INC

Potentially affected: 1,228 vehicles

Owners notified June 17, 2008 · Vehicles built June 1, 2003 – July 30, 2004 (per NHTSA)

Defect description

COUNTRY COACH IS RECALLING 1,228 MY 2004-2008 MAGNA, AFFINITY AND INTRIGUE MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUES SPECIFIED IN FMVSS NO. 108.

Safety consequence

INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A MOTOR VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL REPLACE THE MARKER LIGHTS ON THE SIDE OF EACH MOTOR HOME AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

REFRIGERATOR/DOMETIC

NHTSA #07V031000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported February 1, 2007 · COUNTRY COACH INC

Potentially affected: 2,406 vehicles

Owners notified March 19, 2007

Defect description

CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Safety consequence

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Manufacturer remedy

COUNTRY COACH WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). A SECONDARY BURNER HOUSING WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COUNTRY COACH AT 1-800-452-8015.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

UNEXPECTED SLIDE ROOM EXTENSION WHILE IN-TRANSIT

NHTSA #05V373000 · Equipment — Recreational Vehicle/Trailer · NHTSA notice

Reported August 29, 2005 · COUNTRY COACH INC

Potentially affected: 88 vehicles

Owners notified September 12, 2005 · Vehicles built May 1, 2004 – July 31, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES, THE HYDRAULIC SLIDE ROOM HOSES COULD BLISTER AND LEAK DUE TO ENGINE HEAT.

Safety consequence

LOSS OF HYDRAULIC FLUID COULD CAUSE THE SLIDE ROOM TO UNEXPECTEDLY EXTEND WHILE IN -TRANSIT. THIS CAN RESULT IN A VEHICLE CRASH.

Manufacturer remedy

DEALERS WILL RELOCATE THE HYDRAULIC HOSES OUTSIDE OF THE ENGINE COMPARTMENT AND REPLACE ANY HOSES THAT EXHIBIT SIGNS OF BLISTERING OR LEAKAGE. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

Notes

CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

COUNTRY COACH/HOLLAND USA/STEERING GEAR PLATE

NHTSA #04V259000 · Steering · NHTSA notice

Reported June 7, 2004 · COUNTRY COACH INC

Potentially affected: 527 vehicles

Vehicles built June 1, 2003 – May 31, 2004 (per NHTSA)

Defect description

ON CERTAIN MOTOR HOMES EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION (IFS) GEN II BUILT BY HOLLAND USA, THE GEAR PLATE SUPPORT GUSSETS WERE REMOVED. THIS CAN ALLOW THE PLATE TO FLEX DURING A STATIC STEER CONDITION.

Safety consequence

THE FLEXING MAY RESULT IN STRESS CRACKING WHICH COULD POTENTIALLY CAUSE A LOSS OF VEHICLE STEERING CONTROL WHICH COULD RESULT IN A VEHICLE CRASH.

Manufacturer remedy

HOLLAND USA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. A BOLT-ON STRENGTHENING OF THE STEERING GEAR PLATE WITH U-BOLTS CONNECTING THE CROSS MEMBER TO EACH SIDE OF THE GEAR PLATE AT THE REAR PLUS A TUBE SUPPORT IN THE FRONT WITH J-BOLTS TO THE GEAR PLATE WILL BE INSTALLED. OWNERS SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501 FOR INFORMATION AND INSTRUCTIONS FOR WHERE CUSTOMERS CAN TAKE THEIR VEHICLES TO HAVE THE REPAIRS DONE FREE OF CHARGE.

Notes

CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

HOLLAND/INDEPENDANT FRONT SUSPENSIONS

NHTSA #04E040000 · Steering · NHTSA notice

Reported May 28, 2004 · HOLLAND USA, INC.

Potentially affected: 610 vehicles

Owners notified July 28, 2004

Defect description

HOLLAND INDEPENDENT FRONT SUSPENSIONS P/N 90547917 IFS-114 WITH THE 90547978 SUBFRAME FOR USE ON CERTAIN COUNTRY COACH VEHICLES AND SHIPPED BETWEEN MARCH 5, 2003, AND JUNE 28, 2004. EARLY IFS-114 UNITS WITH P/N 90546687 USED A DIFFERENT SUBFRAME, P/N 90546691 THAT IS NOT AFFECTED BY THIS RECALL. THE NEW SUBFRAME DID NOT HAVE GUSSETS THAT HELP SUPPORT THE STEERING GEAR MOUNTING PLATE. THE LACK OF GUSSETS ALLOWS EXCESSIVE FLEXING OF THE STEERING GEAR MOUNTING PLATE WHICH MAY LEAD TO FATIGUE CRACKS.

Safety consequence

IF A CRACK WERE TO DEVELOP AND PROPAGATE TO THE POINT WHERE THE STEERING GEAR MOUNTING PLATE WERE TO SEPARATE FROM THE SUSPENSION SUBFRAME, THEN STEERING CAN BECOME LOOSE WITH POSSIBLE LOSS OF STEERING CONTROL. A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR EVEN DEATH.

Manufacturer remedy

HOLLAND WILL NOTIFY COUNTRY COACH'S CUSTOMERS AND PROVIDE REMEDY FREE OF CHARGE. OWNER NOTIFICATION BEGAN JULY 28, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501.

Notes

ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Other Country Coach Intrigue model years

Check your 2004 Country Coach Intrigue VIN

Not every recall applies to every VIN in a given year. Enter the 17-character VIN from your Country Coach Intrigue at nhtsa.gov/recalls to see whether your specific vehicle has an unrepaired recall.

Check a Country Coach VIN